Tl* the contact owns a 2006 mercedes benz e500. The contact stated that after refueling, fuel fumes were emitted into the vehicle. Also, the contact mentioned the fuel tank could only be filled half way to avoid the fuel from leaking. The vehicle was taken to an independent mechanic. The technician diagnosed that the fuel tank needed to be replaced. The vehicle had not been repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
2006 Mercedes Benz E500 fuel system complaints
Page 2 of 2: complaints 11 to 29 of 29, newest first, as owners wrote them.
On 7/23/14, I noticed a strong odor of gasoline emanating from the inside and outside of my car after refueling. I purchased a certified pre-owned w211 2006 mercedes benz e500 from mercedes-benz greenway. I researched the issue online and discovered that the gas odor issue I was experiencing may be related to a problem being seen in numerous mercedes benz e-model vehicles. As advised by the other owners having this issue, I detached the rear seat cushion from the car and removed the bolts from the circular access panel that covers a portion of the fuel tank on the driver's side of the vehicle. In the depression on top of the gas tank where numerous electrical wires attach to the fuel sending unit, I found a significant quantity of raw gasoline pooled. This presented a very unsafe situation and I was no longer willing to park the vehicle in my garage due to the potential fire hazard. The pooling of raw gasoline also represents an environmental issue due to the evaporation and creation of toxic fumes. I took photos of the raw gasoline sitting on the fuel sending unit. Mercedes-benz of sugarland demanded $1,022.57 to rectify the problem by removing and replacing both fuel sending units/pumps in my vehicle. Mercedes-benz of sugarland did not return my old parts after I requested them. I feel that the manufacturer of this defective component should be held responsible to recall it and replace it. I understand that the federal safety agency's current investigation action numbers for this issue are pe-12001 and ea-13003. Read more: http://mbworld.org/forums/e-class-w211/437486-urgent-the federal safety agency-opens-investigation-into-fuel-leaks-w211-e-class-7.html.
I filled the vehicle up a on 5/10/14 and the next day my wife was telling me there was a strong gas odor in and outside of the car. On may 12. 2014 I inspected the vehicle and the gas odor was extremely strong. I looked online for similar problem and they said it was an issue for all mercedes e-class (2006 - 2009). I removed the rear seat and found the leakage at the fuel pump.
I began to notice a strong smell of gasoline inside my garage for the past week. Last weekend I was waiting for someone inside my car with the engine running and I felt the strong smell of gasoline. I noticed that the smell decreased somewhat when my gas level went down almost to empty. When I refuel the car the smell got very strong again. I am calling the dealer to make an appointment.
There was strong gas odor after filling up the car with gas. The rear passenger side would smell of gas until the gas tank reached below approximately 70% levels. After parking in the garage, it smelled as there was a gas leak. This would not occur if the we didn't fill up the gas tank.
I am greatly concerned. I smell gas inside and outside of my mercedes e500 2006 model. After fueling up my car , I smell gas inside the cabin towards rear seat area and outside of the drivers rear of the car. This cannot be safe and not healthy breathing in fumes of gas . I have children that sit in the back seat. They are breathing in fumes . My son was diagnosed with cancer after this problem with the car. I question if this was the cause, exposure to gas inside the car. The car is @ the mercedes dealer being looked at as we speak.
Smell of gasoline from car when in garage and parking lots.
After filling the fuel tank last september I noticed a very strong gasoline smell in the cabin of the vehicle. This happened 2 more times before bringing the vehicle in to my mechanic. He explained that there was a leak at the top of the fuel tank.
I have a 2006 e500 sedan. Just before the three year warranty expired, we notice a strong fuel smell in the car. We had a mercedes dealer, check it out and the serviceman said he found the problem with a seal on the fuel pump panel below the left rear seat. Said he had the problem fixed. This was the area of the problem but he didn't stop the leak. After the warranty expired we had the car serviced and the dealer found a bayonet fitting to a overflow cannister disconnected. The leak problem still persist and I have resorted to not filling the car up with gas. I have had to rip out the sound proofing blanket under the rear seat because of fuel odors. ( it got soaked. ) the seat foam got wet in the area just above the fuel access panel. Is there a seal (o-ring or otherwise in the fuel tank o cap in that access area) should I take the cap off and look for a burr on the tank? What torque value or how tight should this cap be screwed on the tank?
