Kia Telluride won't start problems

Filed Aug 10, 2026 · Electrical, Engine · TN

This is an update to my original the federal safety agency complaint (ID 11755209) regarding an intermittent no-start/no-crank defect on my 2023 Kia Telluride (VIN [XXX]). Since my original filing, the identical defect has recurred twice more, on XXX — once at approximately 1:01–1:30 PM EST and again at approximately 5:03–5:17 PM EST, the same day. In both incidents, the dashboard and infotainment system powered up normally, but the vehicle would not crank, consistent with all prior occurrences dating back to XXX. This brings the total documented occurrences to six between XXX and August 8, 2026, including two in a single day. In both August 8 incidents, my wife was stranded and had to be picked up because the vehicle would not start. This follows a dealer-confirmed and dealer-executed starter replacement (Kia of Cleveland, RO dated XXX, part #36100-3L160) that was performed after the dealer duplicated the fault on the vehicle and on a bench test — and a 4th recurrence on XXX, just 10 days after that repair. I have video evidence of all four August incidents (XXX, and the two on XXX showing the instrument cluster and infotainment fully powered with a no-crank condition. I am providing this update because the frequency of occurrences is escalating — two failures in a single day — despite a repair that was physically confirmed by the dealer's own testing. This strongly suggests the actual root cause (potentially an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) has not been correctly identified, and the defect continues to pose an unreasonable stranding risk to occupants. I am concurrently pursuing a vehicle replacement request with Kia America under Customer Care Case #26211382. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 6, 2026 · Electrical, Engine · TN

My 2023 Kia Telluride (VIN [XXX]) has an intermittent no-start/no-crank defect that has occurred on four separate occasions between [XXX] and [XXX] (mileage range 49,850–51,180). In each occurrence, the dashboard and infotainment system power on normally, but the engine will not crank when the start button is pressed, with both key fobs. The fault clears itself with no consistent trigger, making it undetectable by standard diagnostic scans after the fact. The vehicle was taken to Kia of Cleveland (2492 South Lee Highway, Cleveland, TN 37311) three times. On the first two visits (6/18/26 and 7/1/26) the dealer could not duplicate the fault and returned the vehicle unrepaired. On the third visit (7/17/26–7/27/26), the dealer successfully duplicated the no-start condition both on the vehicle and on a bench test after removing the starter, and replaced the starter under warranty (part #36100-3L160). Despite this confirmed and completed repair, the identical no-start condition recurred on [XXX], only 10 days and approximately 250 miles later. This is a safety issue: on [XXX], my wife was attempting to leave for work with our twin 5-year-old daughters in the vehicle when it failed to start. This is the type of defect that could strand occupants in unsafe locations or conditions (heat, cold, traffic, isolated areas) with no warning and no reliable workaround. I have video evidence of the [XXX] incident showing the vehicle's instrument cluster and infotainment fully powered with a no-crank condition, timestamped and showing the odometer reading. I am filing this complaint because the defect has now defeated a dealer-confirmed and dealer-executed repair, suggesting a root cause (such as an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) that has not yet been correctly identified. I am concurrently requesting a vehicle replacement from Kia America under Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 16, 2025 · Electrical · DE

When parked on an incline, the vehicle will not start and has to have the battery jumped. When attempting to start the vehicle, you can hear a clicking sound and an error message pops up saying "Check ESP". After this happens, the windows will roll down to about a 1/8 crack and will not roll up even after the car has been jumped and is on. Also, when driving down the road with the heat on, it will stop blowing heat and will start blowing cold air.

Filed Sep 30, 2025 · Electrical, Engine · TX

First issue, the entire screen went black while driving. Couldn't see navigation, speed other critical information. Was at the dealership a few weeks got it back and the hazard lights no longer worked but they did before it had gone to the dealership. Screen went out again and took it back. Dealership had it a few weeks fixed hazards and started a ticket with Kia engineering. Screen still goes out randomly. Electrical is messed up and car won't start randomly while screen blinks on and off. Been in the shop multiple times for weeks at a time for this issue and they say there is nothing wrong because they can't duplicate it while they have it. They have had to pick it up from my home because it wouldn't start and still say there is nothing wrong with the vehicle.

