I have an inquire in regard to my 2006 lotus elise (VIN [xxx]) oil line issue that happened on 12/11/13. I was driving normally and the engine light came on all the sudden. I pulled over shortly after. While waiting for the tow truck, I already can see that the engine oil was leaking from the front right side. My car was towed to a local repair shop and found that the oil line was dis-attached from the connector. I had been trying to the called the lotus USA # 1800-245-6887 since the incident (12/11/13). I called on 3 different days (12/11/13, 12/20/13, and 12/23/13); called 5-6 times, and left 3 voice messages to [xxx] with my name, the inquiry, and my phone #, and until to date (11/24/13) no one ever called back. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
2006 Lotus Elise engine problems
13 complaints (76% of all complaints for this car). Typical mileage when it fails: 35,000.
- owner complaints
- 13
- of this car's complaints
- 76%
- typical mileage
- 35,000
- crashes
- 0
- recalls
- 1
Which part fails
- Engine2
- Cooling system2
At what mileage
Complaints by mileage at the time of the problem.
Lotus Elise engine problems in other years
Related recalls
Engine and engine cooling
- What is wrong
- Lotus is recalling certain model year 2005-2007 elise and exige vehicles manufactured from june 1, 2004, through november 30, 2006. The oil cooler line may become detached from its fitting.
- Risk
- A detached oil line could spray oil on a tire, increasing the risk of a crash, or it could spray oil throughout the engine compartment increasing the risk of a fire.
- Remedy
- Lotus will notify owners, and dealers will repair the vehicles as necessary free of charge. The safety recall is expected to begin on or before december 19, 2011. Owners may contact lotus at 1‑800‑245‑6887.
Recall number 11V510000 · Recall details
Related investigations
Engine Oil Cooler Line Detachment
On October 14, 2011, Lotus Cars USA Inc. notified the Office of Defects Investigation (ODI) that it will conduct a safety recall (11V‑510) to address concerns with engine oil cooler lines detaching from its crimped fitting on MY 2005-2006 Lotus Elise vehicles.In its 573 report to ODI, Lotus indicated that they have identified instances where the oil cooler lines would detach from their fittings.Lotus attributes this condition to a majority of single supplier affected parts built from June 2004 to November 2006.Lotus states that the cause of the failure is an inadequate process by which the hose is crimped into its fitting by the supplier.In October 2006 the supplier implemented an improved crimping process.Reports indicated that this condition can occur while driving or while the vehicle is stationary with the engine running.In cases where the failure occurred while driving, oil would be expelled under pressure and could come into contact with the tires and or brake friction surfaces, potentially causing a loss of braking or vehicle control. One crash and one vehicle fire were also reported with no injuries.Additionally Lotus indicated that the same condition can occur in MY 2005-2006 Exige vehicles as well. These vehicles are also included in the recall.The action taken by Lotus is sufficient to resolve the issues raised by this investigation.This investigation is therefore closed.
PE11022
What 2006 Lotus Elise owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2006 lotus elise. The contact stated that the vehicle was included in the recall associated with the federal safety agency campaign id number 11v510000 (engine and engine cooling:cooling system:hose). The manufacturer was notified and informed the contact that they had no time frame as to when the necessary parts would be available. The vehicle was not repaired. The failure mileage was 11,300.
Tl* the contact owns a 2006 lotus elise. The contact stated that the vehicle was included in the recall associated with the federal safety agency campaign id number 11v510000 (engine and engine cooling:cooling system:hose). The manufacturer was made aware of the situation and the contact was awaiting a response to find out how to pursue repairs. The vehicle was not repaired. The failure mileage was 13,000. ..updated 01/25/16 *bf updated 01/28/16.
