Mercedes Benz M Class recalls

What is wrong

Mercedes-benz is recalling certain model year 1999-2002 m-class and model year 2000-2003 m-class amg vehicles. The cruise control system in the affected vehicles allows the driver to disengage the system in a number of ways, including tapping the brake pedal, using the cruise control stalk, or braking the vehicle enough to reach a certain rate of deceleration. Mercedes-benz has determined that under certain circumstances use of the brake pedal may not automatically disengage cruise control as expected by the driver, although the other means of deactivating cruise control remain fully operative. Specifically, where the driver pumps the brakes rather than applying consistent pedal force, the level of force required may be unusually high.

Risk

Difficulty or delay in disengaging cruise control can increase the risk of a crash.

Remedy

Dealers will repair the vehicles free of charge. The safety recall began during october 2011. Owners may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 11V208000 · Recall details

What is wrong

Mercedes benz is recalling 16,130 my 2009 m-class w164 passenger vehicles equipped with the optional power lift gate. As a result of a faulty seal around the rear tail lamp assembly, water may enter the rear compartment containing the spare tire. Water contamination of the control unit for the power lift gate can result in disabling of the power lift gate motor.

Risk

Water will cause a short circuit which could lead to a fire.

Remedy

Dealers will replace the seal of the rear tail lamp assembly with a thicker one and reposition the affected power lift gate control unit inside the chassis. This service will be performed free of charge. The recall is expected to begin during april 2009. Owners may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 09V076000 · Recall details

What is wrong

Mercedes-benz is recalling 577 my 2008 gl-class, m-class, and r-class vehicles. A defect may exist in the driving pin used to control the oil pressure of the power steering.

Risk

If a defective driving pin exists in a vehicle and the pin breaks during normal vehicle turning, the normally available hydraulic support function will no longer function and steering wheel operation will be limited.

Remedy

Mercedes-benz will replace the steering gears. The recall began on january 28, 2009. Owner may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 08V682000 · Recall details

What is wrong

Mercedes-benz is recalling 125,228 my 1998-2004 m-class vehicles. The hose clamp used to secure the power steering fluid cooling hose to the power steering fluid cooler may not provide sufficient clamping force for this connection.

Risk

The loss of power steering fluid may result in diminished power steering over time and ultimately can damage the power steering pump. This could result in a loss of control and a crash without warning.

Remedy

An earlier recall repair performed on these vehicles may not be sufficient to prevent a future leakage or failure of the power steering hose connection (please see 03v121). Since it is not possible through inspection to identify specific vehicles that may not have been properly repaired, all vehicles repaired prior to november 15, 2003, will be repaired again. The recall is expected to begin during november 2008. Owners may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 08V465000 · Recall details

What is wrong

Mercedes-benz is recalling my 2006-2008 m-class, r-class, my 2005-2009 slk-class, my 2005-2008 c-class, my 2003-2004 and 2006-2008 clk-class, my 2003-2008 e-class, my 2004 and 2008 cl-class, my 2008 cls-class, my 2004 and 2007-2008 s-class, my 2003 g-class, and my 2003-2004, 2006 and 2009 sl-class vehicles. A software calibration number (scn) coding received on the affected vehicles during a recent workshop visit was incorrect. Depending on the model year and model affected, the results of an incorrect scn coding can affect a number of vehicle safety and emission functions including the following types of functions: (1) the fuel gauge readings may be incorrect; (2) a stuck fuel-level sensor may not be displayed in the instrument cluster; (3) the obd system may cause the check engine light to illuminate incorrectly; and, (4) the speedometer may be out of tolerance.

Risk

In the event of a vehicle crash, the electrical fuel pump may not receive a crash signal that is required for the fuel pump to disconnect and prevent future fuel delivery as designed.

Remedy

Dealers will recode the scn free of charge. The recall began on august 30, 2008. Owners may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 08V303000 · Recall details

What is wrong

On certain vehicles, the accelerator pedal might not have been fully fastened to its mounting studs.

Risk

Over time, the pedal may not maintain a consistent pedal position, which could make it more difficult to operate the accelerator.

Remedy

Dealers will inspect and, if necessary, install the mounting nuts of the accelerator pedal. The recall began on january 16, 2007. Owners may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 06V495000 · Recall details

What is wrong

On certain passenger vehicles, a hose clamp that secures the power steering fluid cooling hose to the power steering fluid cooler may not provide sufficient clamping force for this connection.

