1999 Mercury Villager technical service bulletins
118 technical service bulletins and manufacturer communications cover the 1999 Mercury Villager.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Ford: certain 1999 and 2000 model year villager villagers are to have the throttle body cleaned.
- Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair
- General (PCM) power train control module programming procedures
- General power train control module (PCM) programming procedures
- Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns
- Update wiring harness when replacing fuel injector
- New transmission cooler flusher - service tips
- Climate control a/c service tech tips
- Lamp-brake-invadvertent disabling of brake shift interlock
- Some vehicles may exhibit static or ignition noise through the radio on the AM band
- Some vehicles built from 9/26/1998 through 9/5/2001 may exhibit power door locks that self-active or cycle on
- Information regarding discharged battery charging service tips and guidelines
- Information pertaining to liftgate cylinder operation
- Some vehicles with the rear seat entertainment system may exhibit an inoperative condition
- Concerns with vehicle exhibiting a headlamp that is dim, flickers or is inoeprative
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant...
- Information regarding flip out window latch adjustment
- Some vehicles may exhibit interior lamps that come on while driving
- Engine oil system priming procedures, service tips for reports of premature engine failure
- Expereincing slight vibration/shake felt on some vehicles in the steering wheel and/or floor pan and front...
- Power door locks, self activating or cycling
- Brake shift interlock
- Some vehicles may exhibit poor and / or no a/c performance
- Some vehicles may exhibit heater core leaks
- Information regarding transmission fluid usage charts
- Some vehicles may exhibit the rear under body air conditioning lines leaking
- Some vehicles may exhibit a gear whine noise from the front under light acceleration while driving between...
- On some vehicles, the second row two-passenger bench or second row bucket seats may shake or vibrate...
- Some vehicles may exhibit a transmission operation concern
- Vehicles may experience vibration / shake felt in the steering wheel and / or floor pan and front seat at...
- Information regarding multifunction switch replacement
- Some vehicles may emit a momentary, light chirp noise from the transmission during the 2-3 upshift
- Some vehicles may emit a brief or sustained buzzing type noise from the dash area under load at...
- Some vehicles may exhibit a brief or sustained buzzing type noise from the dash area under load at...
- Information regarding the power door locksthat may self-activate or cycle on some vehicles
- Some vehicles equipped with the rear seat entertainment system may exhibit an inoperative condition when...
- Concerns with 2ND road seat(s) shakes / vibrates
- Some vehicles may exhibit a condition where the horn will not chirp and the lights will not flash when...
- Some vehicles may exhibit a light wheel-speed vibration when driving on a smooth road surface at highway...
- Some vehicles may exhibit a noticeable steering pull or drift while driving on a flat road surface
- Some vehicles equipped with the rear seat entertainment system may exhibit an inoperative condition when...
- Exhibiting a noticeable steering pull or drift while driving on a flat road surface
- Some vehicles may exhibit a power flip-out 3RD-ROW window that stops operating
- Information regarding the new transmission cooler flusher- service tip
- Some vehicles may exhibit a light wheel-speed vibration when driving on a smooth road surface at highway...
- Excessive amount of noise from the front wheels when braking under certain conditions.
- Vehicles may exhibit a light wheel-speed vibration when driving on a smooth road surface at highway speeds
- Some vehicles may experience an excessive amount of noise from the front wheel area while braking under...
- On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off...
- Vehicles built from 9/26/1998 through 9/15/1999 may have power door locks that self-active or cycle
- Some vehicles may exhibit a flip-out window glass in the sliding door or rear quarter that, when closed,...
- Some customers may comment the the left or right sliding door may be difficult to operate and / or sticks...
- Subject regaridng sliding side door operation
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Subject regarding front wipers operating while switch is in off position
- Addressing an intermittent condition where the speed control will not set or may disengage while driving
- Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject
- Exhibiting a loose and partially separated rubber strip along the windshield mounding at the left or right...
- Exhibiting an intermittent condition where the speed control will not set or may disengage while driving
- Some vehicles may exhibit a loose and partially separated rubber strip alone the windshield moulding at...
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material...
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Some vehicles built from job 1 through 10/31/98 may exhibit a clunk, snap or popping type noise from the...
- Subject regarding a flashing air bag warning lamp indicating a fault in the system
- Information regarding self-activating door locks
- Information regarding SRS system diagnosis, air bag warning indication
- (Continued from 13251 and 13252) uncommanded front wiper function. mjs
- Some vehicles may exhibit a loose or partially separated rubber strip on the windshield moulding at the...
- Experiencing a clunk, snap or popping-type noise from the rear suspension area while driving
- Some vehicles may exhibit a flip-out window glass in the sliding door or rear quarter that does not latch...
- Some vehicles may exhibit a concern where the horn will not chirp when using remote entry transmitter to...
- Some vehicles may exhibit a loose or partially separated rubber strip on the windshield molding at the...
- Conditions with the brake lamps inadvertently disabling the brake shift interlock
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (NVH)...
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on...
- Ford motor company has released a private labeled material to be used for iron particle / acid rain...
- Information regarding cupholder operation
- Some vehicles may exhibit windshield wipers that will intermittently activate without turning on the wiper...
- Subject regarding air bag system diagnosis
- Some vehicles may exhibit a rubber strip which loosens and separates from the windshield moulding onthe...
- Experiencing difficulty with programming remote entry transmitter
- Subject regarding windshield wiper activating without command
- Some vehicles may exhibit a flashing air bag warning lamp indicating a fault in the system
- Some vehicles may exhibit a rubber strip which loosens and separates from the windshield moulding on the...
- Conditions with side window latch popping open
- Some individuals may have difficulty programming remote entry transmitters
- Subject regarding door trim panel replacement - service tip
- Ford motor company now recommends sae 5W-30 viscosity grade for servicing any ford gasoline-powered...
- Subject regarding cupholder operation
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent,...
- Information on vehicles are equipped with an optional rear blower control assembly in the headliner
- Some vehicles may exhibit a scratching / popping noise coming from the rear liftgate area
- Information on vehicles equipped with an optional travel / note digital voice memo recorder
- Information on the optional power moonroof
- Some vehicles may exhibit a chirping or squeaking-type noise from the left sliding door / b-pillar area...
- Subject regarding all vehicles equipped with two different gas-filled lift cylinders on the liftgate
- Some vehicles built 12/11/98 and before, may exhibit a chirping or squeaking-type noise from the left...
- Some vehicles with optional power moonroof may not close from a partially open position after battery...
- Information on vehicles equipped with two different gas-filled lift cylinders on the liftgate
- Some vehicles may exhibit an inoperative speed control system
- Some villagers built on or before 9-27-98 may exhibit a rattle noise from the rear of the vehicle when...
- Some vehicles may exhibit interior courtesy lamps which are inoperative when the liftgage is opened
- Some vehicles built on or before 10/25/98 may exhibit an inoperative or noisy sliding door power lock actuator
- Some vehicles built on or beford 10-25-98 may exhibit an inoperative interior sliding door handle on...
- Some vehicles are equipped with an optional rear blower control assembly in the headliner
- Some vehicles built on or before 9/27/98 may exhibit a rattle noise from the rear of vehicle when driving...
- Some vehicles may exhibit interior courtesty lamps which are inoperative when the liftgate is opened
- Some vehicles built on or before 10-25-98 may exhibit an inoperative or noise sliding door power lock actuator
- Some vehicles built on or before 10/25/98 may exhibit an inoperative interior sliding door handle on...
- Experiencing a " buzzing " or " rattling " noise from the exhaust system
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Mercury Villager?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history