2000 Mercury Cougar technical service bulletins
109 technical service bulletins and manufacturer communications cover the 2000 Mercury Cougar.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- General (PCM) power train control module programming procedures
- General power train control module (PCM) programming procedures
- Malfunction indicator lamp (MIL) illuminated - system lean diagnostic trouble codes (dtc's) - service tips
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns
- Malfunction indicator lamp illuminated with diagnostic trouble code P0420 and/or P0430/ 2.5L engine only
- Engine hesitation, loss of power, surging, and other similar symptoms as a result of contamination of the...
- Steering column shipped without crush pad - reuse original crush pad if not damaged
- Malfunction indicator lamp illuminated with diagnostic trouble codes (DTCS) P0442, P0455, P0456, P0457 or...
- Remote keyless entry (RKE) - service tips
- Malfunction indicator lamp on and diagnostic trouble codes P0171/P0174 or P1072/P0175 stored in memory or...
- The malfunction indicator lamp (MIL) may be illuminated and diagnostic trouble codes (DTCS) P1380, P1381,...
- New transmission cooler flusher - service tips
- Malfunction indicator lamp (MIL) illumination with diagnostic trouble codes P0442, P0455, P0456, P0457,...
- Climate control a/c service tech tips
- Lamp-brake-invadvertent disabling of brake shift interlock
- Some vehicles equipped with a 2.5L engine may exhibit multiple misfire diagnostic trouble codes with no...
- Some vehicles may exhibit diagnostic trouble code B1213, B1342, B1601, B2431
- Battery lamp on, however the charging system is functioning properly
- Information regarding discharged battery charging service tips and guidelines
- Some vehicles may exhibit complaints of false alarm activation ofthe perimeter anti-theft alarm or being...
- Some vehicles equipped with the CD4E transaxle may exhibit harsh and delayed 1-2/2-3 upshifts after...
- Concern with headlamps and/or instrument panel lamps dimming slightly at idle
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- Some vehicles may exhibit a noise that appears to come from the front wheel bearings
- Subject on brake fluid leak
- Engine oil system priming procedures, service tips for reports of premature engine failure
- Some vehicles may exhibit a condition where the defroster grille edges lift out of the dash pad
- Some vehicles may exhibit a check engine light and/or EGR diagnostic trouble codes 332, P0401, P1407...
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing...
- Brake shift interlock
- Some vehicles may exhibit the defroster vent edges lifting out of the dash pad
- Some vehicles built prior to 22-SEP-2000, may exhibit the brake lamps staying on
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Information regarding cougar headlamp parting line, which results from the manufacturing process and CAN...
- Some vehicles may exhibit a steering drift/pull to the right
- Some vehicles may exhibit a concern of backlite/hatchback moldings becoming loose
- Some vehicles built through 02-01-2001 may exhibit the fuel level indicator intermittently dropping to...
- Some vehicles equipped with 2.5L engines may exhibit multiple misfire diagnostic trouble codes with no...
- Vehicles equipped with passive anti-theft system (PATS) may not start or crank
- Information on vehicles exhibiting a fuel level indication intermittently dropping to empty with fuel in...
- Some vehicles with CD4E transmissions built 7/1/2000 thru 12/20/200 may exhibit intermittent loss of both...
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5W-20 motor oil
- Some vehicles not equipped with side airbags may exhibit a condition where the airbag warning lamp is...
- Experiencing a spark knock or pre-ignition condition on vehicles with an automatic or manual transmission...
- Some vehicles equipped with rear disc brakes may exhibit a moaning / groaning noise on initial brake...
- On some vehicles, an objectionable exhaust, sulfur, or rotten egg odor following aggressive driving, such...
- Some vehicles equipped with a V6 engine may exhibit a flickering condition of the headlamp, instrument...
- Information on improved fuel tank filler pipe grommet
- Some vehicles may exhibit a vibration at highway speeds
- Some vehicles may exhibit a squeak or squeal in the front brake system
- Some vehicles equipped with anti-lock brakes (ABS) may exhibit an ABS light on condition diagnosed as...
