Driving on highway, vehicle lost power. Ultimate diagnosed as a seized engine. Car was towed to our mechanic. After contacting Kia, they had us tow it to a local Kia dealer. After they diagnosed the same seized engine, they said they would not pay for repair, despite their being a class action suit settled by them. Car was brought back to our mechanic and a used engine was put in.
2016 Kia Sorento engine complaints
Page 20 of 25: complaints 551 to 580 of 722, newest first, as owners wrote them.
The engine is failing with the light on. It is not getting enough power and is a safety risk. I only have had the car for a year and a half and the dealership I have gotten it from won't do anything. It has had a air compression test, new spark plugs, and has been reviewed by multiply parties saying it is not deem road safety. I called the Kia dealership and it says all the recalls were done but it doesn't seem like it. They are saying i pretty much need a new engine, I have not even had the car that long.
Total engine failure. Piston rods tore through engine block. Thankfully the vehicle did not catch on fire.
The engine coolant system has failed due an inherent engine block issue resulting in the engine requiring replacement. This issue has been confirmed by dealer repair technician and manager. This appears to be a common issue with the 2016 Kia Sorento engines in particular.
We drive, a lot. Across state. On highways. Our car engine caught fire and everything shut off. Prior to that. I kept hearing a knocking noise, it was hard to accelerate. Jerky to brake. I was advised by Kia we were in that awful theta 2 claim, but now they won’t reimburse us for this mess. Don’t they have a responsibility after putting my entire family in danger?
On December 18, 2021, my 2016 Kia Sorento with approximately 20,100 miles, 2.4L Gasoline Direct Injection ("GDI") engine suddenly lost power on an eight lane Washington, DC area highway. The Malfunction Indicator Lamp (MIL) began to blink continuously. The first opportunity for an exit navigating through the construction zone, with the vehicle rapidly failing, was taken and the dealer, Ourisman Chantilly of Virginia, was contacted immediately. This confirms that the Kia Motors America, Inc. Product Improvement Campaign for the Electronic Control Unit (ECU) Knock Sensor Detection System (KSDS) was installed on January 12, 2019, with a mileage reading of 13,726 in the Commonwealth of Virginia at Ourisman Chantilly of Virginia. the federal safety agency Recall ID: 18V907000 for the high-pressure fuel pump leakage, Kia recall number SC172, includes 2012-2017 Sorentos. This could be a major fire hazard and pose a serious threat for injury or death. This vehicle has no safety recalls with the federal safety agency; the list of affected Sorento 2016 VINS excludes my vehicle. This dangerous defect of engine failure in a well-maintained, low mileage vehicle sold to me as a five-star safety rated "Pre-Delivery Inspection" (PDI) certified with no mechanical issues and examined as safe, may have had the apparent defects from the purchase date with the mileage delivery of nine (9).
I own a 2016 Kia Sorento with the 2.4L that is supposed to have a lifetime warranty on the engine due to the class action law suit apparently Kia which refuses to honor. I was driving on the interstate one day when my car started to go into limp mode and started to knock really bad my car eventually shut off completely and wouldn’t crank again after that I had it towed to Kia and they informed me that I needed a new engine and that Kia will not cover it for the fact that the car never received a knock sensor update( which I never record a notice in the mail for either by the way ) so now I have a car that isn’t drivable and I have to keep making payments on Kia should be required to honor the lawsuit and recall these vehicles due to this being a safety issue because the car gives you no warning what so ever and seems like more and more of these vehicles are having the same issue this is just ridiculous and I will never buy another Kia again after this
I was driving my vehicle up a hill. I accelerator a little. The car picked up speed then my oil light flickered and then stayed steady, along with the battery indicator. At this point my engine shut down and the car began to slow down. I came up on a side street that I turned into, because at this point the car was slowing down and loosing power and the breaks were not functioning, I would have either stalled and rolled backwards, or myself and my child would have been rear-ended. All the lights still work and everything come on, so I know its not the battery. My oil light flickered a little when I went around a turn a few times prior to this day, but never steady. No other indicator lights came on. The car is at my mechanics, who advises me the engine has seized and the vehicle has no oil. My last oil change was 3.5 months ago and according to the counter I'm only 99 miles over, which should not have caused this. Even though I was told I had up to 4,000 miles before I needed an oil change again. All of my fluids were checked at this appointment and this is the first major issue with my vehicle.
