2019 Lincoln MKZ: engine failure

Filed Oct 7, 2026 · Engine · TX

I noticed on mid Sept/2026 when I started my car the engine was idling rough for a few minutes, then went idling normal. Every morning after it repeated itself when first starting the car and my check engine light came on. I scheduled a a diagnostic with an Auto shop and it was diagnosed as Cylinder 2 misfire. Shop told me to check if coolant level is lower in the next morning, I checked it was low & had to add more coolant, also no coolant on the floor. Check Engine Light on almost every day, took it to another auto shop for 2nd opinion, had them do a coolant pressure test. The Coolant pressure test showed Cylinder 2 had coolant getting inside it. Shop found TSB 19-2208 pertaining to this issue. Repair for this was to replace engine. Found out about Miller vs Ford Class action suit online which stated Ford had a Engine Block design flaw on the 1.0 L, 1.6 L, & 2.0 L EcoBoost engines which allows coolant to leak directly into the combustion Cylinders, which could cause severe overheating. My Lincoln MKZ has the 2.0 L EcoBoost engine. Eventually my engine will fail completely if I continue to drive the car. My MKZ engine was built on 08/2018

Filed Sep 1, 2026 · Engine · VA

In August 2026, my 2019 Lincoln MKZ equipped with the 2.0L EcoBoost engine, with approximately 39,000 miles, began experiencing repeated coolant loss, rough shaking during startup, engine misfires, temperature-gauge fluctuations toward hot, and an “Engine Coolant Over Temperature” warning while the vehicle was being driven. The warning appeared and then cleared, creating concern that the vehicle could continue operating without a persistent warning even though the engine was overheating. The climate-control system also began blowing hot air while the air conditioning was selected. Before the over-temperature warning, coolant had required frequent replacement, at times approximately once per week. An authorized Lincoln dealership performed diagnostic testing and confirmed coolant intrusion into the engine cylinders. The dealership advised that the failure matches the condition addressed in Ford’s technical service bulletin concerning coolant intrusion in certain 2.0L EcoBoost engines. The prescribed repair is replacement of the engine long-block assembly. This condition creates a safety concern because coolant entering the cylinders can cause misfires, overheating, severe engine damage, and potential loss of motive power while driving. The vehicle is currently at the authorized Lincoln dealership, and the failed engine should remain available for inspection until it is replaced. No crash, fire, or injury occurred. The manufacturer declined repair assistance because the vehicle was outside the applicable time limit, and the estimated engine replacement cost is approximately $9,620.

Filed Aug 19, 2026 · Engine · FL

On XXX, the engine in my 2019 Lincoln MKZ (Mileage 58,089) with the 2.0L EcoBoost engine suffered a catastrophic, sudden failure while driving. The vehicle began to overheat & run extremely rough, triggering multiple warning lights. It is now inoperable and unsafe to drive. The vehicle was towed to a Lincoln dealership (Tasca Lincoln in [XXX]) for diagnosis. The work order number is RO #XXX. The dealership confirmed the failure is due to a well-documented manufacturing defect known as "coolant intrusion," where the engine block cracks internally, allowing coolant to leak directly into the engine cylinders. The diagnostic trouble codes stored were P0217 (Engine Overheat Condition), P0302 (Cylinder 2 Misfire Detected), & P0316 (Misfire Detected on Startup). This issue is specifically addressed in Ford's own Technical Service Bulletin 19-2346. This coolant intrusion defect creates a critical safety hazard. The engine can lose its coolant and fail without any prior warning, leading to a complete loss of power while the vehicle is in motion. A sudden seizure of the engine at highway speeds could cause a catastrophic accident, endangering myself, my passengers, & other drivers on the road. Estimated Cost for Repair: $10,781.40 (for complete engine replacement). I contacted Lincoln Customer Relations (Case #XXX) to request assistance with this known manufacturing defect. I was informed that there is no goodwill assistance available & that my case was being forwarded to their internal Vehicle Safety Division. This confirms that Ford is aware this is a serious safety issue. This is not a normal wear-and-tear failure; it is a fundamental defect in the engine's design that Ford has acknowledged internally through its service bulletins. An engine should not fail catastrophically due to a manufacturing defect on a [XXX] vehicle. I urge the federal safety agency to investigate this defect to determine if a safety recall is warranted to protect the public. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

Filed Sep 11, 2025 · Engine, Transmission · MO

My 2019 Lincoln MKZ check engine light came on. The repair shop said coolant was leaking into #3 cylinder from cracks in the engine block. Per alerts the shop receives from Ford, this is a known issue and there is no way to repair this issue. The engine will need to be replaced. My powertrain warranty ended 4 month earlier. My car has 45,500 miles on it. I talked to the dealership and they advised calling Lincoln directly. I call Lincoln and they confirmed this is a known issue. I was told that my car didn't meet the out of warranty criteria to receive any assistance to replace the defective engine. They wouldn't tell me what the parameters are and said I would need to pay the full cost to replace the engine. My understanding from the shop is they see many Escapes and MKZ with this engine issue but never seen one with this low of mileage. Lincoln told me to keep my replacement receipts in case there is a recall. I

Filed Jul 26, 2025 · Transmission · NJ

On models 2017-2019 Lincoln mkz’s there is a tsb known issue for coolant intrusion in the cylinders. I need an engine replacement. This should be a recall in these cars

Filed Nov 2, 2024 · Engine · VA

Engine failed due to coolant intrusion into cylinders. This is a known design flaw in this engine