2005 Mercury Montego technical service bulletins
48 technical service bulletins and manufacturer communications cover the 2005 Mercury Montego.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic...
- Ford: momentary engine idle RPM surge may be intermittent and may occur, due to deposits buildup in...
- Traction control lamp on--no dtc's present, or DTC P1889 in differential electronic module (DEM)
- Ford mercury service campaign: certain 2005 through 2007 FWD and AWD ford five hundred, freestyle and...
- Transmission harsh shifting - no dtc's - mileage over 20,000 miles
- Rear brake drag, noise, dust, and/or premature pad wear
- MIL on with DTC P0191 - fuel rail pressure sensor circuit performance
- MIL with DTC P0106 and/or P0109
- Transmission shifter binding / high effort bezel replacement
- Fuel gauge erratic/inaccurate and/or MIL on with DTC P0463, B1202, B2627, B2879, and/or P2068
- Intermittent instrument cluster operation - including gauges sweep/reset - multiple warning lights...
- Battery light illuminated
- Tenths digit not displayed on odometer after 10,000 miles/kilometers
- Intermittent bounce-back of the driver's window during one touch up operation
- Noise in right front of passenger compartment - air inlet door actuator inoperative (recirculation)
- Noise from rear suspension - cold only
- Grunt or squeak from front suspension during full lock turns - service tip
- Oil leak from power transfer unit
- Intermittent instrument cluster gauge sweep/reset - multiple warning lights on - reverse lights on -...
- Continuously variable transaxle (CVT) noise diagnosis
- Noise from front while turning steering wheel
- Wds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
- Engine RPM fluctuation at highway cruising speeds - vehicles built prior to 8/2/2005
- Trunk lid hard to close
- Special field action 05L25
- Vehicles with a CVT transaxle, may exhibit a fluid leak from the transaxle oil pan area
- Squeak/clunk noise from rear lower control arm - vehicles built 7/12/2004 through 9/21/2004
- Intermittent headlamp flicker with no key in the ignition - vehicles built before 2/21/2005
- Thumping noise or roughness from rear brakes
- Squeak from rear of vehicle when driving over bumps
- Incorrect compass information in owners guide and work shop manual
- Maf diagnostic service tip - vehicles equipped with EGR system module (ESM)
- Memory seat, adjustable pedals and mirrors operation concerns
- Memory seat, mirrors and pedals operation
- Rear suspension noise when cold
- Vehicle may exhibit an oil life xx% message inthe odometer message center display prior to the vehicle...
- Harsh or erratic upshifts/downshifts - wrench lamp illuminated with diagnostic trouble code (DTC) P2544 -...
- Harsh/erratic/slow downshifts or tip-in hesitation -- 6 speed automatic transaxle -- vehicles built before...
- Weld bonding procedure
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- General (PCM) power train control module programming procedures
- Audio unit backlight inoperative and or DTC B2477
- Oil leak from power transfer unit
- General power train control module (PCM) programming procedures
- Wrench light on, no engagement in drive or reverse and diagnostic trouble code P0942
- Wrench light on, diagnostic trouble code P0562 and transaxle in limp home mode after battery jump start
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Mercury Montego?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history