2009 Mercedes-Benz E350 fuel system problems

Filed Jul 14, 2022 · Fuel system · 147,000 miles · CA

The contact owns a 2009 Mercedes-Benz E-350. The contact stated while driving 30 MPH and coming to a complete stop, the vehicle started sputtering and stalled. The contact pushed the vehicle to the side of the roadway. The contact was unable to restart the vehicle after several attempts. The contact towed the vehicle to her residence five days later. The contact used an OBD reader to determine that the failure was associated with the fuel system. The contact replaced the fuel relay and fuses, fuel pump and fuel filter herself; however, the vehicle failed to start. The vehicle was then towed to the dealer and diagnosed with a fuel leak. The contact was informed that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under an unknown recall because the VIN was not included. The failure mileage was approximately 147,000.

Filed Apr 4, 2022 · Fuel system · CA

This vehicle has a very profound strong gas smell inside and out of the car. Upon further research, it has been notably stated that this particular vehicle model from years 2003-2009 had the same common issue that when refueling and topping off at full tank capacity, there is a fuel leakage seeping from the top of the gas tank which sits underneath of the back passenger seat. Apparently there is a health hazard recall listed upon this vehicle for this issue but when I called my local mercedes benz dealer they said that there was no recall with this issue and refused to acknowledge the problem. But in fact there are many videos of evidence online illustrating and showing other same vehicle owners addressing the fuel tank leakage from within underneath the back passenger seat, and there is also many written testimonials cases stating the existance of the same issue. I really do hope this issue gets addressed asap for which i do fear for my family's safety and mine. Thank you in advance for your time!

Filed Jan 26, 2022 · Fuel system · 132,000 miles · FL

The contact owns a 2009 Mercedes-Benz E350. The contact stated while driving immediately after refueling, there was an abnormally strong fuel odor inside the cabin of the vehicle. The vehicle was taken to the local dealer but was not diagnosed. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 132,000.

Filed Oct 9, 2021 · Fuel system · CO

I’m smelling gas fumes inside and outside of the car. I heard there was a 15 yr warranty on E Class with this issue.

Filed Mar 3, 2021 · Fuel system · 133,000 miles · FL

Serious smell of gasoline during and after refuelling. Occurs while stationary.

Filed Feb 16, 2021 · Fuel system · 128,000 miles · SC

When I was filling up the fuel completely, I had a smell of fuel from the back when I parked the car, so I tracked the car and found the fuel drops coming down from the left side in the back, so I stopped the car and took it home and I checked the transmitter unit in the back seat as a mechanical engineer, and I found fuel leaking from the top of the transmitter unit, when I asked about this problem, I found that there is a 15-year guarantee on this subject and I added some evidence that supports the problem, including some customer complaints, and a response to them by the maintenance department im living in saudi arabia and for contact me +[xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Feb 7, 2021 · Fuel system · 128 miles · CA

When I was filling up the fuel completely, I had a smell of fuel from the back when I parked the car, so I tracked the car and found the fuel drops coming down from the left side in the back, so I stopped the car and took it home and I checked the transmitter unit in the back seat as a mechanical engineer, and I found fuel leaking from the top of the transmitter unit, when I asked about this problem, I found that there is a 15-year guarantee on this subject

Filed Oct 20, 2020 · Fuel system · 120,000 miles · CA

Gasoline odor is noticed when fuel is added to the fuel tank. It is very noticeable when car is parked in the garage for over 5 minutes after a recent fuel fill. The odor is very strong and has caused household members to have headaches. I am forced to park the car outside due to this odor. I also noticed gasoline spilling on the floor near the fuel tank area.

Filed Sep 19, 2020 · Fuel system · 84,000 miles · CA

I am having an issue with my e350 (09), every time I fill up my tank I can smell the gas. I don't smell it inside the car but outside the car and it is strong. It is really strong that you thought the gas spilled. Once the gas goes down to like 3/4 of a tank the odor will be gone. I tried tracing where the gas odor is coming from and I think it is under the fender on the rear driver side.

Filed Mar 26, 2020 · Brakes, Fuel system · 86,345 miles · DC · crash · 1 injury

At approximately 11:50 a.m. On tuesday, february 11, 2020, I pulled out of our driveway onto spruce dr. Nw, going south and the car immediately started accelerating on its own, careening down spruce dr. Nw. I was desperately trying to miss parked cars on the street but my car was moving faster and faster, out of control through the intersection at the end of my block. Then my car was flying through the air, between 25-40 MPH, slamming into a creek bank and ending on the driver side down a 30 foot ravine at the end of spruce drive nw. I was trapped inside the car with my seat belt on and according to the police report the side airbag had deployed. Thankfully, I did not hit any cars! It was truly a miracle that I was alive and that my neighbors heard and saw the crash. Within five minutes the metropolitan police department who were stationed at the mayor's house around the corner arrived and with my neighbors were able to pull me from the wreckage through the sunroof. Apparently the glass sunroof had popped open/off during the crash. The crash happened about 11:53 a.m. Shortly thereafter, I was taken by ambulance to a trauma center in a local hospital. Fortunately I only had minor bruises but the trauma center staff gave me a thorough check-up. And no one else was involved in the crash.