A gasoline smells fills the cabin and the outside surrounding area the vehicle continually to the point making anyone surrounding the vehicle and or sitting in the front and back seats physically sick. The gasoline smells omits continually from the backseat and or trunk area no matter the amount of fuel that is in the tank. It is a fire hazard and also health hazard as well.
2011 Mercedes-Benz E350: gas smell in the cabin
21 of the 223 complaints about the 2011 Mercedes-Benz E350 describe gas smell in the cabin.
- owner complaints
- 21
- of this car's complaints
- 9%
- typical mileage
- 61,000
- recalls
- 1
Is there a fix? There is 1 recall and 2 service bulletins for this area of the car. See below
Gas smell in the cabin by model year
What owners say
The contact owns a 2011 Mercedes-Benz E350. The contact stated that on multiple occasions when fuel was administered into the vehicle, he observed a strong fuel odor in the cabin. The vehicle was taken to the residence and parked. The contact stated that as he came out to inspect the vehicle he observed a leak under the vehicle near the fuel spout. The vehicle was inspected and the rear seat and the access panel were removed and a large amount of condensation was present near the fuel tank. The vehicle was taken to a dealer where it has yet to be diagnosed. The manufacturer was notified of the failure. The failure mileage was 159,143.
With less than 40,000 miles on the odometer, I noticed a gas smell both inside the car and outside. I was able to access the fuel filter assembly on the top of the gas tank and found it had a substantial leak resulting in a puddle of fuel on the assembly. The car has never been in a wreck on had any damage that would cause this problem. I researched and found earlier years of the same model had this problem resulting in Mercedes Benz extending the warranty to 150,000 miles for this part. They have refused to warranty my car. This is a major safety issue and by releasing gas fumes into the atmosphere is an environmental problem as well.
The contact owns a 2011 Mercedes-Benz E350. The contact stated that while driving at an undisclosed speed, a strong fuel odor was detected. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 42,900.
On October 6, 2021 I took my vehicle to Mercedes Benz of Stevens Creek because ewhen I filled my gas tank there was a very strong smell of gasoline inside the car and in the garage. The service department found the passenger side fuel sender upper cover leaking. The same situation is occuring presently, April 5, 2023, very strong smell of gasoline inside the car and garage after I fill the car with gasoline. The Mercedes Benz of Stevens Creek invoice # is 934052, Tag # TEK93. This is a safety issue that could ceate a fire hazard if the vehicle were to be involved in an accident.
The contact owns a 2011 Mercedes-Benz E350. The contact took the vehicle in for an oil change and was informed of a recall for fuel system failure. The contact stated that there was an abnormally strong fuel odor whenever there was more than ¾ tank of fuel. There were no warning lights illuminated. The vehicle was not repaired. The contact was provided with Mercedes-Benz Technical Service Bulletin Number: 2013020002. The VIN was not included in the federal safety agency Campaign Number: 12V557000 (Fuel System, Gasoline). The manufacturer was not notified of the failure. The failure mileage was 65,000.
While filling the gas tank, gas continued to pour from the pump, even though the tank was full. Usually the pump automatically stops dispensing gas when the tank is full. Gas splashed all over my car and myself. Also, my car often smells like gas after filling up the tank. It seems dangerous to have gas fumes inside of my car. I feel like a rolling bomb driving after a fill up. What’s going on?
My vehicle developed a raw fuel smell inside and outside the vehicle. Also the check engine light came on. The problem was resolved by the dealer after some time under PZEV warranty. What I am concerned with is why was this not a recall as the vehicle fuel vapors could of caused a fire in our garage or while we were operating it. Please note there was raw gas on the outside of the fuel tank.
The contact owns a 2011 Mercedes-Benz E350. The contact stated that while driving at 30 MPH, a strong fuel odor was detected inside the cabin of the vehicle. The contact rolled down the windows, but the fuel odor was still detectable. The contact pulled over and inspected the vehicle, but there was no visible fuel leakage. The failure recurred three times. The vehicle was taken to the dealer, and it was diagnosed that a cover for the passenger's side fuel sending unit was leaking gasoline. The passenger's side fuel sending unit needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure but informed the contact that the vehicle was out of warranty. The failure mileage was approximately 194,000.
Strong smell of fuel after refueling the vehicle, inside and outside the vehicle. Appears to be similar to issues related to the 2003-2009 model years previously investigated by the federal safety agency and closed in december 2014.
Strong gas odor after filling and for few days took it for repair find the sending unit cover leaking it had filled the cover and part of the tank.the odor was on and of about six months ago but only it was getting worse lately and needed repair. I think mercedes company should take this safety issue seriously before major ....
Gas odor from left rear wheel,
Service bulletins that may apply
Related recalls
Fuel system, gasoline
- What is wrong
- Mercedes-Benz is recalling certain model year 2011-2012 S400, S550, S550 4Matic, S63 AMG, C300, C300 4Matic, E350, GLK350, GLK350 4Matic, CL550 4Matic, and CL63 AMG vehicles manufactured from April 18, 2011, through July 12, 2011. Due to an irregularity stemming from the molding process of the fuel filter flange, the fuel filter flange may crack when operated in high temperatures.
- Risk
- If the fuel filter flange cracks, it will leak fuel which may lead to a fire if an external ignition source is present.
- Remedy
- Mercedes-Benz will notify owners, and dealers will replace the fuel filter, free of charge. The recall campaign is expected to begin in February 2013. Owners may contact Mercedes-Benz at 1‑800‑367‑6372.
Recall number 12V557000 · Recall details
Questions about the 2011 Mercedes-Benz E350 fuel smell
Is gas smell in the cabin a common problem on the 2011 Mercedes-Benz E350?
21 of 223 owner complaints about the 2011 Mercedes-Benz E350 (9%) mention gas smell in the cabin. The model year with the most reports is 2007.
Is there a recall or service bulletin for this on the 2011 Mercedes-Benz E350?
There is 1 recall and 2 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2011 Mercedes-Benz E350
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 Mercedes-Benz E350?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history