There are two major issues with my 2016 Kia Sorento LX (that I’ve just bought less than a year ago). 1- There seems to be some sort of electrical problem going on as my radio and headlights randomly go off when driving. While driving at 70 mph on the interstate AT NIGHT, my headlights when off and I couldn’t see anything! Thankfully I was able to get them back on because I had my children in the car with me. This could have caused us to drive right off the road or worse, hit/be hit by another vehicle. Unfortunately, I have not had a chance to get this looked at due to a bigger issue at hand. Which brings me to… 2- The most expensive and frustrating issue. The engine has seized up, which has been confirmed by a local service center. I have kept up the maintenance on my vehicle since I got it at the beginning of this year. Regular oil changes with full synthetic oil. While driving, again on the interstate, RPM jumped over 4 then down to 0, oil and battery lights came on, and vehicle was disabled. Waited 3 weeks to have it looked at to find that I’m just out of luck. Vehicle is not covered under warranty and there seem to be no open recalls, which I don’t understand given this is a painfully common issue with these models. So I either get to foot the $7,000+ bill for a new engine (which I can’t afford) or continue paying for a vehicle that I can’t even drive. To say that I am dissatisfied with my KIA would be a GREAT understatement.
The contact owns a 2016 Kia Sorento. The contact stated that while reversing out of the garage, she noticed there was a puddle of oil on the ground. The vehicle was taken to the dealer and diagnosed with an engine oil pressure switch leak. The oil pressure switch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact that they would contact her back in 3 - 5 days. The contact related the failure to the federal safety agency Action Number: DP21002 (Engine, Engine and Engine Cooling). The failure mileage was approximately 78,000.
The engine is burning oil per the dealership. This is a known problem with the vehicle, but the dealership claims it is not covered by warranty, nor has a recall been issued. I have to constantly add oil every 500-1000 miles. Other Kia engines have been recalled for this exact issue.
While my Kia Sorento had a chattering noise. When leaving home for an appointment l took the interstate and the chatter sound got louder about 10 minutes into driving. As I increased acceleration, the check engine light began to flash quickly and immediately The SUV started losing power and the engine stalled coasting long enough for me to pull to side of road. I tried to re-start the engine but it would not turn over to start. Twice in the past my husband took the SUV to Kia of Dayton Because car was losing oil with no warning light indicating it was low on oil. The mechanic explained there was a problem, he said that it had to be proven after a couple of oil changes and same problem occurred, which it has repeated twice. They said then they had to contact Kia for further instructions on how to proceed. The danger that affected my 91 year old Dad and myself is that we were stranded on a busy highway with no heat on a cold winter day. I had to find transportation to get my Dad home, because he takes blood thinner which causes him to get cold very easily.
have a 2016 kia Sorento, 4 cylinder, 2.4 L engine with 74.5k miles. The ecu upgrade was performed in 2019. This month while driving, the engine lost power and the car would shudder. The oil dipstick showed no oil and the oil light and check engine lights were illuminated. The car was towed to the local dealership. The dealership mechanic found that cylinder #2 had only 30psi of pressure and 90% leakage and a possible burnt exhaust valve. Error code P030200 was also present. Their recommendation was to replace the engine. HOWEVER, they say these repairs are NOT covered by my extended warranty OR the lifetime warranty coverage resulting from the Kia Theta II class action lawsuit. I feel this engine failure is covered by the Kia engine class action lawsuit and the dealership and warranty company are not honoring the class action settlement.
