2022 Mack Pinnacle (Pi/PN) technical service bulletins
200 technical service bulletins and manufacturer communications cover the 2022 Mack Pinnacle (Pi/PN).
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- All Mack vehicles built with USA17, and forward emissions may experience damage to the diesel exhaust...
- Certain AN, GR, and Pl model trucks could experience an issue with the clutch position sensor causing PTO...
- Parker engine-mounted hydraulic pump service bulletin.
- Mack Trucks Equipped With A Cummins Engine
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr - z
- Cbr
- Cbr
- Vehicles affected by this issue will show coolant runoff on the front rights side of the engine.
- Cbr
- Cbr - 13
- Cbr
- Cbr
- Cbr
- Power train
- Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low...
- Mack DEF Level (UQLS) Sensor Troubleshooting Guide
- Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming
- Vehicles Equipped With a Common Rail Fuel System
- Mack Chassis
- If the vehicle door is open and the truck is in neutral, a popup message may appear on the Driver...
- If oil dilution is suspected refer to the applicable CBR solution below: ∙ CBR-659Mack Chassis
- Frame lean can be caused by several seemingly isolated possibilities
- Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned...
- Cbr - 11L
- Cbr
- Emission Recall
- Cbr: US17 ghg
- CBR: Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
- CBR: Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F)
- CBR: To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP fi le will need to be downloaded.
- CBR: The procedure to eliminate the Mack Chassis "Air Restriction Light On" seen in the cluster is to...
- CBR: Vehicles Equipped With A Lift Axle
- CBR: Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and...
- CBR: Overhead Wear Overview
- Cbr: 11L, 13L
- CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
- CBR: Turbo Compound 2nd Generation
- CBR: Mack Pinnacle With 70 Inch Sleeper -Heater Hoses/Pipes Rubbing Inner Hood
- CBR: Diagnostic Trouble Code (DTC) P107471
- CBR: Mack Chassis
- CBR: Drivers Information Display (DID)Inoperative After Cluster Replacement And Programming
- CBR: Mack Anthem (AN) And Pinnacle (PI) -Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4
- CBR: Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- Cbr
- Cbr
- CBR: Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F, mDrive) Missing X1 Value...
- CBR: Turbo Compound 2nd Generation
- CBR: Turbo Compound (TC) Hot Side Noise, Diagnostic Information.
- CBR: Chassis Equipped With VECU5 Active Datalink/Communication Faults For Multiple Modules; ABS And SRS...
- CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as...
- Cbr
- CBR -Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- Cbr
- Cbr
- Fleet Improvement
- Cbr: tgw
- CBR: Frame Or Cab Lean
- Engine and engine cooling
- CBR: For vehicles equipped with an 11L engine, the plastic saddle bracket holding the a/c line on the left...
- Parts Sales and Marketing Bulletin: Mack Trucks is excited to announce an additional year warranty program...
- Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family...
- CBR: Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In...
- CBR: Vehicle Speed Factor (K-Factor) Programming
- CBR: "Spitting" or "puffing" of air from purge valve.
- Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
- Air Restriction Indicator
- CBR: Intermittent Diagnostic Trouble Codes U02A3,U029D, U029E
- Barksdale Leveling Valve, Leak Test
- Emission Campaign: OBD MONITOR, This Recall includes an updated software in the EECU and ACM to address...
- CBR: Mack DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00
- Diagnostic Trouble Code (DTC) P103200: Particulate Matter Sensor Removed from Exhaust
- Vehicles Equipped With Chalmers Suspension
- Engine Control Module (EMS) Software (MSW) Information
- Cbr
- Mack NOx Sensor Troubleshooting Guide
- CBR: Diagnostic Trouble Code (DTC) P225C00 : NOx1 Sensor Stuck High
- CBR: Model Year 2017 to Current
- Cbr: snm 20-005 - hd
- CBR: Automated Manual Transmission ( AMT ) -Transmission Electronic Control Unit ( TECU ) MID130 PSID 29...
