I was experiencing low voltage inside the School bus , erratic lighting and 2 way radio was cycling on and off due to LOW VOLTAGE. I noticed the smell of smoke inside the school bus, upon further investigation, I opened the hood and noticed smoke rising from the positive electrical "pass Through" 12-volt connector on the driver side. apparently, the connector insulator failed and was shorting to the body and was getting extremely hot and could cause a fire. the connector on the inside of the bus, under the dash, was blackened from the heat. i have a photo of it. I took the bus out of service and notified LION Bus about the problem, they ordered parts and sent a technician out to repair it. I have a video of the smoking connector. This issue could cause a School Bus fire. I will try to send the photos and video. If I cannot send them please reach out with a good e-mail address to send them.
The worst 2024 Lion Lionc problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Electrical2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical2
Recalls 5
Electrical system: propulsion system: cables: fastener/connector
- What is wrong
- Lion Electric Company (Lion Electric) is recalling certain 2023-2024 LionC school buses. The controller area network (CAN) connector for the high-voltage battery number 4 was incorrectly installed, which can allow water to accumulate and cause a lost connection with the battery.
- Risk
- A lost connection with the battery can lead to a loss of power steering assist and reduced braking ability, increasing the risk of a crash.
- Remedy
- Lion Electric will reinstall and replace the CAN connector as necessary, free of charge. Owner notification letters were mailed July 29, 2024. Owners may contact Lion Electric customer service at 1‑855‑546‑6706. Lion Electric's number for this recall is R2024-010.
Recall number 24V460000 · Recall details
Parking brake
- What is wrong
- Lion Electric Company (Lion Electric) is recalling certain 2024-2025 LionC school buses. The parking brake may malfunction and allow the lever to be released without pressing the release button.
- Risk
- A parking brake that is released unexpectedly may result in a vehicle roll away, increasing the risk of a crash or injury.
- Remedy
- Lion Electric will provide inspection instructions to owners, and replace the parking brake levers as necessary, free of charge. Owner notification letters were mailed July 25, 2024. Owners may contact Lion Electric customer service at 1‑855‑546‑6706. Lion Electric's number for this recall is R2024-01-009.
Recall number 24V377000 · Recall details
Service brakes, air
- What is wrong
- Lion Electric Company (Lion Electric) is recalling certain 2024-2025 LionC School Buses. The anti-lock brake system (ABS) pneumatic valve connections and rear wheel speed sensors may be installed incorrectly.
- Risk
- Incorrectly installed ABS valves and wheel speed sensors can cause a wheel lockup or loss of vehicle control during ABS braking, increasing the risk of a crash.
- Remedy
- Lion Electric will correct the brake connections, free of charge. Owner notification letters were mailed December 15, 2023. Owners may contact Lion Electric customer service at 1‑855‑546‑6706. Lion Electric's number for this recall is R2023-008.
Recall number 23V710000 · Recall details
Electrical system
- What is wrong
- Lion Electrical Company (Lion) is recalling certain 2021-2025 LionC school buses. Loose hardware inside the high-voltage distribution unit (HVDU) or direct current junction box (DCJB) enclosures may contact electrical terminals, causing a short circuit.
- Risk
- A short circuit can shut down the high-voltage circuit, causing a loss of steering assistance or drive power and reducing braking power, increasing the risk of a crash.
- Remedy
- Lion technicians will replace the hardware, free of charge. Owner notification letters were mailed August 21, 2023. Owners may contact Lion customer service at 1‑855‑546‑6706. Lion's number for this recall is R2023-007b.
Recall number 23V452000 · Recall details
Engine and engine cooling
- What is wrong
- Lion Electric Company (Lion) is recalling certain 2019-2025 LionC hybrid electric school buses. The surge tank may move and crack the firewall, allowing the tank to contact and damage the high-voltage cables.
- Risk
- Damaged high-voltage cables can shut down the high-voltage circuit, causing a loss of steering assistance or drive power and reducing braking power, increasing the risk of a crash.
- Remedy
- Lion technicians will install a new surge tank support bracket to the accessory plate, free of charge. Owner notification letters were mailed August 21, 2023. Owners may contact Lion customer service at 1‑855‑546‑6706. Lion's number for this recall is R2023-006.
Recall number 23V448000 · Recall details
What 2024 Lion Lionc owners say
Most recent owner complaints, unedited.
Front heater fan smelling of smoke
Compare the 2024 Lion Lionc
Other model years
2024
Questions about the 2024 Lion Lionc
Is the 2024 Lion Lionc reliable?
Owners have filed 2 complaints about the 2024 Lion Lionc, close to a typical Lionc model year.
What is the most common problem with the 2024 Lion Lionc?
Electrical system, with 2 complaints.
How many recalls does the 2024 Lion Lionc have?
5 recalls, covering electrical system, parking brake and service brakes, air.
Was there a recall on the 2024 Lion Lionc electrical?
Yes, 2 recalls: 24V460000, 23V452000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2024 Lion Lionc?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history