1997 Lincoln Navigator technical service bulletins
78 technical service bulletins and manufacturer communications cover the 1997 Lincoln Navigator.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- General (PCM) power train control module programming procedures
- General power train control module (PCM) programming procedures
- Courtesy rail lamps do not operate correctly or cause a battery draw
- False failure of the vapor management valve (VMV)
- Subject regarding exaggerated engine braking on deceleration
- Subject regarding inoperative running board lights
- Some vehicles may exhibit a slow fuel fill condition and/or premature shutoff of the gas pump when the...
- Some vehicles may exhibit a vibration at idle and/or engine droaning noise on acceleration from a stop
- Some vehicles may exhibit a driveline vibration at speeds between 60-70 mph
- Some vehicles may exhibit a condition of no 4X4 low range engagement or a stuck in 4X4 low range, with no...
- All 4X4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite...
- Some vehicles may exhibit an engine knock at initial cold startup
- Vehicles with 2.4L, 4.6L, and 5.4L engines may exhibit an a/c moan at idle
- Vehicles equipped with windsor engines only may exhibit an engine knock at initial cold startup
- Some vehicles equipped with engines produced by windsor engine plant may exhibit an engine knock at...
- Information regarding transmission trouble codes
- Experiencing engine knock at initial cold startup
- This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal /...
- Experiencing windnoise at the top of the door glass seal / weatherstrip molding area
- Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making...
- Experiencing a engine knock at cold start-up
- Information on using 1999 procedures manual for side mirror replacement
- Experiencing front differential noise
- Concerns with front differential noise
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal...
- Some vehicles may experience an idle vibration
- Exhibiting malfunction indicator lamp (MIL) with diagnostic trouble codes (dtc(s) PO351 and / or P0356...
- Exhibiting a vibration that may be interpreted as an nvh condition
- Information regarding new service steering gear
- Conditions on brokent door pull handles
- Addressing concerns of a low speed (under 35 mph) clicking noise caused by a cage nut rocking on the...
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal...
- Some vehicles may exhibit a idle vibration.
- Vehicles exhibiting intermittent illumination of air bag light with diagnostic trouble code B1924
- Some vehicles may exhibit an air bag light on intermittently with diagnostic trouble code B1924
- Rear wiper arm installation
- Some vehicles equipped with 5.4L engines may exhibit a cold start engine knock concern until warmed up
- Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern
- For certain vehicles the octane shorting bar located on the passenger side of engine compartment near the...
- Information on vehicles exhibiting cold engine knock
- Information on vehicles exhibiting vibration at cruise over 50 mph
- Some vehicles may exhibit a rear wiper that does not function properly (jammed)
- When installing a rear wiper arm on some vehicles, be sure to follow the procedure in the 1999 workshop...
- Some vehicles equipped with 4.6L or 6.8L engines may exhibit a cold start engine noise until warmed up
- Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys...
- Experiencing cold engine knock (repeat / revised message)
- Subject regarding idle vibration (repeat message)
- Subject regarding vehicles exhibiting vibration at cruise over 50 mph
- Information concerning the octane shorting bar located on the passenger side of engine compartment near...
- Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern
- Vibration at cruise over 50 mph
- Cold engine knock 5.4L action
- Information on procedures to follow when installing a rear wiper arm
- Some 1997-1998 explorer/mountaineer/expedition or navigator vehicles with 4-WD 4X4 system may exhibit both
- Some vehicles may exhibit rear axle noise
- Malfunction indicator lamp on, with P0300 - P0308 misfire diagnostic trouble codes with a 4.6L engine
- This bulletin states that for certain vehicles it is not possible to set the check engine light and set...
- On some vehicles, the rubber stop bumper may be missing from the parking brake control, a replacement...
- Information on setting the check engine light and setting diagnostic trouble code P0455 (evaporative...
- Experiencing vibration at cruise over 50 mph
- Symptoms regarding P0300-P0308 misfire dtcs with 4.6L engines
- Brief information giving the correct part number for TSB 98-3-12
- If you encounter a vehicle with a missing wheel hub o-ring, do not install a new o-ring
- Concerns of engine checklight on and DTC P1506 ( idle air control over speed error ) and/or fast idle
- Vehicles with the E4OD are added to the fqr ( ford quality renewal ) assembly program
- Some vehicles may exhibit a low speed ( under 35MPH ) clicking noise
- Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers
- Concerns with codes P0500, P0503, P1501 or P1503 which may be caused my a loose speedometer drive gear
- Some vehicles may experience an audible 50 hz body boom
- This bulletin mentions how some hub o-rings may be cut during the installation of the wheels
- Information on removing the radio chassis from some vehicles
- Some vehicles may exhibit loose lugnuts and / or broken wheel studs
- Subject pertaining to radio inoperative conditions
- Some engines may exhibit oil leakage
- Experiencing difficulties with the malfunction indicator lamp (MIL)
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Lincoln Navigator?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history