1993 Mercury Villager: fuel leak

Filed Jul 2, 2002 · Engine · VA

In oct0ber of 2001 consumer had filler vent hose replaced as part of a recall, but remedy did not work, and fuel was leaking again.

Filed Jul 29, 2001 · Engine · TX

This is a known problem with all mercury villager vans allowing exhaust gas leakage into the engine bay in front of the firewall, therefore possibly entering the passenger compartment. Also exhaust gases are allowed into the atmosphere untreated by the catalytic converter. We finally picked up on this when my wife keep getting sleepy driving home, and found this information on the "edmunds" website, (edmunds.com). We have returned the van recently to repair the filler vent hose, probably a $2.00 repair, why has this problem not been addressed? It is far more dangerous, more expensive ($1200), and difficult to detect because it only sounds like a "stuck" valve lifter. We had the van for many years with the noise present, (from the leaking exhaust manifold), but the only source of any information on this design problem was the "townhall talk" forum on the edmund's website. How many people are going to have to be killed after falling asleep at the wheel before some type of notification goes into effect? I have a degree in mechanical engineering and this is obviously an improper shear strength manifold stud which I imagine was used to save some money along the way for nissan/mercury. Some kind of response here would be appreciated. Thanks, john.

Filed Jul 2, 2001 · Engine, Fuel system · SD

Bolt broke on exhaust manifold. Can hear a ticking noise. Also, fuel is leaking out though cracks. Dealership is aware of problem.

Filed Mar 13, 2001 · Engine · CA

Consumer received recall notice 00v419002 - fuel tank vent hose which caused fuel leakage, and resulted in a fire. Manufacturer has advised dealer that replacement vent hose was not in stock, and will not be for another couple of months. Has not yet provided a specific date for consumer.

Filed Feb 28, 2001 · Fuel system · CA

The vehicle exhibited the symptoms of recall 00v‑419, the consumer contacted the dealer about the fuel leak but was told that the next available appointment wasn't until two weeks, the consumers felt this problem needed immediate repair therefore they repaired it themselves. Nlm

Filed Aug 12, 2000 · Fuel system · IL

The fuel overflow hose broke on my 1993 mercury villager. This caused a fuel leak and a puddle of raw gas in my attached garage. Luckily, we noted it and move the vehicle outside and cleaned the fuel up. The mechanic stated that he had replaced about 8 of these hoses in the past couple of years, 3 this year alone. This is a very dangerous condition.

Filed Jul 3, 2000 · Fuel system · RI

Fuel leakage after fillup on a warm day and fuel tank was not over filled.

Filed Jun 26, 2000 · Fuel system · CA

I have experienced fuel tank/line/pump leaks on two occaisons. In july 1999 following a fuel pump replacement I had a leak in the tank and or fuel lines. In june 2000 I again had a fuel leak. The dealer repaired it, at a cost of approx. $60.00 and replaced a fuel or vent line.

Filed Jun 21, 2000 · Engine · CA

Fuel leaks from fuel tank vent hoses when tank is full or near full.

Filed Apr 29, 2000 · Fuel system · OH

Could smell gasoline vapors in van at idle on cold days. Found the smell was gas leaking from from the neoprene fuel lines connected to the fuel injector rails. (note: discovered cause, by reading article in cincinnati inquirer, 4/29/00) about a 95 nissan quest with the identical problem)

Filed Jan 28, 2000 · Fuel system · TX

Fuel is leaking from the fuel tank . Vehicle was inspected by a private mechanic who determined that fuel tank was not cracked. Manufacturer has been notified.

Filed Oct 18, 1999 · Engine · PA

The exhaust gas leaks from the vehicle causing a loud noises while driving and fumes entering vehicle. Dealer replaced the exhaust manifold bolts. Problem still exists.