2024 Kia Sportage visibility problems

Filed Oct 6, 2026 · Body, Visibility · NC · 1 injury

On XXX, while driving my 2024 Kia Sportage X-Pro Prestige on [XXX] after exiting XXX, traveling west toward [XXX], the panoramic moonroof glass suddenly shattered without warning. It sounded like a gunshot going off very loudly inside the vehicle and badly startled both me and my service dog. The glass had no known prior damage, nothing had been placed on it, and I did not see or hear anything strike it. I pulled over and found the panoramic glass extensively shattered, with thousands of small fragments and areas of glass missing. I saw no evidence of an external impact. I received a superficial cut to my finger from a glass fragment; no medical attention was required. The interior sunshade was closed and prevented the shattered glass above it from falling directly onto me and my service dog. Glass fragments were still found inside the vehicle after the repair was completed. Multiple photographs document the extensive damage. The moonroof was repaired through insurance, but no cause for the sudden glass failure was identified. Kia America opened Case #XXX, escalated the matter for additional review, and requested post-incident photographs and incident details, which I provided. Kia later stated it had completed its review, cited factory-warranty glass coverage and the absence of applicable campaigns, and declined further assistance. I was not provided with a diagnosed cause for the glass failure. This vehicle also has a separate recurring safety concern involving unexpected engine shutdowns while driving or in traffic, including a shutdown at approximately 60 mph the following day, May 10. Those incidents were reported separately to the federal safety agency under Complaint #XXX. I am not asserting that the glass failure and shutdowns have the same cause. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 17, 2026 · Visibility · 44,800 miles · LA

The contact owns a 2024 Kia Sportage. The contact stated that while driving 65 MPH, the glass panel between the windshield and the panoramic sunroof exploded, causing glass to fall into the vehicle. The dealer was contacted. The failure mileage was approximately 44,800.

Filed Feb 2, 2026 · Visibility · 28,525 miles · TX

The contact owns a 2024 Kia Sportage. The contact stated that while driving at an undisclosed speed, the sunroof exploded. The contact stated that there was no evidence of an impact on the sunroof glass. The dealer was made aware of the failure. The contact was advised to take the vehicle to a Collision Center for assistance. The vehicle was taken to the Collision Center, and the contact was informed that the failure was a known failure with similar vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact was advised to contact the federal safety agency Hotline and the manufacturer to report the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 28,525.

Filed Dec 23, 2025 · Visibility · IN

6” Snow ice storm & negative degree temps 12/13/25 used heated windshield deicer. On 12/15 driving to work on a country road no other traffic, heard pop cracking noise above my head checked sunroof snow ice melting no visible cracks thought noise from thawing ice. Parked vehicle in my home garage while I went out of town. Returned home 12/22 found large crack origination point in front windshield originating in glass down the middle of rear view mirror sensor housing black box mounted on inner windshield the crack spans from top middle to bottom of black box glass over to right center half of windshield. Believe this is a manufacture defect design flaw low quality integrity of glass weaker than standard glass making it more susceptible to temperature changes or minor impact. Entire crack feels smooth interior exterior glass as if the crack is in the inner layers of glass windshield. Due to multi complaints & prior class action lawsuit regarding manufacture defect of KIA windshields I am reporting my complaint as it is quite similar to others complaints, issues & lawsuits. The massive crack in windshield is a driving safety hazard & a manufacture defect that needs recalled & resolved before injury or death occurs. KIA must acknowledge, issue recall &/or post a bulletin, accept responsibility this is a manufactures defect, notify the public and replace the windshields under Good Faith Customer Relations Warranty

