2012 Kia Sportage electrical problems

Filed Jun 26, 2026 · Electrical, Engine · WA · fire

I was driving eastbound in my 2012 Kia Sportage on I-82 just past Benton City MP97 at about 11AM on Monday June 22, 2026, when my engine knocked twice, the red check engine light came on, and I lost power. I pulled over off the road next to a concrete barrier that was beside a rock roadcut. My flashers would not operate, I put it into park, turned off the ignition and immediately noticed the smell of burning oil or rubber. I had 2 half gallon containers of water on my front seat, so I popped the switch, lifted the hood, used the prop rod to hold the hood up as I started dowsing the flames that were popping up on the passenger side of my engine compartment near the firewall. After using both half gallons, I ran to the rear of the vehicle, opened the hatchback, and grabbed a gallon spray bottle of water and brought that back around to the front of the vehicle. By this point the prop rod holding the hood was bending and the flames were popping back up, I pumped the sprayer and directed a stream of water with my left hand and used my right to hold up the hood as the prop rod was not working. After the fire was completely out, I returned to the rear of the vehicle, donned my reflective vest, put a portable flasher on my vehicle, and at this point a Benton County fireman in a pickup arrived - he was called by a motorist that saw me pulling over with smoke trailing my vehicle. The fireman was followed by a large firetruck and crew. They propped up the hood with a bar and inspected the motor to verify the fire was completely extinguished. They took my information and left. A Washington State Patrol arrived, assessed the scene and offered assistance, but I already had called my wife so he left me to wait for her. He told me I had 24 hours to get the car off the interstate. I had the car towed to my driveway by A&E towing at about 2:30PM. I just realized this morning that I ought to report it to you. I haven't tried to start it, but I'm sure it won't.

Filed Apr 18, 2025 · Electrical · NC

The car has been giving off a burning smell each time that I begin to drive especially if the heat is being utilized. The smell worsens as I drive a further distance.

Filed May 11, 2024 · Electrical · NY

I am writing about a recall notice that was issued last fall (2023) and has not yet been repaired by KIA, this vehicle's manufacturer. The HECU unit has a bad fuse that can cause a fire while driving or when parked. The relevant data is: Manufacturer Recall NumberSC284SL the federal safety agency Recall Number23V652 Recall StatusRecall Incomplete, remedy not yet available This waiting period has been excessive. KIA needs to get this done!

Filed Apr 22, 2024 · Electrical · OH

See attached letter

Filed Feb 8, 2023 · Electrical, Engine · 127,000 miles · PA

The contact owns a 2012 Kia Sportage. The contact stated while driving 45 MPH, the check engine warning light and several unknown warning lights illuminated, and the vehicle started to stall. The contact depressed the brake pedal, stopped, and parked the vehicle. The contact stated that the vehicle failed to restart. The contact shifted into neutral and pushed the vehicle to the side of the road. The contact stated that the vehicle failed to restart upon attempting to jumpstart vehicle with the assistance of a friend. The vehicle was towed to the Mazda dealer where it was purchased. The dealer diagnosed that the engine, the starter, the battery, and unknown parts needed to be replaced. The Kia dealer and manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 127,000.

Filed Dec 24, 2022 · Driver assistance, Electrical · AR

The day I drove the car off the lot after purchasing (roughly 4 years ago) the low tire pressure sensor came on and I was unable to get it to go off. Mentioned it to the dealership whenever I went back for my first oil change and they told me they were able to “wake it up” whenever they checked the tire pressure. It continues to not accurately read if the tire pressure is low or not. A couple of months ago (summertime) my sunroof would not close. I finally got it to close completely after having to turn the car on and off multiple times and I have not risked trying it again since. The biggest issue I’m having now is about a month ago (November) I went to start my car and not only would the engine not turn over, but all the lights kept flickering as if the alternator was going out. I not only replaced the alternator, but also have to get a brand new battery because it was completely drained and would not jump within a day. Now, a couple days ago, I went to start it again and it did something similar - though after doing some troubleshooting I think it might be a bad starter this time that has now killed my battery. Both of these times my car did not show any type of warning lights. My concern comes from the fact that several recalls for the exact same make/model/year of the vehicle I’m driving have been coming out and one of them includes the engine just “freezing up” or “dies for no reason” including while people are driving at highway speeds. No recall has been posted for my specific VIN number yet, but I’m concerned it’s just a matter of time based on these continued issues I’ve been having.

Filed Jun 18, 2022 · Electrical, Engine · MI · fire

My vehicle had just recently been parked and turned off after only having driven 10 miles. Upon returning to my car less than 5 minutes later, a plume of white smoke and a small flame could be seen below the hood of the car. Within minutes the entire engine was engulfed in flames. By the time the Fire Department arrived, the blaze had already reached the rear of the vehicle. Everything was completely lost.

Filed Apr 14, 2022 · Electrical, Engine · 150,000 miles · IL

The contact owns a 2012 Kia Sportage. The contact stated while driving 60 MPH, the engine seized. The check engine warning light illuminated. The contact veered to the side of the road. The contact was unable to restart the vehicle after several attempts. The vehicle was towed to an independent mechanic where it was diagnosed that the engine had seized and the starter was damaged. The vehicle was not repaired. The vehicle was then towed to the local dealer where it was diagnosed that the engine had seized and needed to be replaced. The dealer sent a diagnostic report to the manufacturer; however, the manufacturer declined to cover the repair of the vehicle. The contact became aware of the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling) which he associated with the failure. The vehicle was not repaired. The failure mileage was approximately 150,000.

Filed Mar 30, 2022 · Electrical, Engine · IL

Was driving suv when sudden loss of power to engine, pulled off of highway and loss all power to electrical and to engine, I could smell something burning, upon further inspection after having suv towed to repair shop, I was informed that starter had melted and engine had seized up, I have contacted Kia dealership 3 times with no response from them, I also contacted Kia corp and no response, I also notified the BBB, I know there was a lifetime engine repair of this vehicle and some recall on bearings, I did have knock sensor done as required, I am looking for help in filing a complaint and copies of any recalls that were ever issued to this vehicle, I do not get recall notices sent to me, I own 4 cars, all Kia, other 3 not having issues yet, any help would be appreciated. Consumer stated the warranty has expired, but never received any notices of recalls.

Filed May 26, 2021 · Electrical · PA

My vehicle ran out of fuel, before the fuel gauge came close to "empty". The light had just come on in the past five miles, which usually indicated I had about ~30+ miles before the gauge hit "empty". It is not an electronic speedometer. I have never had that issue before. Surprisingly, I had never had this issue before. I refueled it, and it was seemingly okay. That was Sunday. Friday of the following week, I had my vehicle state inspected (PA), where it did not pass. They had to fix several issues with the rear rotor (reoccurring issue). Once it was fixed, they passed the vehicle. I had asked them to investigate the fuel issue I had. Two days later, my vehicle was less than half on the fuel gauge. I was on the highway, and suddenly I couldn't accelerate anymore. The fuel, battery, and engine lights all appeared on my dashboard. I smelled burning briefly. I went to the side of the highway and waited hours for AAA to jump my car and fuel it back. None of the options worked. I towed the car from AAA to Kia Wexford, at AAA's recommendation to get the car inspected to see if this issue was related to the recall. When the dealership finally looked into the issue, they said they wouldn't even investigate the engine issue, because I had not had the software update for the engine "downloaded" in time. The car was transferred to my name after this time period. They did state the engine would need to be replaced, paid for by me, for a total of $8k. I feel taken advantage of.