1996 New Flyer C40LF Problems: 0 Complaints, 3 Recalls

The worst 1996 New Flyer C40LF problems

Ranked by number of owner complaints. Mileage and cost come from what owners wrote.

Tap a problem to see which part fails, at what mileage and in which other years.

SteeringReported June 11, 2007 · 1,768 vehicles affected

What is wrong: On certain transit buses, the u-joint assemblies have inadequate spline engagement on one of the two end yokes.
Risk: Excessive play in the steering system could develop and, if not corrected, cause a loss of steering control which could result in a crash.
Remedy: The u-joint assembly will be inspected and replaced if necessary. The recall began on june 10, 2007. Owners may contact new flyer at 1‑204‑934‑4874.

Recall number 07V268000 · Recall details

Exterior lightingReported February 23, 2007 · 1,707 vehicles affected

What is wrong: Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." the flashing deceleration lamps were an optional item for some of these buses.
Risk: The standard requires that the deceleration lamp is a solid light rather than a flashing light.
Remedy: Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204‑934‑4874.

Recall number 07V068000 · Recall details

Steering: hydraulic power assist: hose, piping, and connectionsReported May 22, 2002 · 480 vehicles affected

What is wrong: On certain low floor buses, the power steering hose was incorrectly installed.
Risk: The hose can leak, creating the risk of an engine fire.
Remedy: Dealers will replace the hose. Owner notification began july 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1‑204‑228‑8984.

Recall number 02V112000 · Recall details

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

Is the 1996 New Flyer C40LF reliable?

Owners have filed 0 complaints about the 1996 New Flyer C40LF.

What is the most common problem with the 1996 New Flyer C40LF?

There are not enough complaints to tell.

How many recalls does the 1996 New Flyer C40LF have?

3 recalls, covering steering and exterior lighting.

See the problems and recalls for an exact car

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.