2020 Kia Sorento electrical problems

Filed Sep 26, 2026 · Electrical, Engine · MA · fire

Driving at highway speed, the vehicle began to make a loud rattling noise that came from under the vehicle. A passerby pulled even with my car and began frantically gesturing. After a few seconds of confusion, me daughter said the she thought the man was saying "it's on fire." We pulled over to the shoulder of the road, exited quickly and realized there was fire visible in the engine area, seen through the grill. A good samaritan attempted to suppress the fire with an exstinguisher but moments later, it was fully engulfed.

Filed Jul 12, 2026 · Airbags, Driver assistance · MD

Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all flickered and dash dings. Two independent shops ran diagnostics and noted that only battery was dead. Replaced battery and the lights came back immediately.

Filed Mar 20, 2026 · Electrical, Engine · FL

My Oil Pressure Switch is diagnosed as faulty by independent service center as well as Kia. Kia is denying coverage. I have found information that it should be covered. My check engine light shows an oil can light.

Filed Feb 18, 2026 · Electrical, Fuel system · FL · fire

To the Office of Defects Investigation, I am submitting this formal complaint regarding the federal safety agency Recall 22V703000 (Kia Recall SC249) involving my 2020 Kia Sorento (VIN: [XXX] ). This recall identifies a fire risk due to a potential electrical short in the tow hitch harness module. The recall notice specifically warns that a vehicle fire may occur while parked or driving. After receiving the recall notification, we made multiple attempts to schedule the required repair with Pompano Kia, the authorized dealership in our area. Despite repeated efforts, we were not provided with a confirmed repair appointment, and the recall remained incomplete. On [1-19-2026], before the recall remedy was performed, the vehicle caught fire while being driven on a highway in Florida. The vehicle became fully engulfed and was declared a total loss. Law enforcement and/or fire services responded. The incident appears consistent with the fire risk described in the recall. Following the incident, we visited the dealership to report the fire and the unresolved recall. We were told the matter would be reviewed and that we would receive a follow-up call. No follow-up was received. Attempts to contact the dealership through publicly listed email addresses resulted in delivery failure notices. According to the federal safety agency records, this recall affects tens of thousands of vehicles nationwide. We are concerned about: • Timeliness and availability of recall repairs • Dealership accessibility and communication • Risk to consumers when recall remedies are not completed before failure occurs We also attempted to consult several attorneys regarding this incident. We were advised that due to the volume of recall-related fire cases involving this manufacturer, representation may not be feasible unless severe bodily injury is involved. This further raises concern about the scale and seriousness of the issue. We respectfully request that the federal safety agency review: • Whether recall 22V703000 is being remedied INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Filed Jan 16, 2026 · Electrical, Engine · OH · fire

I was driving 2 minutes away from my house and all of the sudden every warning light on the dashboard came on, billowing smoke started coming through the vents. I immediately pulled in a random driveway, as I was turning I. I heard a loud pop. I shut the car off immediately, jumped out. As I looked at the front of my car, flames were coming from the bottom front. I ran up to the house, the man of the house came out with a fire extinguisher. He put out the flames underneath, asked me to pop the hood, I did so and he put out the flames underneath the hood. As I was waiting for a tow truck, I seen a shiny object at the bottom of the vehicle, I pulled it out. It was a wrist pin from the engine. I also noticed a ton of fluids poured out in the man’s driveway. I had the vehicle towed home and contacted Kia and my insurance company. My case was escalated to Kia corporate and Elizabeth Barooni contacted me. She promised to tow my vehicle to the dealership of my choice, get me a rental car, pay any out of cost expenses and repair the vehicle. The vehicle only had 75,000 miles on it. After all her promises, she never contacted me again. I have tried to contact her and a Kia number called me, I answered they hung up on me. I called the number back and it was James Hope, an employee who works at Kia America Corporation. They have not returned my call since around Christmas. I also contacted GEICO, my insurance company, they sent out a adjuster, they denied my claim. They stated that all of this was caused by mechanical failure, they put on the claim that Kia is known for these issues and they will not cover it. I still remain without a vehicle and Kia Corporate has completely ignored me after making promises to help.

Filed Jan 11, 2026 · Electrical, Engine · OH · fire

To Whom It May Concern, I had a horrible experience with my 2020 Kia Sorento and I can't seem to get anyone to respond to me. This very upsetting. My VIN number is [XXX] , my vehicle only had 75,000 miles on it. I kept up with all maintenance, oil changes, checking oil on a regular basis, checking all fluids, including antifreeze, brake fluid as well. I was driving on a clear day, no snow, no rain, no traffic, country road. I was going about 35 MPH and all of the sudden every light that I could possibly think of came on my dashboard, within 30 seconds of that I heard a very loud pop and smoke barreled in through my vents. Obviously the smoke made it a struggle to breathe and definitely is not good for mine or my children lungs. I immediately pulled into the first driveway I seen. This took 5 seconds from the loud pop and the smoke through the vents, actually not even 5 seconds. I jump out of my car and see a fire under my hood. I immediately run up to the house of the driveway I pulled in. Fortunately, the man of the home, seen what was happening, ran to his garage, got a fire extinguisher and put the fire out. I look under the car. I seen something very shiny lying on the ground, right under where the fire was. It was piston cylinder piece This explains the pop, the fire and nearly every fluid that was in my car now on the ground. Oil, antifreeze and brake fluid were all now spilled in this man's driveway. I called Kia and reported the incident, they stated there were no recalls on my vehicle, according to the VIN number. They also stated the year 2020 did not have recalls, like the years leading up to 2019, stopping at 2020 and then resuming at 2021. Elizabeth from Kia America Corp made promises she didn’t keep by stating they would tow my car to Kia dealership and give me a rental. She promised to make it right and was caught lying, she never contacted the dealership. Elizabeth’s phone number [XXX] . Please help me, my kids and I need a vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (

Filed Dec 28, 2025 · Electrical, Engine · OH

I have placed below what I have sent to Kia company.

Filed Dec 28, 2025 · Electrical, Engine · OH

I wanted to add to a previous claim I had already submitted, I found an item that had fallen out of my engine, I don't know if I can submit a picture on here but I will try.

Filed Oct 23, 2025 · Electrical, Lights · WI

The contact owns a 2020 Kia Sorento. The contact stated that while driving at an undisclosed speed, the headlights became inoperable. The blinkers and the radio were inoperable for several seconds before returning to normal function. The contact stated that the failure had occurred several times while the contact and the contact's wife were driving the vehicle. The contact stated the failure was a major safety hazard, especially while driving at night. The vehicle was taken to an independent mechanic; however, the failure was not duplicated. The dealer was made aware of the failure; however, the contact was required to pay a fee for a diagnostic test. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Filed Oct 17, 2025 · Electrical, Lights · UT

My headlights went out completely and without warning on a dark highway. No brights or even the orange running lights. Not even the front hazard lights would go on. There was no warning until after they went out. I pulled over as best I could but there was very little shoulder and semi trucks speeding past me at 70 mph about a foot away from my car. There was a ditch about a foot to the right. I stayed in my car and turned the interior lights on until after highway patrol officer escorted me to a safe turn off. Thankfully my rear hazard lights were working. My husband had to drive a hour to come pick me up. I got home 3 hours later than originally planned. I talked to a mechanic who said it was likely a fuse that went out. I asked him why there was no warning and he said the warning for the lights is likely on the same fuse as the lights! How is that helpful?! We weren’t able to find the right fuse late at night in the dark, so we had to leave it on the side of the road about 60 miles from home until we could go to an auto parts store and drive it home in the daylight. It was a very dangerous situation. I could have been killed.