- CBR: Timing Gear Plate Repair
- CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
- Emission Campaign: Vehicle Emission Label
- CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
- EC: Mack Vehicle Emission Label
- Hub Cap, Leaking
- Diagnostic Trouble Code (DTC) P107471
- Oil In Coolant
- New TSB- Hub cap leaking
- Mack
- Mack MMD Alternator Pulley
- 13L Oil Pickup Replacement
- Mack Chassis
- Mack DEF Pump Troubleshooting Guide
- Barksdale Height Control Valve Troubleshooting Guide
- Timing Gear Plate Inspection
- TBS- Jumper Harness,Wiper Motor,Replacement
- Service Literature Published and Released in November, 2022
- Diagnostic Trouble Codes (DTC) P208064, P208464, P242B64 and P246F64 Lighting The Malfunction Indicator...
- Mack Essential Tool Shipment
- Turbo Compound 2nd Generation
- Mack Chassis
- TSB-Charge Air Cooler t-clamp install.
- Use for new vehicles (US21+OBD22
- Bendix Wingman Fusion, Front Radar Fulfillment
- 11L, 13L
- Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F )
- US10 Emission Engines
- Automated Manual Transmission ( AMT ) I-Shift / mDRIVE
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- Programming Failure
- Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver...
- Oil Pickup Replacement
- (Back Office Only)
- Premium Tech Tool (PTT)
- Back Office Mack Chassis
- DEF Pump Troubleshooting Guide
- Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide
- Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Mack Chassis
- NOx Sensor Troubleshooting Guide
- Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide
- Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- Temperature Sensor Troubleshooting Guide
- Mack Chassis
- Mack Chassis
- Mack Chassis
- Mack Chassis
- (Back Office Only) Mack Chassis
- Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet
- Mack Low Oil Pressure Diagnostic Process For 11 Liter Engines
- Mack Dealer Support Communication
- Mack
- Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors)
- Low Voltage Disconnect (LVD), Function Description
- Electronically Controlled Suspension (ECS) Losing Air Pressure
- No Start Condition After Over The Air Programing
- Mack Chassis
- DEF Pump Cycling periodically Hours After Key Off
- Mack Chassis
- Premium Tech Tool ( PTT ) Training Materials And Support Tools
- Mack Chassis
- Service Literature Published and Released in April, 2022
- Mack Chassis
- Proprietary Steerable Axle Hubcap Replacement
- Mack Chassis
- Mack Chassis
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Aftertreatment Control Module ( ACM ) Diagnostic Trouble Codes ( DTC ) U0001-88 and U0010-88 Lighting The...
- Engine Oil Analysis Specifications
- Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
- Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL );...
- EPRV Delete & Fuel Rail Pressure Sensor Update
- Mack Chassis
- Noise On The AM Radio Band; Thumping, Ticking, Fluttering Sound On AM Radio Band
- Volvo Chassis
- Dye Test Procedure; Fuel System Leak Check
- Diagnostic Trouble Codes (DTC) P24F600 Or P24F700
- Volvo Chassis
- TC Engine Turbochargers
- Mack Chassis
- Mack Chassis
- Mack Chassis
- (Back Office Only) Vehicles Equipped With A Turbo Compound Engine
- Mack Chassis
- Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number...
- Mack Chassis
- Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not...
- Trucks Equipped With A Cummins Engine
- Diesel Fuel Information
- Mack Chassis
- Forward Looking Radar Shortage
- Air In The Fuel System Tests, Common Rail Fuel System
- Aftertreatment Control Module (ACM) Offline/Not Visible/Missing From Control Unit Information in Premium...
- Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24...
- Automated Manual Transmission ( AMT ) ( I-Shift, mDRIVE ) Equipped Chassis, OBD13 And Newer
- Forward Looking Radar Shortage
- Valve Cover Oil Leak at T Joint
- 11 Liter Engines
- Mack Models CHU, CXU, AN, PI
- VECU Software Update
- Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions
- 1-Piece Hub Covers
- Disc Brake Rotor, Replacement
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Mack Pinnacle (Pi/PN)?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history