Filed Jun 24, 2025 · Brakes, Electrical · MO

I am reporting a serious and ongoing electrical and transmission issue with my 2021 Kia Telluride (VIN: [XXX] ). The problem began under 20,000 miles and has continued intermittently for years, progressively worsening. My vehicle is currently at ~99,600 miles and under extended warranty. The key safety concerns include: Transmission Lockout: The vehicle intermittently becomes stuck in Park and will not shift, even with the brake depressed. No-Start Condition: The vehicle will randomly become completely unresponsive—no dash lights, no infotainment, and no engine start. Electrical System Failure While Driving: Multiple safety systems fail mid-drive, including: Loss of power steering and air conditioning Random activation of ESC, TPMS, Collision Assist, Blind Spot, and Parking Brake warnings Infotainment screen turns off while in motion Component Failures Due to Electrical Shorts: Both the radio and the backup camera were diagnosed with shorts and had to be replaced under warranty. Brake Lockout Post-Shutdown: The brake pedal becomes very firm and the vehicle will not restart until hours later. Most concerning, my wife and children have been left stranded in the disabled vehicle on multiple occasions due to these issues. The car has been in the shop several times — around 50,000 and 80,000 miles — but no permanent resolution has been found. This is a clear and escalating safety hazard. The failures affect critical systems while driving and leave the vehicle unpredictably disabled. Kia has been made aware and an escalation is underway, but I am filing this report to ensure the federal safety agency is aware of the pattern and potential danger these failures pose to others. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 14, 2024 · Driver assistance, Electrical · ID · fire

OCTOBER 2024 Before the main incident Oct 2024, I started noticing slight changes in the way my KIA was operating: - Delayed response to accelerate when at a light - Tire sensors/ crash collision sensors - Lane assist pulling my off the road or into on coming traffic (random) - Intermittent Power loss while driving. - Lights not working properly. - High beams failed to operate in Sept and was told by Burlington WA KIA there was not a fix for the recall, while there for service/oil change. - Car going into parking brake when not activated. - When stopped in car is in drive, when starting to accelerate the car went in reverse causing me to hit a stump and partially tearing front bumper off. About a week after that incident I was driving home from store and car started randomly pulling car into oncoming lane. Thankfully there was not a vehicle at that time. Car then started having weird fluctuations with speedometer and dash info. Went from 24.7 miles to gal to 38 and kept jumping, experienced more instances of power loss while in drive. Then all of sudden dashboard went haywire. Whole dash lit up and was switching from different drive modes. I started noticing an electrical burning smell and smoke coming from hood. I pulled over not even a mile from home and started to pull everything important from vehicle. Think the car was on fire under the hood. After several minutes of accessing the situation and smoke dissipated, I decided to try and get car home. As I put car in drive it again went in reverse. I put car in park again and then drive and was able to proceed and limp car home. I parked car and took video of the dash light party and video of putting car in drive and it changing randomly. There still was an electrical burn smell on outside and in cab of vehicle. When my husband arrived home I tried to start vehicle to show him and it wouldn't start. So, he thought maybe the battery fried and took bat in to Napa and bought a new battery.

Filed Nov 1, 2024 · Electrical, Engine · IL

For the past year at least I've had check engine light come on and turn off before being able to get in for a diagnostic. Along with the entire engine shutting down while idling, parking, turning. Whole electrical system failure. Can't move the steering wheel. Have to restart the car and it takes a few tries. Sometimes the car will be off and will not start back up for a while.

Filed Aug 21, 2024 · Engine · GA

Car was being driven when it began to slow down. Pulled over and smoke was coming from under the car. Car would not start again. Once at dealership, found there was catastrophic engine failure due to a rod that put 7 holes in the engine. Also, car was low on oil despite an oil change less than 60 days prior to this incident.

Filed Jan 11, 2024 · Electrical · TX

I have a fairly brand new 2020 Kia Telluride with only about 50,000 miles on it and one day out of no where the car won't start and now I'm getting a check ESC message. Since it's fairly new I had it jump started and the car quickly turned on and ran fine for the rest of the day. The following day the car hesitated when turning on but it started. I was driving and when I got to a light and when the light turned green and went to take off the car wouldn't go. It turned off again and would start back up. I went into the KIA forum and noticed that a lot of Kia Telluride owners are experiencing this same issue but all seem to have different resolutions from needing a new battery, or a new starter or that the IBU system is blown. This is very frustrating because I don't necessarily know where I need to begin and I don't want to have waste my money with trying to figure out exactly what is going on with my car.

Filed May 27, 2023 · GA

The car will NOT start with a ESC warranty