2023 Kia Sportage brakes problems

Filed Jun 15, 2026 · Brakes · OH

I have had repeated failure/wear of my rotors on my 2023 Kia Sportage X-Pro Prestige, starting at about 12k miles and recurring roughly every 3 months from there. I have had multiple dealers look at it and they keep blaming me for the problem. I am not a rough driver, I drive mostly freeway, do not brake constantly or hard unless absolutely needed, etc. The symptoms are that typical vibrating of the car when stopping and the brakes have been squeaking terribly since the first replacement, they have never not squeaked even though I asked them to address it. Neither the dealer or Kia Corporate are helpful, this is obviously a defect as multiple online forums talk about the issue consistently with this car. I had a case open with Kia to find the cause so I can stop fixing the system, but they were unsuccessful in doing so. I just want it to be fixed so I can stop wasting time and money, I bought a brand new car for the first time ever to avoid worrying about repairs for a while. Biggest regret ever and based on how I have been treated I will never buy Kia again.

Filed May 29, 2026 · Brakes, Driver assistance · KY · crash

This is a statement from my daughter: I was driving and noticed a vehicle stopped in front of me. When I attempted to brake, I could feel my brakes sink all the way to the floor. I also didn't receive an alert from the Front Collision Avoidance system or any assistance from the Automatic Emergency Braking system. The vehicle was a CPO that had always been serviced at the dealership. Because of various surgeries I have had, depending on the severity of the crash, I could have been paralyzed for life.

Filed Apr 21, 2026 · Brakes · CO

Vehicle: 2023 Kia Sportage Issue: Service Brakes / Premature Rotor Failure / Grinding Within approximately six months of purchasing my vehicle new, I experienced brake grinding and premature rotor failure. This condition has reoccurred multiple times despite repair attempts at authorized Kia dealerships, including rotor replacement under a Technical Service Bulletin. Multiple dealerships acknowledged the issue. A Kia service manager advised that factory brake and rotor components are prone to premature failure and stated that reinstallation of original parts would likely result in recurrence. They recommended aftermarket brake components to correct the defect. Despite this acknowledgement, Kia America has failed to provide a permanent fix and continues to rely on reinstalling the same materials associated with repeated failures. The defect remains unresolved and presents an ongoing safety risk due to compromised braking performance. This issue appears consistent with known defect patterns affecting Kia Sportage vehicles manufactured between 2022–2024, with widespread consumer complaints reporting premature brake wear, grinding, vibration, and repeated rotor failure. I am submitting this complaint due to the safety implications of repeated brake failure, Kia’s failure to implement a corrective remedy, and the risk posed to drivers and the public.

Filed Dec 18, 2025 · Brakes · CA

I took my car in several times to complain about the rotors and brakes. They said everything was fine but then the vehicle failed on the road so we had it taken to the nearest repair shop since we were on a road trip. Now Kia which has a fix to the damaged parts refusing to replace the defective parts.

Filed Nov 28, 2025 · Brakes, Engine · CO

My 2023 Kia Sportage AWD has several ongoing safety issues that have been happening for over a year. The car stalls or hesitates at low speeds and during acceleration. I hear grinding or whining noises from the front end and drivetrain. My brakes wore out very early and still feel inconsistent, and the automatic braking acts unpredictable. The AWD system sometimes feels unstable when I try to accelerate. The tire pressure warning light comes on often even when the tires are fine. These issues happen randomly and make the car feel unsafe to drive. I am reporting this for safety investigation.

