2022 Mitsubishi Outlander brakes problems

Filed Nov 3, 2026 · Body, Brakes · MI

Bought this used 2022 Outlander from Carvana Sept 10, 2026 at 58,350 miles for family use. A chain-like rattle began shortly after delivery. An authorized Mitsubishi dealer's R/O 6116238, open Sept 22/closed Sept 30, mileage in 58,939/out 58,940, confirms the RIGHT REAR CALIPER WAS MISSING THE BOLTS CONNECTING IT TO ITS SLIDE PINS. New guide pins/bolts were installed and the noise was gone on a test drive. I report paperwork showed Carvana brake work before delivery. Please investigate whether this condition resulted from pre-delivery repair or failed inspection; the records do not identify who omitted the bolts. The dealer also confirmed hood shaking/flutter above 60 mph, cited TSB 26-42A-002 and a reinforced replacement hood. Its narrative says parts ordered, panel to be painted and customer to return for installation; replacement completion is not established. On Oct 30 the next servicing dealership said Mitsubishi's hood was still awaited. On Oct 31 I reported apparent bending near the windshield and water pooling; no photo or professional causation finding for that new observation is supplied. No federal hood recall has been established. The brake-fastener and hood conditions raised safety concerns for our family. No crash, fire or injury is reported. The car is retained and available for inspection; availability of replaced fasteners is UNKNOWN. Prior warning lamps are UNKNOWN; rattling and hood flutter were symptoms. On Oct 30 I reported just under 62,000 miles and continued driving with restricted family travel. Odd wear on the other rear brake is an owner observation without a second-side diagnosis. Sept 22 in the incident field is the service-intake date; exact earlier symptom-onset date is UNKNOWN. Mileage field is intake mileage. Please review a possible safety defect, noncompliance, improper repair and the hood remedy delay.

Filed May 7, 2026 · Brakes, Driver assistance · TX

Automatic Emergency Breaking sometimes occurs while driving in rainy weather even when there are no obstructions in the front of the vehicle. This causes spinouts and exccessive wear and tear on break pads and rotors. Also, many shops and dealerships are having issues with putting 2022 year model outlanders in "maintenance mode" to be able to change rear ebs brakes. Due to this you cannot drive your vehicle and/or rish not having proper break functions. THIS IS URGENT!!!

Filed Apr 21, 2026 · Brakes, Transmission · 25,000 miles · CA

The contact owned a 2022 Mitsubishi Outlander. The contact stated that while driving at various speeds and depressing the brake pedal, the vehicle wobbled and failed to respond. The contact stated that upon forcefully depressing the brake pedal, the vehicle responded as intended. There was no warning light illuminated. The failure mostly occurred while driving at highway speeds. The vehicle was taken to the dealer where it was diagnosed, and determined that the braking system needed to be replaced. The dealer informed the contact that the repair was not covered under the two-year warranty. The vehicle was not repaired. Additionally, the contact stated that the vehicle failed to respond intermittently while attempting to drive from a complete stop on the roadway. There was no warning light illuminated. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 25,000.

Filed Sep 30, 2025 · Brakes, Suspension · NE

Excess play with front axles, manufacture defect improperly torqued axles, under or no grease for axles. Loud clunk noise when braking, rotors and brakes were replaced noise still exists, dealership claims it was the rotors and brakes from harsh driving which is false. Issues with axle, premature wear of front and rear rotors and brakes caused by front axles and suspension failure & defects dealership is refusing to honor warranty.

Filed Jan 21, 2025 · Brakes, Electrical · SD

For the past 3 winters since I had this vehicle when it is cold outside the vehicle starts hard or will not start at all requiring a jump. It will not shift gears, or accelerate. The battery light comes on after the vehicle is running. I have called the local dealership and was told this happens when it is cold. I was told to bring the car in and let it sit there when it's cold so they can try and re create the problems they stated the battery is fine. As of today the vehicle started to leak oil after it started hard. When i purchased the vehicle i had noticed the hood shakes and bounces when driving. I mentioned this to the sales agent and they stated it was a known issue and they would recall the hood but it was a timely process. It is unsafe to drive a vehicle that will not accelerate or change from reverse to park and then roll It is also.unsafe to drive with oil leaking in your car I have made my vehicle available each time there is a situation The battery light comes on but has been tested at the dealership in the last 2 months This happens every time it's cold i call and they tell me itsa known issue when it's cold. When i purchased the vehicle I noticed the hood bouncing I asked the sales person about it and they said it was a known issue and they would fix it when the parts came in. I should have been more careful as it was a vehicle right off the truck.

