Tl* the contact owns a 2005 mercedes benz e320. While parked, the contact noticed a strong fuel odor in and around the vehicle. The vehicle was not taken to the dealer for diagnostics or repairs. The approximate failure mileage was 35,000.
2005 Mercedes Benz E320 fuel system complaints
Page 5 of 5: complaints 101 to 122 of 122, newest first, as owners wrote them.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated that when the fuel tank was full, he would smell gasoline from the interior of the vehicle. The vehicle was taken to the dealer for inspection who stated that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 100,000.
After filling the gas tank, I noticed a strong odor after I got home and got out of car. After further inspection I noticed puddle of gas on drivers side of car just in front of rear tire. This happens every time now when I fill up the gas tank. My short term resolution until this can be fixed is to not fill up gas tank all the way.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated that the fuel was leaking. There was also a strong gasoline odor emitting from the rear of the vehicle that would worsen when the fuel tank was refueled to capacity. The vehicle was taken to a private mechanic but was neither diagnosed nor repaired. The manufacturer was notified of the issue who advised the contact that the vehicle was outside of warranty and provided no further assistance. Failure mileage was 98,000 and current mileage was 101,000.
Noticed a strong gasoline odor emanating from the rear of the car. On further investigation, I discovered that there was fuel pooling underneath the drivers side back seat and that two electrical wires were submerged in the fuel collecting underneath the seat. The fuel originated from a crack near the top of the fuel sending unit. This is a potential fire hazard not to mention the significant health issues to all passengers including the nine year old that is transported in this vehicle. This is a known issue and should be thoroughly investigated.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated that the fuel tank was leaking. The contact took the vehicle to the dealer and was informed that there were multiple leaks in the fuel tank and the fuel tank needed to be replaced. The VIN was not available. The failure mileage was unknown and the current mileage was 70,000.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated after refueling, a strong odor of would emit outside of the vehicle without any sign of fuel leakage on the ground. On a separate occasion when driving the engine warning indicator illuminated continuously on the instrument panel. The vehicle was taken to an independent mechanic who stated the fuel tank and fuel pump would need to be replaced. There was currently an open investigation under the federal safety agency action number pe12001 (fuel system, gasoline: delivery: fuel pump, fuel system ,gasoline: storage: tank assembly). The vehicle had not been repaired. The authorized dealer and manufacturer were notified of the defect. The failure mileage was 63,400. Updated 05/02/12*bf the consumer stated the dealer denied problem. Updated 05/12/2012 *js updated 10/12/12
I've had the smell of fuel in my e320 base model for about 2-3 months now. I didn't pay it much attention until now (3/31/2012) when I did a little research for myself and found a leak from the fuel pump to fuel line housing. I did not take pictures but the hose line connection to the pump was cracked and upon taking hose off pump housing, the housing connection snapped completely off. In the process of trying to find another fuel pump now because vehicle is disable.
After filling the fuel tank completely full, I noticed a strong smell of fuel. I removed the rear passenger seat and also removed the two panels that cover the fuel sending unit. Once I removed the two panels I saw a puddle of fuel sitting in a low spot on top of the fuel sending unit. This concerns me as it is puddling and vapor is being put into the passenger compartment of the vehicle as well as the atmosphere.
Fuel tank leaks fuel at the top when tank is filled higher than 3/4ths. There are several hundred reports of this on these models on the internet. The issue appears to start occurring around 90-100k miles. Since mercedes are made to go many miles this can be an issue. This is very dangerous. I have had it at a mechanic he told me that I should report this to mercedes as it appears that the plastic fuel tank has a flaw in it. We have not fixed the problem as we want it to be investigated. Looking for guidance.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated that after refueling, the smell of fuel was potent inside and outside of the vehicle. The vehicle was taken to the dealer where the dealer confirmed that the fuel lever sensor needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 100,000 and the current mileage was 103,000.
After parking my car in the garage after a refill, I notice a the smell of gas coming from my car. When I took a closer look I notice that my car was leaking gas and the smell was horrific. This is a serious emission issue that not should be happening in mercedes benz.
