Kia Telluride engine failure problems

Filed Nov 3, 2026 · Seats, Transmission · TN

While operating the vehicle, severe unaddressed oil consumption has led to powertrain concerns and potential engine failure. Additionally, the vehicle is subject to unresolved safety recall 24V‑407 regarding the power seat motor fire hazard. Despite bringing the vehicle to the dealership for routine maintenance and presenting these safety and mechanical issues, the service department has failed to provide necessary repairs or authorize a safe replacement/loaner vehicle, leaving the vehicle a safety concern.

Filed Nov 2, 2026 · Brakes · TX

While driving the left rear brake caliper seized causing the brake to drag. It damaged the brake rotor and brake pads. I immediately pulled over as the car was unsafe to drive any further.

Filed Oct 16, 2026 · Engine · MA

hi- I bought a used Kia Telluride (2020) and after 2 months it stalled out and after 2 different mechanics and a Kia dealership telling me it was fixed- it was not. The car basically had no oil left with zero light or warning. after doing some research, there are tons of people complaining of the same issue. the engine is essentially ruined and needs to be replaced and Kia is not addressing this as an issue. my care has stalled out 3 times with my children in it at dangerous intersections. Kia is not taking responsibility of this- having to check oil every 3 days is not normal but Kia thinks it is I guess. The blue smoke coming from my exhaust is a serious problem. A local news station just reported on this of a woman needing an engine replacement and Kia not covering it, but after the news got to them they now are. We need this issue addressed as it is NOT SAFE and Kia needs to put a recall on this immediately- like 5 years ago this should have been addressed! I am not stuck with a car I still owe money on and have to figure out how to pay for a new engine!? KIA needs to do something- this is a safety issue! see article below! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 8, 2026 · Electrical, Transmission · WI

While driving the vehicle on the highway attempting to pass a vehicle at 75 mph the car unexpectedly shut completely off. We had to swerve between 2 vehicles narrowly avoiding an accident and the car would not turn back on. Towed to Kia dealership and was told it was simply a sensor that "talks" to the key fob which caused the car to shut off without warning. Dealership claimed it was fixed but there was no warning lights or notice of the failure. Since the dealership "fixed" the issue now the car is continuously running a check engine failure code and now the dealership claims it's the catalytic converters failing and needing to be replaced. Vehicle was inspected by the Kia dealership that it was purchased from.

Filed Oct 7, 2026 · Engine · CA

I am reporting a potential safety defect involving excessive engine oil loss and persistent oil leakage on my 2020 Kia Telluride, VIN [XXX]. The vehicle currently has approximately 100,367 miles. It has been experiencing significant oil loss, approximately one quart of engine oil per week. I am concerned that this amount of oil loss is abnormal and creates a potential safety hazard if the engine loses sufficient oil while the vehicle is being driven. The vehicle has also had repeated oil leaks, including an oil pan leak and timing cover leak. I have taken the vehicle to Kia for repairs multiple times, but the oil-related problems have continued. This has required me to continually monitor and add engine oil to prevent the oil level from becoming dangerously low. I specifically brought the vehicle to Kia because of the excessive oil consumption and ongoing leaks. However, the dealership has told me that they will not perform an oil-consumption test until the existing oil leaks are repaired. Kia Customer Care also opened case #[XXX], but I was subsequently told that Kia could not provide assistance because the vehicle is outside the standard warranty period. I am concerned that the underlying cause of the excessive oil loss has not been properly diagnosed. I am also concerned about the possibility of engine damage or engine failure if the vehicle continues losing oil at this rate. Kia has also issued a 2026 warranty extension concerning an engine oil-filter-housing gasket leak on certain 2020–2025 Telluride vehicles. I have asked Kia to determine whether my vehicle is affected by this condition and whether the current oil leaks are related, but I have not received a satisfactory resolution. I am asking the federal safety agency to review this complaint along with other complaints involving 2020 Kia Tellurides experiencing excessive oil consumption and/or recurring engine oil leaks to determine whether there is a potential safety defect or broader pattern that warrant INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

Filed Oct 6, 2026 · Engine, Suspension · IL

I am filing this safety report regarding my 2020 Kia Telluride, which currently has approximately 133,000 miles. The vehicle is experiencing severe internal oil consumption, burning through multiple quarts of engine oil rapidly between normal service intervals without triggering any dashboard warning lights, creating a high risk of sudden engine failure or stalling at highway speeds. Additionally, the vehicle is losing coolant at an accelerated rate, risking severe engine overheating. Furthermore, the suspension system has been a recurring safety nightmare; the shocks have failed and been replaced twice, and a critical structural defect caused the tires to rub directly against suspension components while driving, prematurely destroying the tires and severely compromising vehicle stability and steering control. I do not feel safe driving this car or transporting my kids everyday. When I spoke to Kia customer service, I was told they could not do anything despite being just under 100,000 miles at the time.

