My mercedes benz 220c went dead at stop light causing danger to who ever was driving. I took auto to mercedes dealer who informed me that wire harness was deteriorating after only 80,000 miles on car. Also air flow was bad.
1996 Mercedes Benz C220 electrical complaints
Page 2 of 2: complaints 11 to 17 of 17, newest first, as owners wrote them.
Engine keeps shutting off while accelerating. This happened several times while driving sometimes in the left lane and then have to coast to the side. Very scary and unsafe!. ! I took vehicle to the mechanic and he said the engine wire harness needed to be replaced.
The 1996 mercedes c220 had a defective engine wiring harness. The check engine light came on and I serviced the car. The mechanic mentioned that mercedes used a recycled wiring cover that with the high temperature cracked and even melted. I was told by the service technician that he changed a few, and there was no charge. My car was not included, and I was requested to pay for everything. This was unexplainable. I had to pay twice for the diagnostic ($120) and for the labor ($700.). The engine wiring harness costs $1400.00. I am negotiating with customer service if they could cover the costs because it was an issue of poor workmanship or quality. I have never herd of engine wires cracking and melting on a car!! The service person was very nice and mentioned that this was not the first time and some even resulted in fires. I do believe that this should be recalled in all cars that mercedes benz cars that have been equipped with this type of recycled wire covering. It is a danger to all that drive this cars and others that it may effect if an accident results. To ignore this issue after it has been brought to the attention of customer service is to hold them liable in all accidents, deaths and injury that involve these vehicles.
1996 mercedes c220 - wiring has deteriorated to the point of the car no longer running, but they want to charge me $1080 just for the 30 feet of wiring harness to replace it - not to mention labor charges. Driving down the highway and the car just flooded out, started smoking, and quit. Now it will start then immediately die. Mechanic showed me the inside of numerous engine wiring channels where exposed copper wires lay next to each other with crumbly dry-rot looking rubber material which used to be insulation. This car has been meticulously taken care of. I have searched and found this problem reported all over the internet with people complaining but mb refuses to repair for a cheaper charge for their own factory defect. The dealer says that many left the assembly line already cracked back in 1996 as they had to replace many under warranty back then. This sounds like a deliberate scam to force customers to pay high repair costs for a known factory defect.
The engine light came on and the engine surges up and down. Vehicle is difficult to drive.
Severe degradation of the engine wiring harness which shorted out the air mass meter and throttle actuator. The vehicle stalled in heavy rush hour traffic. This wiring deterioration could have easily resulted in a vehicle fire, as has occurred in other mercedes-benz vehicles with this defect. Mercedes has denied any responsibility.
Wiring harness on a 1996 mercedes c220 with 74,000 miles intermittently failing, and causing car to stall on freeway and surface streets. This is putting me and my family in danger, as well as other drivers. Mercedes does not recognize this as a problem, there are numerous websites dedicated to this issue, hundreds of cases, and no response. This part which should outlast the car, is failing on cars with less than 100,000. I am afraid to drive my car! I don't know if it is going to completely stop in the middle of the freeway... And get me into an accident.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Mercedes Benz C220?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history