2016 Mack LR technical service bulletins
228 technical service bulletins and manufacturer communications cover the 2016 Mack LR.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- All Mack vehicles built with USA17, and forward emissions may experience damage to the diesel exhaust...
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr
- Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low...
- If oil dilution is suspected refer to the applicable CBR solution below: ∙ CBR-659Mack Chassis
- Frame lean can be caused by several seemingly isolated possibilities
- Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned...
- CBR: Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F)
- CBR: To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP fi le will need to be downloaded.
- CBR: The procedure to eliminate the Mack Chassis "Air Restriction Light On" seen in the cluster is to...
- Cbr: 11L, 13L
- CBR: Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil
- CBR: Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F, mDrive) Missing X1 Value...
- CBR -Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- Cbr
- Cbr
- Cbr: tgw
- CBR: For vehicles equipped with an 11L engine, the plastic saddle bracket holding the a/c line on the left...
- Unknown or other
- Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family...
- Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
- Barksdale Leveling Valve, Leak Test
- CBR: Programming Failure
- CBR: Mack DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00
- Mack NOx Sensor Troubleshooting Guide
- Vehicles Equipped With Chalmers Suspension
- Cbr
- Service Literature Published and Released in May, 2023
- CBR: Automated Manual Transmission ( AMT ) -Transmission Electronic Control Unit ( TECU ) MID130 PSID 29...
- CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
- CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
- CBR: Mack Chassis
- Cbr: 11L
- Mack Chassis
- Mack MMD Alternator Pulley
- Mack Model TE,LR
- Mack DEF Pump Troubleshooting Guide
- TSB-Charge Air Cooler t-clamp install.
- Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F )
- US10 Emission Engines
- Automated Manual Transmission ( AMT ) I-Shift / mDRIVE
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- Programming Failure
- Premium Tech Tool (PTT)
- DEF Pump Troubleshooting Guide
- Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- Mack Chassis
- Mack Chassis
- NOx Sensor Troubleshooting Guide
- Use for new vehicles (US21+OBD22
- Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- Temperature Sensor Troubleshooting Guide
- Mack Chassis
- Mack Chassis
- Mack Chassis
- (Back Office Only) Mack Chassis
- Mack Chassis
- Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet
- Mack Low Oil Pressure Diagnostic Process For 11 Liter Engines
- Mack Dealer Support Communication
- Mack
- Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors)
- Low Voltage Disconnect (LVD), Function Description
- Electronically Controlled Suspension (ECS) Losing Air Pressure
- No Start Condition After Over The Air Programing
- Mack Chassis
- DEF Pump Cycling periodically Hours After Key Off
- Mack Chassis
- Premium Tech Tool ( PTT ) Training Materials And Support Tools
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Volvo Chassis
- Mack Chassis -Technical Service Bulletin M-284
- Aftertreatment Control Module ( ACM ) Diagnostic Trouble Codes ( DTC ) U0001-88 and U0010-88 Lighting The...
- Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control...
- Engine Oil Analysis Specifications
- Diagnostic Trouble Code (DTC) P04DB
- Intake Pre-heater Electrical Schematics (Diagrams)
- Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide
- Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
- Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure
- Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL );...
- Mack Chassis
- Volvo Chassis
- Diagnostic Trouble Codes (DTC) P24F600 Or P24F700
- Mack Chassis
- Volvo Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Exhaust Gas Temperature Sensor Circuit Range/Performance
- Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number...
- Mack Chassis
- Mack Chassis
- Tech Tip
- Diagnostic Trouble Code (DTC) U3017
- Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not...
- Revised How And When To Diagnose A US14 / US15 Emissions P2463 Diagnostic Trouble Code ( DTC )
- Diesel Fuel Information
- Diagnostic Trouble Code (DTC) P0201 To P0206 FMI 13
- Air In The Fuel System Tests, Common Rail Fuel System
- Aftertreatment Control Module (ACM) Offline/Not Visible/Missing From Control Unit Information in Premium...
- Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24...
- Automated Manual Transmission ( AMT ) ( I-Shift, mDRIVE ) Equipped Chassis, OBD13 And Newer
- Mack Chassis
- Lighting Control Module ( LCM ) Replacement
- Model Year 2016, 2017 Chassis Equipped With A Fuller 10 Speed Transmission Displaying Error Message "...
- Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions
- Transmission Oil Cooler Hose, Replacement
- Valve, Common Rail, Removal
- Back of Cab Crack, Repair
- Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions
- Air Pressure Switch, Replacement
- Fuel Filter Housing, Replacement
- Assembled Camshaft
- Diagnostic Trouble Code (DTC) P04DB
- Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN...
- Exhaust Gas Recirculation (EGR) System
- Plugs, Pressure Protection Manifold
- Hood Insulation Separating From Hood, Insulation Installation Instructions
- Diagnostic Trouble Code (DTC) P24F6-00, Exhaust Aftertreatment Fuel Air Purge Valve Stuck Open Or DTC...
- Back over prevention
- Fuel Tank Strap Insulator Design Update; Fuel Tank Strap Appearance Changed
- Diagnostic Trouble Codes (DTC) P0194-00
- Mack Chassis
- Expired
- Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL )
- Mack Chassis
- Mack Chassis
- Mack Chassis
- ECM and ACM Reprogramming, OBD2015
- Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control...
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Diagnostic Trouble Code ( DTC ) P2698, Diagnostic And Repair Information
- Mack Chassis
- Mack Chassis
- Diagnostic Trouble Code ( DTC ) P026C Lighting The Malfunction Indicator Light ( MIL )
- Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL)
- Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
- Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL)
- Particulate Matter ( PM ) Sensor Diagnostic Trouble Codes ( DTC ) Illuminating The Malfunction Indicator...
- Diagnostic Trouble Code ( DTC ) P009E
- Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement )
- Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control...
- Diagnostic Trouble Code ( DTC ) P009E
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL )
- HVAC Filter Blocked, Repair, LR
- Mack Chassis
- Expired
- Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement )
- Mack Trucks has received reports from the aftermarket regarding oil leaks at the CCV housing inlet tube...
- On some MACK CHU, CXU, GU, TD, LEU, LR, and MRU trucks built from 01/14/2013 and 01/20/2017, the V-Stay...
- Mack trucks has received reports from the aftermarket regarding oil leaks at the ccv housing inlet tube...
- Buggy spring bracket, replacement, rear transmission support brackets are breaking on some mack leu and lr...
- Engine control module (ECM), reprogramming.
- Power divider lockout leakage, repair
- Engine fuel filters. engine fuel filters (part number 21380521) with week number date codes 15_33...
- Engine fuel filters (part number 21380521) with week number date codes ?15_33? (August 10, 2015) through...
- On MACK vehicles built between July 6, 2015 and January 15, 2016 equipped with a MACK CRD 150 carrier, the...
- V-stay rod cover, replacement
- Coolant level sensor, replacement
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Mack LR?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history