Tl* the contact owns a 2006 lotus elise. The contact stated that the vehicle was parked when he noticed that oil was leaking abnormally. An independent mechanic examined the vehicle and advised the contact that oil was leaking from the oil filter. The vehicle was taken to an authorized dealer and the contact was informed that the vehicle was not included in the recall associated with the federal safety agency campaign id number 11v510000 (engine and engine cooling:cooling system:hose). The vehicle was not repaired. The manufacturer was made aware of the failure and offered no assistance. The failure mileage was 10,000.
Oil cooler hose separated from fitting at the sandwich plate on the engine.
As I was pulling onto my street, the oil light came on the dash. I immediately found a place to stop and park the car, at which time I noticed the smell of oil in the cabin. Upon exiting the vehicle I noticed oil on the front driver's side tire & wheel, and approximately 30 minutes after parking there was a large puddle of oil underneath the front half of the car. My online search for a possible cause of this incident has lead me to believe that I experienced a failure of the oil cooler lines.
Oil cooler supply line connected to the sandwich plate where the oil filter screws in, on my 06 lotus elise became disconnected from the coupling, spraying oil everywhere and permanently damaging my engine. The engine only has 50k miles on it, and now it needs to be replaced. New motor, and labor costing over 6000 dollars to fix. This is an issue that seriously needs to be addressed by lotus, as numerous lotus owners are reporting this and discussing this on the online forums. Being the 2nd owner of the vehicle, I am not covered by warranty and all the repair cost are coming out of my own pocket. I wish there was some way I can get some compensation back from lotus, as I only put 5k miles on the car before this happened...
I was driving home from work, and after about half of a mile I started to smell burning oil and thought to myself "boy, I'm glad that smell isn't coming from my car!" I was traveling at about 55 MPH. I looked in my rear view mirror and saw a thick trail of oil following me and looked at my oil light and saw that it was on. I immediately pulled over. There was oil covering the right rear tire, brake assembly, and suspension. The remaining two or three quarts came out while I was calling the tow truck. The shop mechanics said that the oil cooler hose slipped out of it's crimp and he showed me a photograph. I found out later that there is no easy fix. According to the experts in the lotustalk forums, it's common for the crimps to come undone. Although I had shut down the engine in time to avoid a complete seize up, the repair cost will still be around $2000 to replace the hoses and clamps. Most of the cost is from labor because it's difficult to pull the hoses through and the front clamshell needs to be removed. There are aftermarket kits to replace these oil cooler hose/clamp systems. I haven't figured out how I'm going to do the repairs yet because the nearest lotus dealer is $250 miles away. Although I was uninjured, I can see how this could cause injuries - either from the brake rotors getting coated with oil, fires, or the engine seizing up in the middle of a busy highway. The lotus elise is a great car, but the oil cooler hose clamps in the earlier models are a big problem!
Oil cooler line crimp fitting failed at the sandwich plate adapter while driving onto a highway ramp. Cloud of white smoke appeared in rearview mirror and oil pressure light illuminated. Turned vehicle engine off and repaired myself by modifying the crimp that failed.
The hose connecting the two oil coolers in the front of the car failed on the freeway. I felt the car dangerously losing traction on the left side of the driver and I also saw the oil light coming on, and pulled over immediately. I had to replace the hose, it cost me $775. Two weeks from that, the hose fitting failed again, my car is in the shop right now, who knows how much the damage is now.
Questions about the 2006 Lotus Elise engine
Does the 2006 Lotus Elise have engine problems?
Owners have filed 13 complaints about the engine of the 2006 Lotus Elise, 76% of all its complaints, more than any other problem.
At what mileage do 2006 Lotus Elise engine problems start?
The typical (median) mileage in owner complaints is 35,000 miles.
Was there a recall on the 2006 Lotus Elise engine?
Yes, 1 recall: 11V510000. Check your VIN to see if your car still needs the free repair.
What year does the Lotus Elise have bad engine?
The Lotus Elise model years with the most engine complaints are 2005 (31 complaints) and 2006 (13 complaints).
Other 2006 Lotus Elise problems
Steering 1Suspension 1Transmission 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Lotus Elise?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history