1994 lincoln town car the lower ball joint on the front drivers side of the car suddenly broke in half allowing the lower control arm of the car to fall to the ground. Fortunately, I was just parking when it happened. Their was no warning of a problem with the ball joint. The car drove fine. I understand that a recall exists for this problem (98s37), but according to the dealer, my car is not covered by the recall. Obviously, it should be.
1994 Lincoln Town Car suspension problems
13 complaints (8% of all complaints for this car). Typical mileage when it fails: 231,700. 2 crashes reported.
- owner complaints
- 13
- of this car's complaints
- 8%
- typical mileage
- 231,700
- crashes
- 2
- recalls
- 1
Which part fails
- Front: control arm: lower ball joint6
- Front: control arm: lower arm3
- Rear2
- Front2
- Rear: springs: air suspension system1
- Front: springs: air suspension system1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Lincoln Town Car suspension problems in other years
Specific symptoms reported on the 1994 Lincoln Town Car suspension
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Suspension: front: control arm: lower ball joint
- What is wrong
- Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. The one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. This could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
- Risk
- If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
- Remedy
- Dealers will replace the lower control arm ball joints (2).
Recall number 98V322000 · Recall details
What 1994 Lincoln Town Car owners say
Most recent owner complaints, unedited.
My elderly parents were driving in a straight line at low speed when the lower control arm ball joint failed. The control arm dropped, dug into the pavement and rendered the car out of control. Luckily no one was injured. It was very difficult to jack up the car, slide a dolly under it, tow it home, etc. There have been several complaints on this exact problem. A recall addressing this serious life threatening defect has been issued on vehicles of the same model, year and construction; but, not all VIN were covered in the recall. As of this date no work has been done to correct the failure.
Dt: the contact stated the front left ball joint fell off of his of 1994 lincoln town car. This happened on 9-16-05. This was the first time this has happened.*ak
While driving my 1994 lincoln town car at 20-25 MPH in hopewell nj my drivers side lower ball joint separated,causing the lower control arm to fall to the ground and the wheel well to fall on the top side of the right front tire,rendering the vehicle immovable. The car was then towed 42 miles to my home on a flatbed truck at the cost of $192.00. With the aid of a neighbor (a professional mechanic) the ball joint was replaced with an aftermarket part,cost $52.00(no labor cost-self installed).the broken ball joint( I have retained the broken part in my possession) did not have any fittings for lubrication,but according to ford customer service division in dearborn mi( mr.paul laffin ) my vehicle was not part of any safety recall(98s37 ford's # ) or 98v322000.I was advised that I should take my car to the nearest lincoln dealer for inspection and or service of the other (right side) ball joint. My driving to and from work involves 15 miles on an interstate highway,I guess I was just lucky to have this failure occur on a city street at 20 MPH. I am very dissatisfied with ford,lincoln for their response to my issue which I believe is a defective part that they refuse to take responsibility for and correct. Even if my car was not in the original recall, I feel it is a similar issue that should be addressed in a like manner when it has been brought to their attention. As for nhsta I would like your office to look into the assembly specs for all 1994 lincoln town cars to see if all were equipped with this type of (ungreaseable) ball joint. Thank you.
Rear suspension drop causing the vehicle to drop lower to the ground. Please provide any additional. Ph
Consumer advised that left side lower ball joint connected to wheel separated while driving causing loss of steering control. Dealer advised joint separated due to lack of grease at assembly. *ph both lower ball joints were replaced and aligned the front end. Needed front brakes replaced. Consumer declined brake repairs.
When driving at 20/25mph and upon approaching a stop sign, consumer heard a very loud noise when front left driver's side end dropped down. This was as a result of lower control arm and ball joint separating.there is a recall 98v322000; but, this vehicle is not part of recall due to VIN.
While traveling at speeds above 55 MPH, there is a vibration and noise coming from vehicle. Front lower control arm has been diagnosed as the component causing this problem. Manufacturer informed consumer that this vehicle was not included in campaign 98v322000 due to VIN. *ak consumer stated dealer took care of the problem.
Front air suspension system is not holding up properly. Has not contacted dealer yet.
The engine had a noticeable amount of oil exhaust smoke, this is an indication of internal engine wear. Nlm
Questions about the 1994 Lincoln Town Car suspension
Does the 1994 Lincoln Town Car have suspension problems?
Owners have filed 13 complaints about the suspension of the 1994 Lincoln Town Car, 8% of all its complaints.
At what mileage do 1994 Lincoln Town Car suspension problems start?
The typical (median) mileage in owner complaints is 231,700 miles.
Was there a recall on the 1994 Lincoln Town Car suspension?
Yes, 1 recall: 98V322000. Check your VIN to see if your car still needs the free repair.
What year does the Lincoln Town Car have bad suspension?
The Lincoln Town Car model years with the most suspension complaints are 2003 (81 complaints), 1997 (50 complaints) and 1996 (24 complaints).
Other 1994 Lincoln Town Car problems
Engine 25Brakes 23Acceleration 22Electrical 20Transmission 17Seats 14Airbags 11Fuel system 8Lights 8Tires 8Visibility 7Body 3Locks 3Seat belts 3Steering 3Driver assistance 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Lincoln Town Car?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history