2016 Land Rover Discovery Sport engine problems

Filed Sep 1, 2026 · Engine · IL

2016 Land Rover Discovery Sport, turbocharger failed at approximately 98,000 miles. Vehicle required turbocharger replacement costing over $5,000. VIN is excluded from the existing turbocharger class-action settlement because the vehicle is identified as having a BorgWarner single-scroll turbocharger. I believe the turbocharger failure may represent a premature manufacturing/design defect similar to the turbocharger failures alleged in the existing Flynn-Murphy litigation.

Filed Feb 8, 2026 · Engine · MA

My 2016 Jaguar Land Rover Discovery Sport is displaying a CHECK ENGINE light. After having it seen by mechanics I'm told the Turbo-Manifold is faulty-CRACKED-and must be replaced, not safe to drive. It demonstrates by having noxious fumes enter the cabin, causing ill effects-not operable subject to dire illness. Should be part of RECALL. Please advise. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jun 9, 2025 · Engine · TX

Crankshaft pulley and Crankshaft had a manufactured defect that caused the pulley to brake into pieces while standing at a stop intersection, multiple pieces of metal were projected towards the radiator, water pump, passenger wheel, serpentine belt, battery and other components causing considerable damage and left the vehicle inoperable. The repairs were substantial and required multiple parts to be replaced due to a low quality part (crankshaft and pulley) during the vehicle's assembly, among some of them were a new Crankshaft pulley, radiator and retainers, and serpentine wheel. The total cost for the damage including parts, labor and secondary services (towing) were in excess of $3,700.00 (Three thousand seven hundred dollars). The mechanics that performed the services strongly advised and encouraged that the manufacturer were contacted to arrange for refund and awareness of the defect in the parts involved. We proceeded to contact the local dealership and service in Frisco Texas and they denied relief stating that the vehicle was out of warranty, although they had full knowledge that defective parts are not within the scope of warranty but inherent risks that need to be addressed for the customers. Given the lack of relief, I proceeded to notify the federal safety agency of this issue for further investigation and possible force of a recall to obtain relief of all customers that may be impacted.

Filed Jan 3, 2024 · Engine · 116,000 miles · GA

The contact owns a 2016 Land Rover Discovery Sport. The contact stated that while starting and while driving, there was an abnormal exhaust odor inside the cabin of the vehicle. Additionally, the contact stated that while parking the vehicle, the vehicle made an abnormal clicking sound that lasted for 2-3 minutes after the vehicle was parked. The vehicle was taken to the dealer, where it was diagnosed that the exhaust intake manifold was fractured and needed to be replaced. The vehicle was not repaired. The contact was concerned for her safety due to the exhaust odor and carbon monoxide poisoning. The manufacturer was not notified of the failure. The failure mileage was approximately 116,000.

Filed Oct 23, 2023 · Engine · OH

The timing chain broke on an uphill and evidently ruined the entire engine. I was stuck in the middle of a 2 lane road with no shoulder on a hill. I had to direct traffic for 45 minutes to avoid any crashes or my car being rear ended. Repair will cost more than the car is currently worth. Seems to be a known issue. It was inspected by Land Rover Cincinnati. Check engine light came on 2.5 days prior to the incident - called Land Rover Service and I was instructed to "tighten the gas cap and wait a few days."

Filed Aug 3, 2023 · Engine, Fuel system · NC

I checked the car for a pre trip inspection, and noticed the oil dipstick smelled of gas. Towed it to a service center where they were not able to confirm what was the cause as there are no warning lights and fuel injectors tested good. They drained and flushed oil, but the issue did not resolve. Concerned this issue is the same issue as other cars of the same model but different year have been recalled for, I am reporting the issue.

Filed Oct 21, 2022 · Engine · OH

I experienced three incidents attributable to a malfunction of the turbocharger integrated exhaust manifold. The first two occasions the vehicle suddenly and inexplicably lost power slowing to approximately 5 mph. Acceleration only made the engine rev up but did not increase power. No prior indications from the function of engine nor any warning indicators activated at the time the first two incidents occurred. I had only owned the vehicle for two to three months when the first incident occurred. Being my first experience with a vehicle equipped with paddles affixed to the steering wheel and not having any prior warnings I presumed I had inadvertently and incorrectly touched the paddles. The loss of power lasted only minutes but rendered the vehicle unable to maintain speed to safely maneuver through and move from travel lanes. The most recent occurrence happened while traveling at highway speed on an interstate. This time the vehicle again immediately lost power and my speed abruptly dropped to about 30 mph and for the first time illuminated the check engine light. Fortunately, traffic was light and I was within 1 mile of the next exit. I was able to maneuver to the shoulder and eventually exited the highway. The vehicle recovered function and I travelled approximately 10 miles back to a Land Rover Dealership. Diagnostic tests pulled code DTC P0299 and recommended that the turbocharger be replaced. There is currently a class action lawsuit pending against Land Rover vehicles for this problem which has been reported to be a common occurrence in the 2012-2017 Evoque, 2015-2017 Discovery Sport, and 2013-2015 LR2. In 2020 4 complaints were filed with the federal safety agency (11342410, 11342277, 11375748, and 11375786) regarding turbocharger failure and sudden loss of power. My vehicle has been parked at a dealership since July 8, 2021 because the unforeseeable loss of power renders the vehicle unreliable and at risk of accident and injury.

Filed Sep 20, 2022 · Engine · NJ

the timing chain its just broken

Filed Jun 30, 2022 · Engine · TX

Crankshaft pulley fell off vehicle Belt of vehicle was no longer spinning and coolant/charging systems were not functioning properly Unknown Unknown No

Filed Jan 12, 2022 · Engine · FL

In July 2019 the 2016 Land Rover Discovery sport experienced a failure of the crank shaft pulley that completely destroyed the engine. At time of failure in 2019 car has approximately 96,500 miles. A claim was filed with Land Rover which was denied because they deemed the crank pulley a serviceable part that should have been maintained by car owner. The engine was subsequently replaced with used engine assembly with 60k miles and car placed back into service. January 2022 the same car experienced a crank pully failure on the engine that was replaced in July 2019. Car currently at Land Rover Dealership undergoing forensic evaluation.