2021 Mercedes-Benz S 580: tire blowout or tread separation

Filed Jun 25, 2025 · Wheels · MA

Excessive Tire failure on "AMG" 21 inch wheel and tires. Pirelli tires have replaced 4 tires in four months. cracks in side wall bubbling.

Filed Feb 20, 2025 · Wheels · AL

I purchased this vehicle used at a dealer in Virginia. I drove it home to Chelsea Alabama, outside Birmingham. After a couple of days, my front right tire went flat. I took it to the dealer and they said the flat tire was caused by a cracked rim and required both to be replaced. Almost $3,000 for tire and rim. I continued to drive the car, maybe 4,000-5,000 miles and I had another tire go flat. This was the drivers side rear tire. This was a Pirelli 285/35 R20 run flat tire. Again when I took it to the dealer, this rim was cracked and also needed to be replaced along with the tire. $2,790. The car has 55,000 miles and is meticulously maintained. And I do not drive on rough roads. The dealer consistently states it was due to “hitting a pot hole” which a) is not the case in both these incidents, and b) a rim should not break from running into regular small imperfections in the road. I’ve been in the auto manufacturing business for 38 years and have never, ever had a rim fail, not once but twice in 4 months on the same vehicle. After investigating, this is happening all over. My feeling is the rim has not been sufficiently designed to support the weight of this vehicle. And now, every time I take the car out, I fear for my life and my families life. Frankly, the car is not safe because the rims can and will crack and split under regular driving conditions! This can cause a blowout and possible injury or death. This cost and the cost of my safety should be covered by Mercedes. They should replace these rims with stronger, more properly designed rims to ensure my families future safety!

Filed Feb 18, 2025 · Wheels · NY

I’ve had to replace six tires due to blowouts from hitting small potholes, something I’ve never experienced in the past 40 years of driving other vehicles! This seems to be a manufacturing defect in the vehicle, as the tires can’t support the weight of the car, and any pressure on them causes them to blow out. I’m now hesitant to drive long distances, fearing that one or more tires could blow out at any time. Without a spare tire in the trunk, I’m left stranded. Below are answers to your question: 1. The tires failed, yes they are available for inspection. Also have photos of the damaged tires. 2. The safety of myself and my passengers is at risk, as a tire blowout while driving at 55 mph could potentially cause the vehicle to lose control and result in a serious accident.. 3. The problem has been confirmed by an independent service center. 4. The vehicles tires have been inspected by an insurance representative and independent service center 5. NO

Filed Jun 12, 2023 · Wheels · CA

I have had one tire blow out after traveling over a moderate pot hole, and 3 other tires that have been damaged with "bubbles" due to excessive stress from normal driving. In addition to the damaged tires, I have had 3 bent wheels all due to normal driving because the 21 inch wheels/tires on this vehicle cannot tolerate the loads during normal driving. This is a well-known defect by Mercedes and I believe it is a design defect and that it is dangerous.

Filed Jul 28, 2022 · Tires · 3,000 miles · CA

The contact owns a 2021 Mercedes-Benz S580 equipped with Pirelli tires, Tire Line: P Zero MO-S, Tire Size: P255/35/R21 (Front tires) and P285/30/R21 (Rear Tires), DOT Number: (Unavailable). The contact stated while driving 30 MPH, the drove over a pothole and the driver’s side front tire experienced a blowout. The vehicle was towed to the dealer, and the contact was informed that there was a bubble on the side shoulder of the tire, and the tire needed to be replaced. The tire was replaced. The contact stated that a similar failure reoccurred with the front passenger’s side tire and the rear driver’s side tire. The vehicle was taken to the dealer both times and the contact was informed that the sidewalls on the tires were thin causing the blowouts. The failure mileage was 3,000.

Filed Jul 26, 2022 · Wheels · CA

I have had 3 tire failures(blowouts)when I have hit potholes with my 21” wheels and Pirelli P Zero tires. I read on a MBZ Forum for my specific make of car - 2021/2022 MBZ S580 - that many others have experienced the same failures with these Pirelli tires. Those that have Michelin have had none. With such a small area between the road and the rim afforded by super low profile 21” setups, a tire like Pirelli with a weak sidewall will fail when the car strikes a pothole or obstruction. Another owner on the Forum said when he contacted Mercedes, they said it was not their problem, but Pirelli’s. Meanwhile, there are thousands of owners with this combination, many of which have already experienced failures. Something needs to be done before there are injuries, or worse.