Filed Oct 1, 2024 · Brakes, Electrical · TX

While driving down the highway at 70 mph, my 2022 Mitsubishi Outlander SEL suddenly shut off without warning, causing the entire dashboard and instrument cluster to go dark. In a matter of seconds, the vehicle unexpectedly braked on its own, decelerating from 70 to 0 mph in an extremely short distance. This abrupt stop nearly caused an 18-wheeler behind me to rear-end my vehicle. Thankfully, the truck driver was able to swerve just in time, narrowly avoiding a catastrophic collision. The situation could have resulted in severe injuries or fatalities. During the incident, all power to the vehicle was lost. The brakes became unresponsive and impossible to press, and the steering became extremely difficult to control, making it nearly impossible to maneuver the vehicle safely. This is the fifth time my vehicle has experienced this issue, with the past three instances almost ending in serious accidents due to the car’s complete failure to respond. After a few seconds of total power loss, the vehicle inexplicably starts back up on its own and operates as if nothing had happened. Despite this recurring and life-threatening malfunction, the dealership has been unable to identify or fix the problem after four repair attempts. Each time, they’ve tried different fixes: 1. Initially, a software update was performed. 2. Next, the ADAS controller was replaced. 3. Then, the body computer was swapped out. 4. Now, they are attempting to replace a power distribution system. Even after these numerous interventions, the problem persists, and the dealership has no clear understanding of the underlying cause. They have viewed a video of the incident that I provided, but no actual solution has been identified. The dealership has resorted to seeking advice from other brand technicians in an attempt to resolve the issue, but to date, there is no resolution in sight. This defect poses an imminent danger to my safety and the safety of others on the road.

Filed Aug 1, 2024 · Brakes, Wheels · SC

There is very loud squealing noise coming from front tires when backing and driving forward. It gets extremely loud when turn the wheel in motion. Dealership claimed they couldn't fix it.

Filed Jun 27, 2024 · Acceleration, Brakes · TX

Persistent issue where the vehicle will loose all power to brakes, engine, instrument cluster and infotainment. This issue has almost caused 2 crashes out of the 3 occasions in which it has occurred. When the issue happens all power is lost as if the car were rolling in neutral while off, no indication of what is wrong or anything of the sort. It happened on the highway going about 65 mph, was able to steer (without power steering support) into the emergency lane as the car dramatically dropped speed. The brakes were also not being supported by the booster so it was extremely difficult to push the pedal, thankfully it was on a bit of an uphill. Put the car manually into park after it stopped, and by itself the car restarted, although some of the cluster components and infotainment components were very slow to restart. The next time this happened was in slow traffic, once again the car shut off with no warning of any kind. Once I managed to get the brake pedal pushed far enough for the brakes to engage, I managed to stop the car within a foot or so of the person in front of me. Once again, I put the car in park and it was able to restart on its own. Both times it has been to the dealer, Don Herring of Plano, and as helpful as the service advisor is, there is still no solution in sight as they keep changing electrical components left and right. I am worried about the car becoming a rolling ball of metal that I cannot stop one day. I hope Mitsubishi figures this problem out, otherwise its a fatality waiting to happen.

Filed May 13, 2024 · Brakes, Driver assistance · NJ · crash

As I was parking the parking sensors didn’t engage to say I was too close to another vehicle causing me to side swipe the other vehicle! I thought it was just me but still 4 days later anytime I park the sensors don’t alert me as being too close! The forward and reverse emergency brake system is not engaging as it used to do!

Filed Apr 7, 2024 · Brakes · NC

The car has a rapid war of rotors and break pads. The car inspected authorized dealer ship and they mentioned this is a very common issue on outlanders as the rotors, calipers, and breaks did not properly design for the wight of the car. It seems the manufactures and authorized dealer aware internally form the defect but do not take necessarily actions which may cause safety issue to owner of this make and model. After the dealer inspected the car i asked for the report but the dealership made all the report unavailable online and said they cannot provide any document