2004 Mercury Mountaineer technical service bulletins

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

• Feb 7, 2019 Service bulletinCorrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust
• Sep 21, 2016 Service bulletinThe Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic...
• Jul 10, 2012 Service bulletinFord/lincoln/mercury: if battery was disconnected or dead, vehicles/trucks may experience hard starts and...
• May 1, 2009 Service bulletinFord: some vehicles may exhibit oil separation from the internal lube found in the unitized cartridge seal
• Oct 1, 2007 Service bulletinSome 1997-2008 vehicles equipped with a 4.6L 2V, 5.4L 2V, or 6.8L 2V engine--spark plug thread repair...
• Feb 27, 2007 Service bulletinMIL on with DTC P0463 or erratic fuel gauge operation
• Feb 26, 2007 Service bulletinMIL on with P0463 or erratic fuel gauge operation
• Jan 1, 2006 Service bulletinLimited slip axle chatter, shudder, binding sensation, or vibration during low speed turning maneuvers
• Jan 1, 2006 Service bulletinMalfunction indicator lamp on with PCM diagnostic trouble code P0463 and/or ic diagnostic trouble code...
• Jan 1, 2006 Service bulletinLow tire indicator on - TPMS system sensor wake up
• Nov 14, 2005 Service bulletinWds cop kit diagnostic tip - coil on plug (COP) ignition systems - engine misfire or rough running
• Oct 31, 2005 Service bulletinFuel gauge slow to update after refueling
• Oct 7, 2005 Service bulletinNoise from rear wheel hub bearings
• Jul 1, 2005 Service bulletinMalfunction indicator lamp coming on with diagnostic trouble codes (DTCS) P0171, P0172, P0174 and/or P0175...
• Jun 7, 2005 Service bulletinAxle seal leaks
• Jun 7, 2005 Service bulletinDriveline 1ST order vibration/boom/drone
• Jun 7, 2005 Service bulletinMalfunction indicator lamp (MIL) and electronic throttle control (ETC) lamps on with both diagnostic...
• Jun 7, 2005 Service bulletinSafety belt retraction speed
• Jun 7, 2005 Service bulletinNo start/hard start on cold soak - 4.0L engine
• May 27, 2005 Service bulletinImproperly formulated transmission fluid that, over time, may cause delayed/harsh reverse engagements
• Apr 1, 2005 Service bulletinNo start/hard start on cold soak
• Apr 1, 2005 Service bulletinRear axle noise repair
• Apr 1, 2005 Service bulletinDelayed or harsh reverse engagements - 5R55S transmission - vehicles built prior to 09/23/2004
• Apr 1, 2005 Service bulletinWrench lamp on and no diagnostic trouble code (DTC) stored
• Mar 7, 2005 Service bulletinFront seat(s) slight movement when accelerating and/or decelerating
• Feb 21, 2005 Service bulletinMaf diagnostic service tip - vehicles equipped with EGR system module (ESM)
• Feb 21, 2005 Service bulletinIncreased turning effort during low speed sharp turns false 4X4 engagement
• Feb 21, 2005 Service bulletinMIL on and/ or runs rough/misfire dtcs P0300-P0308 P0316 and or P0171/P0174 4.6L engine
• Jan 24, 2005 Service bulletinRear power window(s) inoperative
• Jan 1, 2005 Service bulletinLiftgate glass applique damaged/cracked
• Jan 1, 2005 Service bulletinOpen fuse F2.20 (5 amp) and/or F2.1 (30 amp) which may result in loss of function of several systems...
• Jan 1, 2005 Service bulletinRear axle noise repair
• Jan 1, 2005 Service bulletinBackglass difficult to close and an intermittent door ajar lamp
• Jan 1, 2005 Service bulletinMIL on with DTC P0191 with or without various drivability symptoms and/or additional dtcs
• Jan 1, 2005 Service bulletinVibration diagnosis - tire/wheel runout
• Dec 31, 2004 Service bulletinWarning indicators-parking aid-reverse sensing system (RSS) and forward sensing system (fss)-false...
• Dec 31, 2004 Service bulletinThrottle pedal response on tip in vehicles built before 10/4/2004 equipped with a 4.0L engine
• Dec 31, 2004 Service bulletinIncreased effort during low speed sharp turns on 4X4 vehicles
• Dec 27, 2004 Service bulletinAluminum corrosion - service tip
• Dec 27, 2004 Service bulletinRattling noise - right front fender while driving
• Dec 13, 2004 Service bulletinRear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
• Dec 13, 2004 Service bulletinGeneral (PCM) power train control module programming procedures
• Nov 15, 2004 Service bulletinMalfunction indicator lamp (MIL) illuminated with diagnostic trouble codes (dtc's) P0172 and/or P0175
• Nov 15, 2004 Service bulletinGear selector lever - increased effort to shift from drive to park
• Nov 1, 2004 Service bulletinGeneral power train control module (PCM) programming procedures
• Nov 1, 2004 Service bulletinRough idle in drive
• Oct 4, 2004 Service bulletinFront window clunk noise
• Oct 4, 2004 Service bulletinOil leak from oil filter adapter - 4.0L sohc engine built before 4/1/2004
• Oct 1, 2004 Service bulletinUnintended 4X4 engagement during low speed parking lot turns
• Oct 1, 2004 Service bulletinBroken rear cargo storage door lift handle
• Oct 1, 2004 Service bulletinMultiple vehicles - fuel level indication concerns - service tip
• Oct 1, 2004 Service bulletinRear axle noise
• Oct 1, 2004 Service bulletinSpeed control inoperative or not holding the set speed
• Sep 6, 2004 Service bulletinChatter, shudder, a binding sensation, or vibration during low speed turns on vehicles equipped with the...