Tl* the contact owns a 2005 mercedes e320. The contact stated that the check engine light illuminated, so the vehicle was taken to an authorized dealer and she was informed that the fuel tank was leaking. The contact was also informed that the leak was located at the top of the fuel tank. As a result, a strong odor of fuel would emit from the vehicle during the first fifty miles of driving after refueling. The vehicle was not repaired. The failure mileage was 70,000 and the current mileage was 83,000.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated that there was an overpowering gasoline smell inside the vehicle, interfering with the contacts ability to operate the vehicle. The vehicle was taken to the dealer where the dealer advised that the fuel tank was leaking abnormally and needed to be replaced. The manufacturer was not contacted. The contact was concerned that the leaking fuel tank could result in a fire and that the vehicle was unsafe to drive. The failure mileage was 41,190.
Vehicle was acting normally up to incident. Entering highway accelerating like normal and pulled out in front of tractor trailer when suddenly car had dramatic and frightening loss of power. Full throttle did nothing. Downshifting did nothing. With truck horns blaring and near collision, I pulled off the road. Restarting cleared the problem. Dramatic loss of power has occurred three more times with no warning nor check engine light. Now light comes on with egr out of range code. Discussing this with other mercedes diesel owners points towards soot clogged egr valve and soot clogged intake manifold. How such a problem could occur so frequently at such a low mileage with a company known for diesels is unknown.
2005 mercedes benz e320. Consumer states fuel filter assembly problem *tgw the consumer stated after refueling the vehicle, a strong odor of gas was present. After the fuel filter problem was diagnosed, the mechanic had no idea there was also a gas tank problem. The next month, the strong odor of gas was back again. The vehicle was taken to the dealer and the consumer was informed the fumes were coming from the gas tank due to a defect in the gas tank design. A hold was discovered in the gas tank under the passenger compartment.
Gas leak rear tanks mercedes e320, gas leaks out when tank is full, dealer says to not to; off tank. Cill cost $2200 to fix. No warranty. Car only 5 years old and needs new gas tank. Dealer should pay for this kind of maintenance, is replacing gas tank every 5 years typical maintenance? This could cause fire, very dangerous.
Tl* the contact owns a 2005 mercedes benz e320. The contact stated that there was an overpowering gasoline odor in the vehicle. The vehicle was taken to the dealer who diagnosed the failure as a fracture in the fuel tank. The manufacturer was contacted who did not offer any assistance. The vehicle was not repaired. The VIN was unavailable. The failure mileage was 50,000 and current mileage was 77,000.
Car bought off lease from mercedes benz credit at auction. Almost immediately began to smell strong fuel vapor odor when the car was filled with fuel. Determined that fuel tank is made out of plastic. This plastic fuel tank had a crack in it. It had to be replaced at my cost. I believe this should be a national recall and be paid for by mercedes benz. Online, there are many reports of this occurring in other mercedes e320's like mine. The dealer admitted replacing over 20 of these fuel tanks per month.
Tl-the contact owns a 2005 mercedes benz e320. The vehicle was parked in the contacts garage when the contact could smell a strong odor of gasoline. The vehicle was recently refueled prior to the failure. The vehicle was taken to an independent repair shop where the contact was told the fuel tank was leaking. The was in the process of being repaired. The failure and current mileages were 52,000. Sm.
Tl*the contact owns a 2005 mercedes-benz e320. While the vehicle was parked he noticed a gasoline odor and a leak on the garage floor. The contact started the vehicle and the check engine light illuminated on the dashboard. The vehicle was taken to an authorized dealer for the failure. The dealer performed a diagnostic test and it was determined that there was a spurge leak. The dealer performed a smoke test which did not determine the cause of failure. The computer was reprogrammed on january 12, 2009. The contact noticed a fuel smell every time he added fuel to the vehicle after the dealer reprogrammed the computer. The vehicle was taken back to the dealer on may 6, 2010. The dealer replaced the fuel seal in the fuel tank sending unit. The vehicle was taken back to the dealer on january 31, 2011 and the dealer advised him that the fuel tank needed to be replaced. The vehicle was not been repaired since the fuel tank was no longer under warranty. The failure mileage was 49,000 and the current mileage was 70,000. Updated 04/08/11*lj updated 12/28/2011
At 2 separate times the high pressure diesel injection system failed and dumped raw diesel all over. On the last event it sprayed against the exhaust headers and created a lot of smoke.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Mercedes Benz E320?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history