1993 Mercury Villager technical service bulletins
113 technical service bulletins and manufacturer communications cover the 1993 Mercury Villager.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- New transmission cooler flusher - service tips
- Climate control a/c service tech tips
- Lamp-brake-invadvertent disabling of brake shift interlock
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- This aritlce is to provide information on replacement of old style hood lamp switch to the rvised...
- Brake shift interlock
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Information on servicing the forward clutch
- Information regarding the new transmission cooler flusher- service tip
- Be aware that the F6XZ-7A360-AA forward clutch assembly has been replaced by 3 individual parts
- Information regarding the servicing of the forward clutch, which has been replaced by three individual parts
- Some vehicles may exhibit a noticeable steering pull or drift while driving on a flat road surface
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Addressing an intermittent condition where the speed control will not set or may disengage while driving
- Exhibiting an intermittent condition where the speed control will not set or may disengage while driving
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Conditions with the brake lamps inadvertently disabling the brake shift interlock
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- On some vehicles the check engine warning lamp may illuminate and diagnostic trouble codes 32, 35, P0400,...
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Brief information regarding exhaust gas recirculation (EGR) system diagnosis
- Information regarding transmission assembly shortage
- Information regarding exhaust gas recirculation valve (EGR) system diagnosis
- Information regarding shortage of new transmission assemblies
- Special field action regarding revised waranty information
- Some vehicles may display diagnostic trouble code (DTC) 34, or PO325 (MIL DTC 0304) when testing the...
- Some vehicles may display diagnostic trouble code 34, or P0325 (MIL DTC 0304) when testing the electronic...
- Some vehicles may exhibit a malfunction indicator lamp (MIL) on and diagnostic trouble code ( DTC ) 32
- Concerns with EGR flow malfunction
- Whining noise from transaxle on light acceleration, tip-in acceleration between 40-64 km/h (25-40 mph)
- Rear brakes are binding or overheating after having been serviced
- Some vehicles with analog instrument clusters may exhibit a concern of a fluctuating or jumping tachometer...
- Information on a new transmission fluid usage chart
- Information on tire company telephone numbers for customer assistance
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use
- Service tip information regarding elimination of sanding rotors and drums
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable
- The rear brakes may bind or overheat after having been recently serviced
- Experiencing a squealing or grinding noise from either the front or rear brakes when the customer lightly...
- Availability of hub-mount brake rotor machining equipment
- Announcing the ford OEM air conditioning retrofit kit availability
- This bulletin mentions the two different cylinders available for replacement liftgate support cylinders
- Some vehicles may exhibit an intermittent ABS warning lamp concern and trouble codes 41/ 45/ 55/ 63 may be...
- Some vehicles may exhibit an illuminated anti-lock brake system (ABS) warning lamp and trouble codes...
- Subject regarding the availability of hub-mount brake rotor machining equipment
- Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds
- Front door window binding while traveling up or down
- EGR function testing
- Authorized warranty part replacement of brake pads to correct excessive brake noise
- Instructions on how to manually clear codes from memory after an ABS brake repair
- Instructions for testing the EGR
- Fuel economy- customer expectations versus vehicle usage
- Blower motor- "chirping" or "squeaking" from blower motor at low speeds
- Interior- leather seat cleaning procedure- service tip
- Fluid- transmission fluid usage charts
- Blower motor- "chirp" or "squeak" from blower motor at low speeds
- A chunch/grunt noise coming from the rear leaf spring shackle bushing may be repaired by installing an...
- Interface with the villager PCM/TCM on vehicles, use the OBD II dlc connector located just beneath the the...
- Poor heater capability in vehicles during cold weather while the engine is at idle
- Concerns of the ABS pump motor running while the vehicle is sitting still
- Some 1993 vellagers may experience an unpleasant odor during certain driving conditions
- Intermittent ABS lamp on and wheel sensor dtc's set while driveing the vehicle on the highway
- The ABS pump motor running while the vehicle is sitting still
- Some vehicles may experience an unpleasant sulfur odor during certain driving conditions
- Poor heater capability in villagers during cold weather while the engine is at idle
- When attempting to interface with villager PCM/TCM on 1996 & 1997 vehicles, use the OBD II dlc connector...
- Dealers who wish to order a cooling fan shroud for a 1993 villager should order part number F3XY 8C607 b
- Chunch/grunt noise coming from the rear leaf spring shackle bushing may be repaired by installing an...
- Suspension-noise from rear of vehicle- noise-"crunching/grunting" from rear of vehicle
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning...
- Extended crank - long crank time during morning start-ups - vehicles built through 7/1/96 no start - no...
- A few villagers may experience an intermittently inoperative front windshield washer
- Torque converter - leak test procedure - service tip
- Extended crank or intermittent stalling in high ambient temperatures
- Intermittent power door lock activation
- Information on aode/4R7W transmission main control & case replacement
- Improved rear shock absorbers available
- Brakes - elimination of sanding rotors and drums - service tip
- Mass air flow sensor - replacement as an assembly - service tip
- Improved fuel pump w/ an improved, hardened inner gerotor gear
- Procedure for intermittent engine flare on startup from a stop
- Fuel pump improved, hardened inner gerotor gear
- 2.3L efi engines display a rolling idle concern
- Parts information for replacing the main control
- There may be a squeak / rattle noise from the sliding door area and / or the sliding door may be difficult...
- Experiencing a crunch / grunt noise from the rear suspension of some vehicles
- May exhibit a grinding/squealing noise from the rear brakes
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because...
- Vehicle may experience a minor exterior rear view mirror vibration
- Vehicles may exhibit a grinding/squealing noise when it is cold in the morning and at the first...
- Crunching noise coming from rear leaf spring
- Intermittent to occasional brake squeal or brake creep/groan
- Transmission overdrive whine between 25 to 40 mph
- Unknown
- Fuel pump whine due to misplaced sound deading strips, allowing the fuel tank to ground out against the frame
- The rear brakes may bind or overheat after having been recently serviced
- Some vehicles may leak oil from the area of the front oil pump gasket
- Hissing or fluttering noise from engine compartment may be due to broken exhaust manifold stud
- Side window latch may not stay in open or closed position
- Vehicles may experience a low toned rattle/clunk from the rear portion of the vehicle while drivine less...
- Chirp or squeak from blower motor
- Rear wiper motor inoperative or intermittent operation
- Chirp or squeak noise from blower motor at low speeds
- Vehicles may exhibit a grinding/squealing noise from the rear brakes
- Vehicles may exhibit a driveability concern due to a broken crankshaft
- Some vehicles may experience a transmission shift hunting condition
- Vehicle ignition cylinders may require an excessive effort
- Vheicles may experience an engine exhaust leak due to a broken manifold stud
- Vehicles may experience a transmission shift hunt condition from 3-4 to 4-3
VIN decoder
See the problems and recalls for an exact car
Buying a used 1993 Mercury Villager?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history