Filed Oct 5, 2026 · Engine · MI

On September 4, 2026, my son was driving our 2021 Kia Telluride on the highway at approximately 70 mph with cruise control engaged when the vehicle suddenly began making a clicking noise, followed by a catastrophic engine failure. We observed no oil-pressure warning or other advance dashboard warning before the failure. The sudden failure at highway speed created a significant safety risk. I am the original owner. The vehicle had approximately 115,000 miles at the time of failure. Its most recent oil change was performed on June 4, 2026, at 112,613 miles, approximately 2,400 miles before the incident. The servicing Kia dealership reported that the engine had a hole in it and essentially no oil remaining. The oil filter and drain plug were in place, and the dealership reported no external oil leak that explained the missing oil. An oil-filter-housing leak had previously been repaired in January 2026. The cause of the oil loss and engine failure has not been conclusively established. I am concerned about possible excessive internal oil consumption and the absence of an advance warning before catastrophic failure. I request that the federal safety agency investigate whether this condition affects other Tellurides and creates a risk of sudden engine failure or loss of propulsion at highway speed. Kia denied my initial request for goodwill repair assistance. The case has been escalated, but remains unresolved. The vehicle and failed engine are available for inspection through the servicing dealership.

Filed Oct 1, 2026 · Engine · MI

On September 24th, 2026, while traveling with my family in my 2020, KIA, Telluride, the vehicle began experiencing an unusual engine vibration approximately 200 miles into our trip. About five miles later, I exited the freeway and stopped to inspect it. Once stopped, the engine began knocking loudly. I checked the engine oil and coolant levels; both appeared normal, and the temperature gauge was at its usual reading. After waiting about five minutes, I restarted the vehicle, but the knocking became worse with each start. I stopped running the engine and had the vehicle towed to a Kia service center. The vehicle had approximately 99,350 miles. The shop has described the engine problem as a “catastrophic failure.” The cause and specific failed components are cannot be identified in this kind of failure. This sudden failure during freeway travel with my family created a serious safety concern and I am sure this needs to notified so that it doesn't happen to anyone who own's the same car. There are particles of metal shavings found in Oil filter which concludes engine failure with no explanation. Only option I am given is get the engine swap which is ~70% of the total cost of the car. Kia support just says since the car is out of warranty they cannot do anything about it. This is a serious durability issue. I totally understand that the car warranty was reduced for the 2nd owner, but first user could also get this problem on the freeway and can be dangerous for everyone driving in the car as i am still under 100,000miles. I am trying to spread awareness, Kia already acknowledges that consuming 1qtz of oil every 1000 miles is normal, which means the engine has a issue that Hyundai/Kia needs to fix before more family starts facing this with even worse situation than ours. Please look into this so that they can acknowledge fix the problem and opens a recall for fixing it.

Filed Oct 1, 2026 · Engine, Suspension · NC

Purchased vehicle 8/31/2021 - 32k miles 10/18/21 - first mention of oil consumption (opened case with Kia) 2023,2025,2026. 3 more cases filed and DENIED with Kia customer care. Filed BBB claim, filed BBB anutoline claim, also hired lemon lawyer. Kia offered $6k to go away (I declined). *July 18,2026 Kia finally diagnosis and recommends engine replacement. Bore scope was used to discover scoring on cylinders from significant oil consumption. Vehicle is now smoking at take off (112k miles), current open case with Kia customer care again. Requesting buyback or settlement for the 3rd time in 5 years. Still paying $600 a month Safety concern: on a trip out of state vehicle dash lit up every icon and went dead in the middle of a packed 4 lane highway , started with power steering, no lights, no horn , couldn't roll window down.(video avail) Vehicle towed to dealership. Had replaced battery 2 times already. This has happened twice and my family was in the vehicle once on the large highway, very scary no one knew we were broke down bc we had no way to show it. People blowing and zooming by mad. Low oil light doesn't exist on this vehicle, I've been bone dry with no indication EVER. I now ride around with a 5 quart jug of oil and funnel in the back of my car since 72,000 miles. This should be illegal. Rear suspension: 4 times the rear suspension has been replaced (7 times in the shop to be fixed one time over 30 days) and has never been fixed , now making the same knocking noise it's always made. The car is a lemon and Kia knows it and will not stand behind their product. I DO NOT FEEL SAFE IN THIS VEHICLE, kia has been notified numerous times in every avenue and every way I could communicate, they say "we will call you with an update when we have one" that call NEVER happens.

Filed Sep 24, 2026 · Engine · OH

My 2020 Kia Telluride experienced progressive and severe engine oil consumption that ultimately required a full engine replacement. Beginning well before the failure, the vehicle required frequent manual oil top-offs between scheduled changes, including on longer trips. No low-oil warning light, check-engine light, or oil-pressure warning ever illuminated to alert of critically low oil levels. In late March 2026 an independent service center replaced the engine oil filter housing and related gasket after an oil leak was observed; an axle damaged by oil spray was also replaced at that time. Shortly afterward the manufacturer issued a warranty extension covering oil-filter-housing gasket leaks on 2020–2025 Tellurides, extending coverage to 15 years/180,000 miles for that specific condition. Despite the housing/gasket repair, the excessive oil consumption continued. Several weeks later the vehicle lost power and broke down while being driven. It was towed to an authorized Kia dealership. Technicians inspected the vehicle, confirmed heavy oil consumption (noting the engine had been requiring large amounts of oil nearly weekly with no external ground leaks observed), and diagnosed catastrophic internal engine damage. They recommended complete engine replacement at a quoted cost exceeding $13,000. The dealership also inspected the oil-filter housing area under the recent warranty extension but determined the engine damage itself fell outside that limited coverage. The oil-consumption problem and resulting engine failure create a clear safety risk: sudden loss of power or stalling can occur without any dashboard warning, potentially while the vehicle is in motion on public roads. The failed engine and related components remain available for inspection. The condition has been confirmed by both an independent service center and an authorized Kia dealership. Similar oil-consumption and engine-damage reports have been widely noted among other owners of the same model.