Risk

A loss of power steering fluid can damage the power steering pump and may result in diminished power assist for steering which could lead to a crash.

Remedy

Dealers will replace the power steering hose clamp free of charge. The recall began on may 17, 2005. Owners may contact mercedes-benz at 1‑800‑367‑6372.

Recall number 05V224000 · Recall details

What is wrong

On certain passenger vehicles, the hose clamp used to secure the power steering fluid cooling hose to the power steering fluid cooler may not provide sufficient clamping force for this connection.

Risk

The loss of power steering fluid may result in diminished power steering over time and ultimately can damage the power steering pump.

Remedy

Dealers will install a new hose clamp on the power steering hose to the power steering cooler. During clamp replacement, the power steering cooling hose will be inspected and replaced as necessary. Owner notification began june 16, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mercedes-benz at 1‑800‑367‑6372.

Recall number 03V121000 · Recall details

What is wrong

Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 208, s7.3, "occupant crash protection." the seat belt chimes may not function as designed and is not consistent with the requirements of the standard.

Risk

If the driver buckles his seat belt prior to starting the vehicle, the chime will not sound at all when the vehicle is started.

Remedy

Dealers will inspect the vehicles to ensure that the seat belt chime operates as required by the standard. Owner notification began september 25, 2002. Owners who do not receive the free instructions within a reasonable time should contact mercedes-benz at 1‑201‑573‑0117.

Recall number 02V203000 · Recall details

What is wrong

Certain passenger vehicles equipped with dunlop sp5000 tires. Some of these tires have a separation around the entire circumference in the area of the side wall and tread.

Risk

This could result in premature tire wear.

Remedy

Dealers will inspect and if necessary replace the dunlop tires which exhibit this defect when visually inspected. Only dunlop tires in week 4901 with tire codes 4909 or 4917 are involved and will be replaced. Owner notification by telephone began febuary 27, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mercedes-benz at 1‑800‑367‑6372.

Recall number 02V058000 · Recall details

What is wrong

Vehicle description: passenger vehicles. Certain all activity module ii (aam ii) could have a sub-component that could cause the module to intermittently not function properly. The aam ii controls a number of systems including the high beam lights, instrument cluster, door locks, and wiper systems.

Risk

This condition could cause an intermittent non-functioning of these systems.

Remedy

Dealers will replace the aam ii. Owner notification began february 16, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mercedes-benz at 1‑800‑367‑6372.

Recall number 01V061000 · Recall details

What is wrong

Vehicle description: passenger vehicles. The seat belt anchor in the rear folding middle seating position may have been manufactured with out-of-tolerance hardware.

Risk

If this is the case, the seat belt anchor may not comply with federal motor vehicle safety standards.

Remedy

Dealers will install an additional rear middle seat belt anchor plate.

Recall number 00V352000 · Recall details

What is wrong

Vehicle description: certain passenger vehicles fail to conform to the requirements of fmvss no. 208, "occupant crash protection." an audible seat belt buzzer warning sounds for approximately two seconds when the vehicle ignition is turned to the on or start position and the driver seat belt is fastened. This buzzer activation exceeds the limitations set forth in the standard.

Risk

Drivers may become confused regarding the purpose of the chime.

Remedy

Dealers will repair the seat belt warning chime system.

Recall number 00V203000 · Recall details

What is wrong

Vehicle description: sport utility vehicles. The latching mechanism on the seat belt assembly was not assembled correctly. If the plastic cover is loose during the engagement of the buckle tongue to the latch mechanism, the buckle could unlatch.

Risk

In the event of a crash, the seat occupant may not be properly restrained, increasing the risk of personal injury.

Remedy

Dealers will inspect the seat belt buckles. If either the driver or front passenger seat belt buckle is found to be defective, it will be replaced.

Recall number 99V328000 · Recall details

What is wrong

Vehicle description: sport utility vehicles. The certification label on these vehicles fail to comply with the labeling requirements of part 567, "certification."

Risk

The rear gross axle weight rating was listed as 3257 lb. Instead of 3527 lb. And the tire size was listed as 276 rather than 275. A consumer could incorrectly inflate the tires or improperly load the vehicle.

Remedy

Dealers will send a representative to the owner's home and remove the non-compliance label and replace this with a label which is in compliance.

Recall number 98V090000 · Recall details