Filed Nov 18, 2025 · Brakes, Electrical · PA

Initially in May 25, my Sportage started accelerating on its own, unprompted, up to 4500 RPMs many times and also hesitated. In 6/25 the info screen, (whole dash) went black 4-5 x’s for about 3minutes while driving 60 mph on bypass. Beginning of July, Siri didn’t work and said it was inaccessible, and also the navigation said it was not updated however, when I pulled into the dealer, all of a sudden it worked? On 7/23 I was turning into apt complex and had no brakes! I had slowed to about 20mph, car behind me, and couldn’t make that turn so I coasted up to next entrance and was able to turn in. Fortunately, I was able to stop in my handicap pkg spot. I had already made appt for the initial issues at the dealer, Moyer Kia in Lebanon, for first week of August, but immediately called them on 724 and explained the absence of breaks! They told me to get car there right away, so I did. I gave a list of all above info, they were able to give me a loaner, Kia G6. This was very inconvenient for me as most of my back is fused and I provide transport for my [XXX] /o mom w/Walker, but I can’t go w/o a car! Moyer has had my car since 7/24,. With the exception of need for miles on the loaner communication was poor. I tried to reach Kia Corp multiple x’s to no avail. I was told by Brian at dealer that my case had been escalated to the national safety board and they were advised not to touch my car pending investigation. So it sat there for months I got a message from Kia Connect that my battery was dead, more communication than I had received throughout this whole experience! Last week, Thursday I had called corp who said they sent me an email on 1023 to tell me nothing is wrong with my car, they also emailed the dealer. I hadn’t checked email, nor did they call, so I didn’t know, dealer called me on Friday to come and get my car, but first they had to grind the rust off of rotors, recharge the battery and would I like them to inspect it?, NOTHING IS WRONG? THIS CAR is NOT SAFE!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM

Filed Aug 12, 2025 · Brakes, Engine · OH

Purchased a CPO Sportage XPro April 2025. As I am unfamiliar with the mechanisms of Kia, unbeknownst to me, my engine revved the first week of purchase. Since this incident, the engine has revved while braking on [XXX] while driving down a city street. The next incident occurred on [XXX] , while exiting the highway and coming to a stop. My passenger, who happens to be a mechanical engineer asked if bumped the gears for the engine to revv as it did, which I did not. The fourth occurrence was [XXX], while driving city streets and coming to a stop. I contacted Kia after the [XXX] incident and they drove the car and could not duplicate my safety concern. When the engine revvs while braking, there are no malfunction warnings messages and goes back to normal within 30 seconds or when I shift back to park and drive. As the safety issue is intermittent, not sure if there is a scheduled duplication of the occurrence. Nonetheless, in review of several complaints via the federal safety agency, I see a similarities in the federal safety agency Campaign 23-V-410 and wondering the applicability to my Sportage despite no recalls. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 16, 2025 · Brakes, Engine · AL

The issue appears to involve the CVT (Continuously Variable Transmission) system or the transmission fluid/lubricant pump. The vehicle jerks or hesitates when accelerating from a stop, as if struggling to shift properly. The check engine light comes on repeatedly. This issue is ongoing, and the vehicle is available for inspection upon request. The jerking and hesitation when trying to drive, especially from a stop or when merging into traffic, poses a safety risk to myself and others. The delayed or unpredictable response could easily lead to an accident in high-traffic areas, intersections, or when making turns. Yes. The issue has been observed multiple times. The check engine light has returned even after replacing the O2 sensors, and a trusted mechanic believes the problem may be transmission-related. However, the Kia dealership claims there are no active recalls tied to my VIN, even though publicly available information lists powertrain- and fluid pump-related recalls for my vehicle's year and model. The vehicle has not yet been inspected by Kia corporate. I reached out to the local dealer, who denied any applicable recall. I am submitting this complaint in hopes of an official review and inspection by the manufacturer or the federal safety agency to determine if the issue qualifies for safety recall intervention. Yes. The check engine light first appeared months ago, which led to replacement of the O2 sensors. Shortly after the replacement, the light returned, and the car began jerking while trying to drive or accelerate from a stop. These symptoms have persisted and appear to be worsening.

Filed May 9, 2025 · Brakes · MI

My car is a 2023 Kia Sportage with 38,000 miles on it. I was informed upon getting my brake pads changed that my master cylinder for my brakes were not working, which is extremely dangerous and should not have happened until the car had at least 100,000 miles if ever. Not only did I have to pay out-of-pocket because Kia refused to get me in for a month so I had to go to a private repair shop to get this taken care of even though I was under warranty. This extremely concerning.

Filed Nov 21, 2024 · Brakes, Engine · PA

Purchased vehicle used 11/18/2023. Two days later vehicle went into limp mode on the highway. No brakes. Engine continued to shut off. Towed to dealer. Replaced injector. 11000 miles. 12/27/23 Vehicle was returned. 11/14/2024 Vehicle went into limp mode. Engine would not run. Vehicle was blowing white smoke thru exhaust. Another highway incident. Towed to dealership. This condition is very dangerous on the highway not only for me, my family and other motorist. As of today the vehicle is still at dealership. Do not have the repair orders or my car.