2007 Mercedes Benz CLK350: gas smell in the cabin

Filed Nov 13, 2020 · Fuel system · CA

When I fill the gas tank, there is a very steong smell of fuel inside and outside of the car. The smell ia there util at least half the tank is used. The same problem has been with "e" series. Mb issued a recall. However, the dealership tells me there is no recall for 2007 clk350 eventhough same parts are used to deliver the fuel.

Filed May 28, 2020 · Fuel system · GA

When I fill my car up I can smell gas in my garage. Once I drive it for a while and it gets below a half tank or so I don't smell the gas anymore. I am worried that the gas smell in the garage made some fumes into my house and this is a safety issue. I see some models of mercedes have been recalled for this reason. I would like mercedes to recall and repair this at no charge to me. Apparently mercedes covers model year 2003 to 2009 on the e class in 2006 to 2011 on the cls class. I am having the exact same issue. *bf *tr

Filed Sep 17, 2018 · Fuel system · 66,000 miles · FL

Strong smell of fuel from rear left side of vehicle after fill up. Fuel puddle found under rear passenger seat under fuel tank access panel. Left side fuel pump (fuel filter/sender) found cracked and leaking at the nipple to the outgoing gas line. This is a common failure for 10 year old e and c class mercedes and is part of a mercedes extended warranty program to correct this exact problem. However, mercedes tells me that my clk is not part of the warranty extension.

Filed Feb 22, 2018 · Fuel system · 103,000 miles · FL

After filling gas tank strong gas smell around car specially in the garage no visible fuel leak.no fuel smell in the car only outside by rear wheels.not in motion ,

Filed Feb 12, 2018 · Fuel system · 122,754 miles · UT

Gasoline fumes are inside and outside the vehichle after filling the tank. Mercedes agreed to warranty this issue for 15 years on the e-class and cls-class in ea 13-003. These components are the same on this model (clk). The investigation should be reopened and include all effected models.

Filed Feb 8, 2017 · Fuel system · 59,000 miles · CA

Very strong gasoline smell coming from under the driver side rear seat especially after filling gas tank. Mercedes agreed to warranty this issue for 15 years on the e-class and cls-class. Why didn't mercedes and the federal safety agency include this model (clk) that has the same problem with the same components?

Filed Mar 1, 2016 · Fuel system · 70,287 miles · CA

There is a strong gas smell coming from the vehicle especially after filling up the tank. It was inspected at fletcher jones mercedes benz dealer and the leak was found at the fuel tank filter, level sensor, and 2 seal rings. Due to the cost, I did not have the vehicle repaired at the dealer but at a local shop specializing in mb. Cost for the repair was $836.70. I am reporting this late for purposes of safety and trending.

Filed Oct 5, 2015 · Fuel system · 35,442 miles · TX

A very stong gasoline smell in the garage after having car filled. The strong smell has been going on for sometime but didn't think too much about it. Last week a plumber came to my house for a leaky pipe situation and noticed the smell and said that was not normal and cou ld present a fire hazard! I immediately took the car to greenway mercedes late on tuesday, 9-29-15. I said I won't have to pay for this because it must be a defect. They said indeed I would have to pay. The diagnostic showed that it was the seals in the fuel sending unit, and I paid $1400 to be repaired. I told them I was going to file a complaint with you because I had researched and found other complaints filed for the same problem with you.

Filed Apr 26, 2014 · Electrical, Engine · 66,400 miles · PA

Driving down the road at a slow speed and the car just quits. Sometimes it will start itself back up and sometimes I have to pull off to the side of the road to turn ignition off and then on again. The car will just quit at highway speeds and after some quick thinking and realizing what just happened the only thing to do is drift to the berm of the road with no pwr steering or brakes. There are also times when I start the car it will quit and takes two to three more tries. Also had a severe raw gas coming from the car after a fill up. The gas fumes were so severe that we had to park the car outside for fear of an explosion in our garage. I took the car to the mb dealer in pittsburgh and they were able to repair the gas problem as the gaskets around the gas tank were dry-rotted and I paid approx $600.00 for this repair which I feel that mb should have covered since at 66000 miles this should not happen. As usual they could not duplicate the stalling issue. Mb know of this problem but will not do anything since it doesn't show up on there computer hook-ups. Something needs to be done before people get killed. I'm sure I'm not the only one this happens too.

Filed Oct 21, 2012 · Fuel system · 29,500 miles · PA

There is a very strong gas smell. It is overwhelming, lasts for days, and we need to park the car outside of the garage, as the smell is so intense it makes you feel sick. It just started happening about a week or two ago, and seems to be most obvious after getting fuel. I searched the internet and found that this seems to be a very common problem with a lot of mb owners having similar issues. Also, there seems to be a recent class action suit initiated by the federal safety agency involving this problem. I'm concerned this could be a life threatening safety problem if an explosion occurs and the intense fumes seem likely to cause other health related problems.