Mercedes Benz ML320 power steering loss problems

Filed Aug 2, 2023 · Steering · 220,000 miles · NM

The contact owns a 1999 Mercedes-Benz ML320. The contact stated while driving approximately 30 MPH and other various speeds, the vehicle lost power steering functionality. The contact stated that she refilled the power steering reservoir several times and noted that there was a stain underneath her vehicle after parking overnight. The contact stated no warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed and had not been repaired. The manufacturer had been informed of the failure. The contact related the failure to a closed the federal safety agency Action Number: PE3006 (Steering). The failure mileage was approximately 220,000.

Filed Jul 14, 2020 · Acceleration, Steering · 219,444 miles · VA

Steering is hard to turn. Over heats and will not keep coolinat down

Filed Jul 27, 2019 · Steering · 210,000 miles · MD

Steering fluid leeks.there is a hole in the tank.the steering is very hard.

Filed Jan 5, 2018 · Steering · 79,500 miles · PA

Loss of power steering fluid, it appears to be from the hose connection to the radiator during driving and while stationery. This issue was previously recalled, I believe twice. Dealer requested $125 diagnostic charge. Mb USA informed in a phone conversation, that this problem was already fixed october 2008 under recall, and the warranty expired and I should fix on my own cost.

Filed Nov 22, 2014 · Steering · 143,340 miles · ID

I bought this car yesterday from an individual off craigslist and the power steering has gone out 5 times. So far only at very low speeds, but I have looked online and seen numbers complaints with power steering failure at faster speeds too. Very unsettling. There were a couple of recalls regarding the clamps and hoses, but upon research I found that y car has no open campaigns. I guess that means they fixed the problem. There is an obvious problem still and I need it fixed or I need a new car. This is not safe.

Filed Jul 29, 2014 · Steering · 99,000 miles · IL

Tl* the contact owns a 1999 mercedes benz ml320. The contact stated that while driving approximately 35 MPH, the power steering failed without warning. The vehicle was restarted but the failure persisted. The vehicle was taken to an independent mechanic where it was diagnosed that the power steering pump needed to be replaced. The vehicle was repaired twice, but the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 99,000. Djr

Filed Feb 28, 2013 · Steering · NJ

Mercedes benz ml 320. Consumer requests reimbursement for repairs. *smd the consumer stated the steering was extremely stiff and the vehicle would not turn. After doing some research, the consumer discovered the 2000 models years had steering problems, due to a faulty pump assembly. The vehicle was towed to the dealer. The consumer then received a call from the dealer, stating the pump needed to be replaced. The consumer asked about the pump and hose recall. The dealer stated the parts would be replaced free of charge. However, the pump was not apart of the recall and it would cost $ 1190 to replace it. The consumer requested that just the recall parts be replaced. But, the dealer stated it probably would not fix the problem.

Filed Mar 28, 2011 · Engine, Steering · 36,000 miles · OH

I purchased a used 2007 mercedes ml320 cdi on march 12. After a week of driving - I inspected the engine compartment (I usually do). I noticed engine oil dripping (small but noticeable amount) on the serpentine belt. I did not think it was urgent - so I took pictures so I can send it to my seller to claim warranty. On march 23, I was driving with my family on I-65. Suddenly, steering became very hard. It was a curving highway so I was forced to go into other lanes. Lucky, traffic was not heavy so I did not swerve into any other vehicle. I was able to wrestle with the steering wheel on time to move away safely. Also, at the same time we lost steering, the battery light went on. After stopping, we popped the hood and immediately noticed the same belt mentioned earlier had disintegrated into several pieces. We called for a tow vehicle. Mercedes benz fixed the problem for $300 and assured me that there is no oil leak. 200 miles later, I got home - and saw the same leak, same spot. Oil was dripping from the turbo to intercooler hose joint (which was just above the serpentine belt). I did some research on the internet and the only similar issue I found LED to dtb s-b-09.20/29. I asked mercedes, but they say its not covered under warranty. So I am currently researching to fix this problem permanently.

Filed Nov 18, 2010 · Steering · 120,000 miles · CA · crash

Tl*the contact owns a 2000 mercedes benz ml320. While driving 40 MPH the power steering failed and the steering wheel continued to move to the right or left. He lost control of the vehicle and crashed into some small trees which damaged the left side of the vehicle. There were no injuries. The vehicle will be towed to the body shop for the repairs. The dealer was called and informed him to contact his insurance carrier. The manufacturer was not notified. The failure mileage was 120,000.

Filed Mar 6, 2009 · Steering · 120,494 miles · CA

2001 mercedes-benz ml320 has a recall for power steering pump. Consumer states that the dealership repaired the hose and clamp but refused to replace the power steering pump. *nj the consumer stated the power steering pump had failed previously and ran completely dry and was making a lot of noise and there was a loss of power steering control. The consumer stated the failure of the hose and clamp caused damage to the power steering pump. The consumer was informed the recall only covered repairs to the hose and clamp and additional damage was not covered.