- Vehicles may experience no start condition when the wiper switch is in the intermittent or low-speed...
- Safety recall pertaining to brake pressure control reducing valve replacement
- Some vehicles may exhibit no forward gear ranges due to the misalignment of the forward / coast clutch...
- Information pertaining to duratec oil pan investigation
- Vehicles equipped with 4-WHEEL disc brakes may exhibit a rear disc brake moan / groan noise
- Some vehicles may exhibit a rough idle or hesitation after a hot soak of approximately 30 minutes
- Some vehicles may exhibit a rough idle or hesitation after a hot soak at approximately 30 minutes
- Vehicle may experience water leaks in the front passenger compartment during heavy rains and/or going...
- Some vehicles may exhibit the battery warning lamp illuminating due to fuse 2 or 7 blowing
- Some vehicles equipped with compact disc changer may exhibit a 6 disc cd changer that is not ejecting the...
- Some vehicles equipped with a 2.5 engine and built after may 25, 1999 may exhibit an intermittent hard /...
- Vehicles with 2.5L engine and built after may 25, 1999 may exhibit an intermittent hard / no start, rough...
- Vehicle may experience the malfunction inciator lamp (MIL) illumination with diagnostic trouble codes (DTCS)
- Some vehicles equipped with a 2.5L engine and built after may 5, 1999 may exhibit an intermittent hard /...
- Some vehicles may experience a hoot noise from the idle idle air bypass solenoid on deceleration, usually...
- Some vehicles equiped with 4-WHEEL disc brakes may exhibit a groan / grind noise from the rear brakes on...
- Experiencing the battery warning lamp illuminating due to fuse 2 blowing intermittently
- Experiencing a hoot noise from the idle idle air bypass solenoid on deceleration, usually in cold ambient...
- Vehicle may experience the low coolant lamp to illuminate with coolant at normal operating level, vehicles...
- Information regarding the new transmission cooler flusher- service tip
- Information regarding several internal changes that have been implemented on the MRX-75 transaxle to...
- The new synthetic transmision fluid must be used whenever adding fluid or performing any type of service...
- Some vehicles equipped with a 2.5L engine and built after may 5, 1999 may exhibit an intermittent hard/no...
- Some vehicles equipped with 2.5L engine may exhibit multiple misfire diagnostic trouble codes (DTCS) with...
- Vehicles built before jun 21, 2000, an improved fuel filler tank grommet is now available for service
- Exhibiting a windnoise and / or water leak around the b-pillar mouldings
- This bulletin addresses an issue with the automatic transmission fluid seeping from the vent, resulting in...
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble...
- Information regarding speed control switch voltage readings - service tip
- Some vehicles equipped with 2.0L engine may exhibit a timing belt shredding or timing belt striking the...
- Some vehicles may exhibit a windnoise or whistle from the windshield a-pillar moldings
- Some customers may report a concern of radio operating with ignition switch off, with or without a key in...
- Subject regarding the speed control switch voltage readings - service tip
- Some vehicles with the optional overhead warning indicator console may exhibit the door ajar warning and...
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Information on investigating hard start / no start conditions accompanied by overfueling in ambients below...
- Some customer may report a concern with the radio volume going up and down on its own while driving or...
- Vehicles may exhibit a radio that is intermittently inoperative
- A concern with paint bubbling / peeling on the front and / or rear bumper
- Exhibiting an intermittent and / or inoperative speaker function
- Information on using peanut style a/c fittings
- Some customers may report a concern of radio volume going up and down on its own while driving or...
- Some vehicles may exhibit a radio that is intermittently inoperative
- Some vehicles may exhibit paint bubbling / peeling on the front and / or rear bumper
- Some vehicles may exhibit intermittent and / or inoperative speaker function
- Information regarding a/c peanut o-ring color
- Experiencing a grinding / groaning / squeaking / squealing noise when opening or closing the sunroof
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Concerns with vehicles exhibiting intermittent and / or inoperative speaker function when the radio is...
- Information regarding radio removal/installation
VIN decoder
See the problems and recalls for an exact car
Buying a used 2000 Mercury Cougar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history