Oil burns fast into catalytic converter. Dealer and corporation know of problem bit won't recall. Many people are complaining about the same thing. It's a safety fire Hazzard 🔥
My wife was driving to work when the engine lost power and started making a rattling noise. I took the vehicle to my trusted mechanic who informed me that the engine needs to be replaced due to excessive oil consumption. Not once did I receive any type of oil warning light on my dash informing me of an oil issue. My vehicle has almost 1,000 miles left before the next scheduled oil change. My engine is destroyed and it is going to cost 4,500 dollars to replace with a [XXX] engine from a SALVAGE YARD. But I have no other option because I cannot afford anything more. In December, three weeks before Christmas. This is unreal that this vehicle consumes that much oil. My car has 57,000 miles on it. It's basically new. Now I have to depreciate its value and probably reliability with an engine from a totaled car. Despicable. There NEEDS to be a recall on this and reimbursement to those who had to buy a new engine. Safety concerns: My wife drives my children to school every day in that car. Luckily it failed when they weren't inside. My wife had to drive the car miles home at an unsafe slow speed causing a road hazard. Components have not been inspected by the manufacturer yet but will be sent to Kia by my mechanic. NO WARNING LAMPS UNTIL MY ENGINE WAS TAKING ITS LAST BREATH ON THE WAY TO THE MECHANIC. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
The 2016 Kia Sorrento we drove for 6 months, odometer reading under 82 000 mi had complete engine failure with no warning. It started to rattle when shifting to a new gear and completely broke down on the way to the dealership the next day. The Kia Dealer has confirmed the engine failed. We had no warning of engine issues.
My children and I were on the freeway, and when I pushed the accelerator, nothing happened. No rpm increase, no engine change…nothing. I have had my car looked at and diagnosed, and nothing alerts to being wrong. The screen said Engine Control System, the engine light came on, and I had to pull all the way over across 4 lanes of traffic on the freeway, without being able to accelerate. I pulled over, put the car in park, and waited about 10 minutes. I turned the car back on and everything was fine. I do not understand. This is a safety hazard!
My vehicle without any warning whatsoever, completely shut down while driving in interstate traffic. This was a very dangerous thing to happen while driving on a busy interstate. I was able to get to the side of the road but the vehicle would not start. I had my vehicle towed to my mechanics shop where he determined that the motor had failed due to cylinder/piston damage. I was denied coverage by KIA so my only choice was to pay my mechanic to replace the motor with a remanufactured motor at a cost of $9000.
I just bought my car in March of this year. It started overheating so I brought it to the mechanic where I was quoted $9,000 for a new motor. I still owe $17,000 on it. Was completely disrespected at the dealership by the service department. So now I’m stuck with a car that doesn’t drive and a huge loan I have to pay out. I was told that the oil level in my car was extremely low. I just recently had it changed and wasn’t due for over a month for another. No light sensor or anything went off.
I was driving 85 MPH on the interstate and my engine lights started flashing (no engine light or oil light prior to this) and started slowing down. I got to the shoulder of the interstate and my car was making a terrible knocking noise. I have owned this car for 3 months. There is a little over 87K on my car. I had the car towed to the nearest Kia dealership where I was told my engine was totaled. After paying 140.00 for a diagnostics report and being without a car for a whole month (keep in mind this is just for the report). I was quoted a total of 6,800 for them to fix my car. After further research I have found other people with the same issues with the engine. My engine is a 3.3L V6. In the previous lawsuit for Kia it only covers 2.4L engines where my engine is having the SAME issues. I should not have to pay for a new engine when this is a big issue with other consumers with the same car and engine type. Now im stuck paying on a car I CANT DRIVE until the 6800 is paid. I owe to much on my car for me to pay it off in full. This put me as well as everyone else on the interstate at risk and would have also put my children at risk if they were in the car. I am beyond irritated. As well as a given a whistleblower just coming out to state that these engines are not safe and kia and hyundai's neglect in keep their consumers safe. SOMETHING HAS TO BE DONE!
I just purchased my Kia Sorento in March of 2021. It doesn’t notify you when oil is LOW or OUT. Even with proper oil changes. Also the engine randomly started to overheat regardless that it’s barley got 107 miles on it. Of course there’s several recalls for this particular vehicle for the same issues but not for mine specifically. Insurance won’t cover wear and tear so now my cars in the shop for who knows how long with an extremely high bill expected.
The contact owns a 2016 Kia Sorento. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic where the contact was notified about a knocking in the engine. The contact was informed that the engine needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 103,000.
Engine failed while driving. No warning lights. Have to purchase a new used engine. Fan blower resister: only blows at high or not at all. Has been fixed once and is now an issue again.
Car failed while driving and now has a rod know and low oil
The contact owns a 2016 Kia Sorento. The contact stated that while driving at an undisclosed speed, the check engine warning light was illuminated. The vehicle was taken to the dealer and an independent mechanic on separate occasions. The dealer and an independent mechanic diagnosed the vehicle with engine failure. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 128,459.