• Sep 6, 2004 Service bulletinMalfunction indicator lamp (MIL) illuminated - system lean diagnostic trouble codes (dtc's) - service tips
• Sep 6, 2004 Service bulletinFront axle tube leak
• Sep 1, 2004 Service bulletinFuel gauge slow to update
• Sep 1, 2004 Service bulletinNo crank/no start condition when vehicle temperature is below freezing (32F/0C)
• Aug 23, 2004 Service bulletinEngine misfire or running - coil on plug (COP) ignition systems - wds cop kit diagnostic tips
• Jul 12, 2004 Service bulletinInoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns
• Jul 1, 2004 Service bulletinSome of the vehicles were built with instrument clusters that were not configured properly for use with a...
• Jul 1, 2004 Service bulletinMultiple vehicles using fehp rear axle fluid
• Jun 1, 2004 Service bulletinDelayed/harsh reverse engagement
• May 1, 2004 Service bulletinRear axle date code inspection and service
• Apr 1, 2004 Service bulletinRear axle chatter, shudder, binding sensation, or vibration during low speed turns
• Apr 1, 2004 Service bulletinAnti-lock brake system (ABS) light on with diagnostic trouble code (DTC) B2900, U1900 and C1805
• Apr 1, 2004 Service bulletinRear axle noise
• Mar 1, 2004 Service bulletinAn intermittent no start and/or malfunction indicator lamp (MIL) on with diagnostic trouble codes (dtc's)...
• Mar 1, 2004 Service bulletinStandard ABS (not advance trac/ivd) built prior to 2/9/2004 may exhibit an intermittent amber ABS light on...
• Mar 1, 2004 Service bulletinPoor fit between driver air bag and steering wheel
• Mar 1, 2004 Service bulletinRear 3.55 axle noise
• Mar 1, 2004 Service bulletinIntermittent hard start, long crank time or multiple crank attempts before starting
• Mar 1, 2004 Service bulletinDiagnostic trouble code (DTC) U0300 (internal control module software incompatibility) stored in the PCM...
• Mar 1, 2004 Service bulletinMalfunction indicator (DTC) lamp on with diagnostic trouble code (DTC) P2106
• Mar 1, 2004 Service bulletinRear liftgate rattle / light popping noise
• Feb 1, 2004 Service bulletinGenerator noise in cold ambient temperatures
• Feb 1, 2004 Service bulletinCertified rear axle available
• Feb 1, 2004 Service bulletinIntermittent air bag warning lamp on, memory seat, and/or adjustable pedal concerns
• Feb 1, 2004 Service bulletinRear axle noise
• Feb 1, 2004 Service bulletinDelayed crank with no start, diagnostic trouble codes (DTC) U0300/P0606/P2105/P2107, malfunction indicator...
• Jan 1, 2004 Service bulletinDistance to empty not displayed
• Jan 1, 2004 Service bulletinNo crank with diagnostic trouble code B1601 and/or B1213
• Dec 22, 2003 Service bulletinEngine-romeo built 4.6L 2V-TICK noise from engine-engines built before 9/17/2003
• Dec 1, 2003 Service bulletinDemonstration/delivery hold - special field action 03L17
• Dec 1, 2003 Service bulletinTire pressure monitoring system (TPMS) module configuration - service tip
• Dec 1, 2003 Service bulletinMultiple electrical concerns - fuse 2.17 open
• Dec 1, 2003 Service bulletin4X4 inoperative and/or indicators blinking
• Nov 1, 2003 Service bulletinFuel signal to instrument cluster service tip
• Nov 1, 2003 Service bulletinEngine auxiliary oil cooler line and the right side motor mount squeaking noise from front exterior while...
• Oct 1, 2003 Service bulletinA popping or creaking noise that appears to be coming from the front exterior of the vehicle
• Oct 1, 2003 Service bulletinMalfunction indicator lamp/etc lamp lit with P0606 and one or several P21XX-SERIES diagnostic trouble...
• Oct 1, 2003 Service bulletinMalfunction indicator lamp on and/or electronic throttle control lamp (ETC) on with diagnostic trouble...
• Sep 15, 2003 Service bulletinRemote keyless entry (RKE) - service tips
• Sep 1, 2003 Service bulletinDriveline vibration on drone/boom at highway speeds
• Sep 1, 2003 Service bulletinIntermittent diagnostic trouble code (DTC) P2106 with the malfunction indicator lamp (MIL) on
• Sep 1, 2003 Service bulletinThe amber anti-lock brake system (ABS) warning light on with diagnostic trouble codes C1235, C1236/C1237...
• Sep 1, 2003 Service bulletinAir conditioner hooting noise during light load acceleration at low speeds, from 1000-1300 RPM
• Aug 1, 2003 Service bulletinVehicles with a silver valve stem tire pressure monitor system (TPMS) may exhibit a warning light/message on
• Aug 1, 2003 Service bulletinAxle whine at cruise or during acceleration/ deceleration
• Jul 21, 2003 Service bulletinEngine misfire or rough running condition with coil on plug (COP) ignition systems may be more accurately...
• Jul 5, 2003 Service bulletinAnti-lock brake system (ABS) lamp illuminated and diagnostic trouble code (DTC) C1235, C1236, C1237 on...