1997 New Flyer C40LF recalls
There are 4 safety recalls on record for the 1997 New Flyer C40LF, covering 4,933 vehicles in total across all the models in each campaign. Newest first.
All recalls
Steering
- What is wrong
- On certain transit buses, the u-joint assemblies have inadequate spline engagement on one of the two end yokes.
- Risk
- Excessive play in the steering system could develop and, if not corrected, cause a loss of steering control which could result in a crash.
- Remedy
- The u-joint assembly will be inspected and replaced if necessary. The recall began on june 10, 2007. Owners may contact new flyer at 1‑204‑934‑4874.
Recall number 07V268000 · Recall details
Exterior lighting
- What is wrong
- Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." the flashing deceleration lamps were an optional item for some of these buses.
- Risk
- The standard requires that the deceleration lamp is a solid light rather than a flashing light.
- Remedy
- Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on march 5, 2007. Owners may contact new flyer at 204‑934‑4874.
Recall number 07V068000 · Recall details
Steering: hydraulic power assist: hose, piping, and connections
- What is wrong
- On certain low floor buses, the power steering hose was incorrectly installed.
- Risk
- The hose can leak, creating the risk of an engine fire.
- Remedy
- Dealers will replace the hose. Owner notification began july 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1‑204‑228‑8984.
Recall number 02V112000 · Recall details
Suspension
- What is wrong
- Vehicle description: transit buses. There could be a casting defect in the left side spring tower. The spring towers support the vehicle structure, and failure of a tower could cause a sudden shift in the front axle.
- Risk
- This condition could lead to loss of control of the vehicle.
- Remedy
- Dealers will replace the spring tower. Owner notification is expected to begin during may 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1‑204‑982‑8181.
Recall number 01V160000 · Recall details
Questions about the 1997 New Flyer C40LF recalls
How do I check if my 1997 New Flyer C40LF has an open recall?
Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.
Do I have to pay for a recall repair?
No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.
How many recalls does the 1997 New Flyer C40LF have?
4, covering steering, exterior lighting and suspension.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 New Flyer C40LF?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history