On Saturday 10/23/2021, I picked up my car at Kia Ron Bouchard Lancaster MA. They explained to me that warranty coverage is only extended if the problem was presented in PI1802. That wasn't my problem. I contacted another Dan O'Brien Kia dealership in Norwood MA, and found that one of the problems that might have caused my car to malfunction was a safe recall that was not made and therefore I lost my warranty. But I went to Kia several times and they always said they didn't have the parts to recall. In the document it says that my car would have the rod bearing warranty if it were failing. Asking another dealership he explained to me if when I presented the oil consumption problem on 07/23/2021 the part could already have problems. What are the symptoms of a bad rod bearing: Low Oil Pressure - Many times when a bearing is beginning to fail (or has failed), you will noticed signs of decreased oil pressure. This is usually more evident upon first starting the vehicle. In many cases, a bad rod bearing will lead to a "check engine oil" light being displayed on the dash. (Problems that were happening in my car when I was at Kia on 07/23/2021). Another explanation that the dealership gave me is that my car was showing excessive oil consumption and burning of oil and a problem that may have been caused by the defect of the part of the safe recall (E-CVVT COVER AND MOTOR PLUG REPLACEMENT) that was not made, which as a result occurred the Misfire and the cylinder lost compression. E-CVVT Cover defect could cause Late valve timing will keep the intake valve closed too long after the intake stroke has started, and will increase the vacuum in the cylinder. The high vacuum will have a tendency to suck oil up past the piston and rings into the upper part of the cylinder where it will be burned.
Basically my car stalled on me while driving on the feeder of the freeway. I had all three of my children inside the car so luckily nothing bad happened when my car died. I had to tow my car to a mechanic who later informed me that my engine had pieces of metal inside it. He then explained that the dealership should replace our engine since there has been recalls for this same issue on Kia Sorento. At this point, I called the dealership and they refused to replace our engine and stated that I should of done a previous recall (an upgrade). I advised them that I never received any information in regards to a previous recall and I actually had went online a few months ago and checked for any recalls. My Mom had ran across a website and we all checked all of our vehicles for recalls. My Kia Sorento had no recalls. What is my next step to get the Kia Dealership to fix my vehicle? Ive already called the main number to Kia and they were no help either. Thank you for your help!!!
After accelerating from a stop, the engine started making a loud clunking noise and was losing power. The vehicle was towed to a certified Kia dealership where it was determined to be a rod bearing failure in the engine. The engine needs to be replaced and is not covered under any warranties due to a sensor not being updated. I was never notified of any recalls which the sensor update was. I have owned this vehicle for two years and was never notified of any recalls.
My car had no warning light on the vehicle. However while my husband was driving 80 MPH on the engine started making a loud noise and stalled on the interstate. After research and taking it in for a diagnosis test its came back that the engine is rapidly burning oil and did not notify us when we were low on oil. Since then I have researched and found a TON of other 2016 kia Sorento having the SAME EXACT ISSUE! However there is no recall for this! This is not only EXTREMTLY unsafe but also extremely expensive to fix for something that is not our fault but rather the manufacture. My husband knows how to react in situations like that but if it was me it would have not only put me in danger but also my children and any other drivers that were near me. This needs to be recalled especially due to the abundant amount of people with the same year and make of vehicle having the same exact problem. Do something to protect us as this is absolutely ridiculous that this big of an issue is not under recall. I am now coming out of pocket to fix this issue which is alot of money.
Excessive oil consumption, that is, more than 1 quart consumed every 1 thousand miles, beginning around 68,000 miles. At subsequent oil change (12/20, 72000), crankcase was nearly empty. Next 3000-mi oil change, engine dash indicators noted oil pressure issue - this was with 74000 miles on odometer. I added 2 quarts of oil to crankcase immediately. I took the vehicle to the dealership where I purchased vehicle (their 'service warranty' mandated I go to the original seller (Mitsuibishi)). I disagree with their findings. Mitsuibishi El Cajon performed the oil consumption test (Kia) reporting after 1000 miles, the oil consumption was in accord w Kia Technical Bulletin 222. However, I am adding 1 QT of manufacturer's recommended oil every 3 weeks and now change oil every 30 days. I cannot sell this vehicle in this state and when vehicles are in short supply. For a vehicle with currently 86000 mi, this is Unacceptable!
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Kia Sorento?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history