1997 Mercury Cougar brakes problems

Filed Jan 7, 2003 · Brakes, Engine · 60,000 miles · TX

We have numerous complaints with this vehicle. One of which is the brakes. Another is the cooling system. There is a recall on the manifold but our local ford dealer wlll not replace even though we have asked them to do so. In addition the engine had a problem which no one could figure out.

Filed Jun 20, 2002 · Brakes · SC

Front hydraulic disc rotors are 1/2 inch bigger that rear rotors which causes rotors to warp. Brakes overheat, steering starts shaking, and front end will nose dive if vehicle brakes too hard, causing wheels to lock up. Dealer notified. Please provide more information.

Filed Nov 6, 2001 · Acceleration, Brakes · CA

While traveling 30mph in traffic started applying brakes to slow down, had no brakes, and vehicle kept going. Brake pedal was almost to the floor. Also, cruise control had failed. Stopped vehicle and had it towed to mechanic. Was informed that brake booster plunger, had worn out, causing non braking ability.

Filed Sep 19, 2001 · Brakes, Transmission · TX

Transmission vibrates and was erratic, torque converter was cleaned, transmission shifter was inoperative.

Filed Dec 18, 1999 · Brakes · TN · crash

Brake line corroded by battery acid and broke, resulting in a sudden loss of brake function and subsequent collision with vehicle that stopped ahead. Brake combination valve located in front of battery. All the brake lines run past the battery from the master cylinder and to the wheels and are fully protected by a plastic coating except the line to the left front wheel. On this line the plastic coating starts at the valve and stops just to the right of the battery. The line broke at the point where the coating stops and is heavily corroded by battery acid for several inches. I am a mechanical engineer investigating this accident for allstate insurance company and would be happy to provide you with a copy of my report.

Filed Oct 26, 1999 · Brakes · TX

I bought my cougar in 1997. At 6,113 miles the front rotors were warped and had to be turned . At 8,788 miles the roters had to be replaced. At 15,718 miles the rotors were warped again and had to be turned again. At 16,992 miles the rotors were warped again and turned once again. At 20,990 miles more problems with the brakes,premium aftermarket rotors and pads were ordered and were installed at 21,461 miles.then at 26,402 the brake problem continues the rotors were turned again. I have tried to be patient with the service department at centroplex ford but the last time they turned the rotors they said that they don't know what to do to fix the problem and I am very concerned. My warranty will run out soon and I would like my brakes fixed for good .

Filed Oct 6, 1999 · Brakes · AL

While driving brake disc rotors warped, causing extended stopping distance which may result in a crash. Dealer replaced brake rotors numerous times, but the problem has reoccurred. Please provide further information.

Filed Aug 15, 1999 · Brakes, Suspension · GA

Front end problems causing excessive vibration (several repair attempts), front brakes also experience locking up on occasions, both these failures are causing directional control problems. Mjs

Filed Feb 1, 1999 · Brakes · CA

Emergency brake pedal padding failed. Nlm

Filed Nov 5, 1998 · Brakes · GA

Because the brake rotors were warped, when applying the brakes, they caused vibration and shaking in the steering wheel. Dealer cut the rotors.