Filed Dec 20, 2025 · Body, Visibility · AK

While traveling at approx 65 mph on a clear, debris-free Alaska highway in -5°F temperatures, the panoramic sunroof of my 2024 Kia Sportage spontaneously shattered with an explosive sound. There were no vehicles in the immediate vicinity (nearest car was maybe 50 to 75 ft away) and no observation of flying debris or falling objects from overpasses. The failure appears to be a spontaneous glass breakage (SGB) incident potentially caused by thermal stress or manufacturing defect rather than external impact. Crucially, some of the remaining glass fragments and one large attached piece are displaced and flexed OUTWARD (upward toward the sky). There are also fracture lines in the remaining glass along and parallel to the sides of the vehicle as well as parallel to the front frame of the glass. They do not radiate out from a central point as one would expect from an object strike. This geometry to me indicates internal tension or cabin pressure release, as an external impact from a projectile would have forced the glass inward into the cabin. Additionally, there was very little glass in the vehicle cabin, certainly far less than one would expect given the size of the opening in the sunroof and the amount of glass missing. I have personally previously been in a vehicle whose side window was blown out from a vehicle kicked rock strike and in that case was showered with a lot of glass. Yesterdays catastrophic failure resulted in some glass intrusion into the passenger cabin at highway speeds, creating a severe distraction with sound was loud & sudden enough to potentially cause a loss of vehicle control. I am aware of similar reports regarding the 2023-2024 Sportage (and previous Kia panoramic sunroof class actions) regarding the use of ceramic glazing or assembly stresses that contribute to such failures. I request an investigation into whether the current model's panoramic roof assembly is capable of withstanding extreme thermal differentials and body flex.

Filed Nov 25, 2025 · Visibility · CO

The sunroof shattered while driving without any sort of impact.

Filed Mar 3, 2025 · Visibility · CO

What I assume happened to my wiper blades: In December of 2024 we got a lot of heavy snow. I turned on my car to heat it up while I worked on cleaning off the outside of the car. My wipers were set to auto so the car automatically tried to clear the snow from the windshield. I did not notice this since they didn't move due to the snow weight. Once snow was removed I noticed the wipers did not work so I brought it in for the dealership to look at it. They determined that the gear had been stripped and needed to be replaced and informed me that this is not covered under warranty. Since the repair I have not driven the car in snow, no longer use the auto wiper function, and am sure to clean off all snow/ice before I turn the blades on. End of February I turned the wipers on to clean the windshield by pulling lever back. No fluid came out, the blades went back and forth a few times and then only one blade started coming up while the other lay in its off position. Determined that my car is not holding any wiper fluid (unsure if this was not connected properly during last repair). Have an appointment to get the car looked at again.

Filed Oct 28, 2024 · Visibility · 23,000 miles · AL

The contact owns a 2024 Kia Sportage. The contact stated while the vehicle was parked, the windshield cracked without impact. No warning light was illuminated. The vehicle was not taken to a dealer; the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 23,000.

Filed Apr 12, 2024 · Visibility · NH

On 4/42024 I was driving home and there was a mix of rain and snow. My riverside windshield wiper went out of sync and slammed into the passenger side damaging the blade, it then went over the edge and was stuck on the windshield frame overhanging the side view mirror. It made it very difficult to drive. When driving behind any other vehicle ot creates a scenario where you can't see how far or close you are to another vehicle. When I got to the dealership to have it looked at, they tried to blame it on a buildup of the wet snow that happened overnight. I cleared off my car completely before going to work. The fix was they had to tighten the linkage. While I was there, I overheard them complain in the service department that they had a lot of wiper related incidents that day.

Filed Feb 19, 2024 · Visibility · TN

Not really sure what happened, but last week the temperature suddenly dropped below freezing and there was ice built up on the windshield. We started the car and turned on the windshield defrost at high and we began to drive the car after the windshield was clear of ice and about 10 minutes later we noticed a crack develop on the windshield going from where the hot air from the defrost was hitting the windshield. and through out the day we noticed the crack grow exactly along the line where the defrost air would hit it. The crack is connected to a 2 mm round spot where a rock chip hit the windshield a few weeks ago but the crack seems to have started because of the temperature difference that was caused by the windshield defrost.