Tl* the contact owns a 2006 mercedes benz e500. The contact stated that whenever refueling, he would smell a strong gasoline fuel odor inside and outside the cabin. The vehicle was taken to an independent mechanic for diagnosis and the contact was informed that there was a leak in the fuel pump that was located under the rear seat. The vehicle was not repaired. The failure and current mileage was 60,000.
Strong odor of fuel inside vehicle after filling the fuel tank at station. Smell went away after approximately 50 miles.
GAS SMELL INSIDE OF THE CAR, VERY CONCERNED. the federal safety agency ACTION# PE12001.
I noticed strong gasoline smell in my 2006 e500. The smell is very strong inside the cabin and my vehicle always stays in the garage. When I walk into the garage I also smell a very strong gas odor. I had similar smell 2 years ago and got it to the dealer. They said the fuel tank opening under the rear seat was not properly closed and leaked the gas. They claimed they fixed it and also replaced any insulation that was there the to ensure smell completely goes away. For a while I was not getting the smell but it suddenly started coming and it is very strong. I also hear that it is affect lots of vehicles.
Fuel tank cracked. Unexplained, and confirmed by dealer. Fumes leak from exterior (can detected when tank is near capacity). Clear and present danger. Mb solution is to replace defective tank. Pe12001 (related case it would seem) -- e class.
I recently noticed in my 2006 e500 4matic that after I put a full tank of gas in the car, there is a strong odor of gas coming from the rear driver side back seat. My car is garage kept and once I enter the garage in the morning to go to work, its very strong odor of gas. I am concerned that there is a gas leak of some sort. I have a 2 1/2 year old son that sits behind the driver side rear seat. This gas leak smell has happened to over several hundred eclass vehicles.
Tl* the contact owns a 2006 mercedes benz e500. The contact stated that there was a fuel leak coming from the fuel pump, causing fuel to leak into the interior of the vehicle. The contact took the vehicle to the dealer and was told that the failure was within the fuel filter module. The vehicle was not repaired. The failure mileage was 50,000 and the current mileage was 62,000.
Fuel smell inside cabin after refilling to 100% capacity. Only goes away once car has crossed 3/4 tank which is normally about 75 miles. There have been hundreds of complaints just like this, I have had it looked into as much as I could, but could not afford to have my mechanic pull the fuel tank to diagnose further. This needs to be looked into and fixed. Normally mercedes is excellent when it comes to safety issues, I'd think they'd take this a bit more seriously. This investigation is related to action number pe12001.
The interior cabin of my 2006 mercedes benz e500 has a strong odor of gasoline, especially after refueling. Recently, I get headaches and dizzy when driving, so I have to roll down the windows to get rid of the smell. I have addressed this problem to multiple mercedes benz service centers and they said that there is no danger but if I wanted the smell to go away, it would cost me appx $2000. I feel that this is a danger while driving because the fumes can cause the driver to pass out, or a spark in the car possibly from a short circuit or cigarette lighter could ignite in the car and cause an accident. After doing research regarding this matter, it seems it is the exact complaint of: reference the federal safety agency action number: pe12001. I feel that this engineering/manufacture defect should be addressed by mercedes benz and repaired due to its potential hazards it may cause on the highway.
Strong smell of gasoline inside & outside of car for 2-3 days after gas fill up. Car into mercedes benz of pembroke pines fl. Oct. 10, 2010. Replaced l/side fuel sender unit. Strong smell of gasoline remained so strong could not drive more than a few blocks or park in garage. Car back to mercedes nov. 5, 2010. Diagnosis - faulty gas tank vent. Replaced gas tank got car back nov. 13, 2010. Repairs well over $2000. Even though car emitted gas smell detectable from 50 feet, and clearly unhealthy to drive, not considered emission issue. Mercedes internet forums indicate this is a common problem with 2003-2006 e class.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Mercedes Benz E500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history