1997 Mercury Grand Marquis technical service bulletins
133 technical service bulletins and manufacturer communications cover the 1997 Mercury Grand Marquis.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles...
- Some 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
- Extended coverage program 05N04 - extended coverage for composite intake manifold
- Abrasion of the rear brake tube near the floor pan stiffening rib and the #3 transmission cross member
- General (PCM) power train control module programming procedures
- General power train control module (PCM) programming procedures
- Malfunction indicator lamp (MIL) on with diagnostic trouble codes (DTCS) P0420 and/or P0430
- Malfunction indicator lamp illuminated with diagnostic trouble codes (DTCS) P0442, P0455, P0456, P0457 or...
- Malfunction indicator lamp (MIL) on with diagnostic trouble codes (DTCS) P0420 (catalyst system efficiency...
- Remote keyless entry (RKE) - service tips
- New transmission cooler flusher - service tips
- Malfunction indicator lamp (MIL) illumination with diagnostic trouble codes P0442, P0455, P0456, P0457,...
- New service part - number 5 needle bearing and race kit - 4R70W transmission - service tip
- Climate control a/c service tech tips
- Lamp-brake-invadvertent disabling of brake shift interlock
- Transfer service tips for the front wiper motor mount bracket and depressed park output arm
- Some vehicles may exhibit an intake manifold crossover (first runner) coolant seepage condition
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- Engine oil system priming procedures, service tips for reports of premature engine failure
- Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed...
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing...
- Brake shift interlock
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Some vehicles may exhibit a fead belt jump-off toss
- Some vehicles built 04/15/2000 or earlier equipped with a keyless entry system may exhibit an inoperative...
- Information on replacing fuel tank strap bolts
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5W-20 motor oil
- Service action 00E11, supplement #1 - update information regarding on-board diagnostic system upgrade
- Service action bulletin regarding on-board diagnostic system upgrade
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the...
- Subject regarding climate control - eatc - blower motor control service tips
- Information on programming remotes after driver door module replacement
- Some vehicles may exhibit a bang / popping noise heard from the exhaust system during cool-down
- Some vehicles may exhibit an inoperative keyless entry pad
- Brief information regarding vehicles that exhibit yellowing of the headlamps
- Subject regarding keyfob programming information - service replacement drivers door module
- Some vehicles may exhibit yellowing of the headlamps
- Some vehicles may exhibit a slight steering drift / wander condition, usually noted during highway driving
- Information regarding the new transmission cooler flusher- service tip
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble...
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Service information for musty and mildew type odors coming from the air conditioning / heating system
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4R70W transmissions may experience delayed or no...
- Information on the new flush and fill tool available through rotunda
- Some vehicles may exhibit a bang popping noise heard from the exhaust system during cool-down
- Conditions with the brake lamps inadvertently disabling the brake shift interlock
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (NVH)...
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Ford motor company has released a private labeled material to be used for iron particle / acid rain...
- Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford...
- Subject regarding door trim panel replacement - service tip
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Information regarding reprogramming powertrain control modules (PCMS)
- Engine experiencing roughness at idle due to exhaust system resonance
- A vibration / noise felt in steering wheel on right turns.
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent,...
- Concerns regarding the front seat feeling loose on some vehicle
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern
- For all vehicles with lighting control module concerns that require a module replacement, the technican...
- For all vehicles with drivers door module concerns that require a module replacement, the technician must...
- For all vehicles with remote keyless entry concerns that require a module and / or transmitter (keyfob)...
- All vehicles with antilock brake module concerns that require a module replacement, the technician must...
- Some vehicles equipped with 4R70W transmissions may exhibit delayed or no 2-3 upshift, primarily when the...
- Mass air flow (maf)- sensor contamination- service tip
- Some vehicles with a very low odometer reading may experience a lack temperature control
- Information regarding replacement and / or repairs on any lock component
- Experiencing a " buzzing " or " rattling " noise from the exhaust system
- Some vehicles may exhibit malfunction indicator light on with evaporative diagnostic trouble codes P0442,...
