2015 New Flyer XT60 technical service bulletins

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

• Jul 16, 2024 Service bulletinService bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
• Sep 21, 2021 Service bulletinTechnical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support...
• Sep 20, 2019 Service bulletinService Manual Bulletin provides revised information for the Preventive Maintenance on specifically...
• Sep 20, 2019 Service bulletinService Manual Bulletin providing revised, corrected or additional information for the Preventive...
• Sep 13, 2019 Service bulletinService Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage...
• Sep 4, 2018 Service bulletinThis Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support...
• Jan 5, 2018 Service bulletinThis Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg...
• Jan 5, 2018 Service bulletinThis Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation...
• Nov 15, 2017 Service bulletinThis Service Manual Bulletin provides new information on how to check for proper chain tension, as...
• Aug 11, 2017 Service bulletinThis bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
• Jun 30, 2017 Service bulletinThis Maintenance Instruction describes an inspection of ZF center axle hub/rotor bolt torque.
• Mar 31, 2017 Service bulletinTechnical Instruction to replace air compressor mounting bracket.
• Feb 28, 2017 Service bulletinTechnical instruction to install spacer for entrance door lower shaft pivot mounting bracket.
• Nov 30, 2016 Service bulletinTechnical instruction for amerex display module and firmware validation
• Oct 31, 2016 Service bulletinTechnical instruction to replace rear axle fluid and fluid specification tag.
• Aug 31, 2016 Service bulletinTechnical instruction to replace rusted wheelchair restraint floor plate hardware.
• Aug 31, 2016 Service bulletinTechnical instruction to revise lift-u wheelchair ramp hardware torque values.
• Jul 31, 2016 Service bulletinTechnical instruction to apply specific torque to all mounting bolts for rooftop components.
• Jun 30, 2016 Service bulletinTechnical instruction - addition of a bridge rectifier to ramp power supply - specifically equipped vehilces
• Jun 30, 2016 Service bulletinTechnical instruction - inspect rear bumper and re-torque mounting hardware if required - specifically...
• May 31, 2016 Service bulletinTechnical instruction to inspect and re-torque connection points for ground cables.
• Apr 30, 2016 Service bulletinTechnical instruction to install support bracket for transmission mode selector harness on specifically...
• Apr 6, 2016 Service bulletinSec. 579.5
• Mar 31, 2016 Service bulletinTechnical instruction to clean traction motor ground connection.