- Experiencing a torque converter clutch shudder or vibration
- Information on a new transmission fluid usage chart
- Information on tire company telephone numbers for customer assistance
- A new silicone gasket and sealant
- Some vehicles may exhibit brake squeal from the rear when braking
- Some police and export cars equipped with phonelic piston calipers may exhibit brake squeal from the rear...
- Some vehicles may exhibit no temperature control and/or a clicking noise heard coming from behind the...
- Information on a buzzing or rattle noise from the exhaust system
- The anti-lock brake system ( ABS ) may activate under false ABS conditions
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- Service tip information regarding elimination of sanding rotors and drums
- Availability of hub-mount brake rotor machining equipment
- Subject regarding revised remote keyless entry (RKE) system
- Vehicles may experience torque converter clutch shudder or vibration
- Brief information regarding engines being added to the fqr (ford quality renewal) assembly program
- Repairs to vinyl covered surfaces
- Information concerning vibration-shudder under light to moderate acceleration above 56 km/h (35MPH) in 3RD...
- Subject regarding the availability of hub-mount brake rotor machining equipment
- Vehicles may exhibit harsh ride quality or excessive road feel through the steering wheel while going over...
- MIL light on with evaporative DTC P0442, P0455
- Experiencing difficulty diagnosing vehicles with evaporative fuel system diagnostic trouble codes
- Some vehicles may experience a lean right condition
- Experiencing difficulties with the malfunction indicator lamp (MIL)
- A vibration/"buzzing" noise may be heard or felt in the steering wheel on right turns
- Vehicle may exhibit a lack of power
- Diagnostic instructions for a/c mode failure
- Additional instructions when diagnosing a/c mode failure
- Vehicles built between 1/4/97 and 4/14/97 may exhibit a concern of lack of power
- Vibration- shudder or vibration under light to moderate acceleration above 56 km/h (35 mph) while in 3RD...
- Fuel economy- customer expectations versus vehicle usage
- Interior- leather seat cleaning procedure- service tip
- Malfunction indicator lamp (MIL)- MIL illumination- diagnostic trouble code (DTC) P0446 stored in memory
- Fluid- transmission fluid usage charts
- Air conditioning- R-134A tracer dye installed in a/c system and three o-ring spring lock couplers- service tip
- Inadvertent ABS activation on smooth dry pavement
- The power point electrical outlet was deleted
- Wind noise from the front door area on affected vehicles
- Wind noise from the front door area at varying speeds and conditions on affected vehicles
- A white stress mark in the door scuff plate
- White stress mark in the door scuff plate, replace with new level part
- The power point electrical outlet was deleted- disregard the note in the 1997 owners guide advising not to...
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning...
- Powertrain control module -reprogram powertrain control module (PCM) - service procedures - service tip
- Wiring - electrical diode identification and service replacements
- Torque converter - leak test procedure - service tip
- Front wheel rattle may be caused by the dust shield rattling
- Wire wheel cover center ornament separates from the backing plate
- Concerns of check engine light (MIL) w/ codes P0300 thru P0308 & eng runes rough/misses
- Light to moderate axle noise (axle whine) at 50 to 65 mph (80 to 105 kph) during accels, decels or cruise
- Windshield and interior glass - fog/film
- Brakes - elimination of sanding rotors and drums - service tip
- Mass air flow sensor - replacement as an assembly - service tip
- High pitch whining noise from the alternator may be caused by a loose eng ground strap
- Concern for intermittent no start/or intermittent stall & w/ no dtc's
- Vehicles equipped w/ an aode or 4R70W trans has a concern of shudder from the transmission torque...
- Firestone P235 tires may exhibit a high frequency vibration at 65-75 mph
- Some vehicles equipped w/ an AX4S transaxle may have been shipped w/ a low transaxle fluid level
- Complaint of a buzz/vibration felt in the steering wheel while turning (usually more noticeable turning right)
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Mercury Grand Marquis?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history