2022 Nissan Rogue: engine knocking or ticking

Filed Sep 24, 2026 · Engine · 159,143 miles · MT

The contact owns a 2022 Nissan Rogue. The contact stated that the vehicle was previously repaired under the federal safety agency Campaign Number: 25V437000 (Engine and Engine Cooling); however, the failure occurred after the recall repair. The contact stated that while his daughter was driving 80 MPH, the engine made a loud knocking sound with the messages, "Engine Stalling - Pull Over and Park Safely" and "Shift to park(P)" were displayed. The contact's daughter pulled over and turned off the vehicle. The vehicle failed to restart after several attempts, with a burning odor inside the vehicle. The vehicle was towed to the residence and then to an independent mechanic, who retrieved DTC: P0014, P0017, P0506, P0524; and determined that there were metal shavings inside the oil filter and the engine. The vehicle was then towed to the dealer, who determined that there was severe internal mechanical knocking from low crankshaft, heavy metallic contamination, internal bearing failure, and catastrophic engine wear. The contact was informed that the engine needed to be replaced. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 159,143.

Filed May 12, 2026 · Engine, Fuel system · FL

During acceleration engine makes a strange noise as if marbles were rolling around in the engine, or a knocking noise more noticeable when the engine is cold. Dealership says this is a normal sound on Nissan Rogues with the 1.5 cyl turbo charged engine. When I use 89 octane fuel the knocking sound seems less pronounced but, The manual on my 2022 Nissan Rogue says to use 87 octane. Is there anything we can do if the dealership refuses to acknowledge there is a problem which needs to be addressed?

Filed Apr 20, 2026 · Engine · GA

My 2022 Nissan Rogue has experienced repeated engine failures beginning at approximately 88,000 miles, including four separate incidents despite repairs performed at authorized dealerships. The vehicle exhibited engine knocking and drivability issues prior to failure. Nissan later issued a recall related to engine issues, and recall service was performed on January 29, 2026. The engine failed catastrophically less than 30 days later and was diagnosed with coolant intrusion into the cylinders requiring full engine replacement. The recall inspection appears to have been limited to a computer scan and did not identify the underlying issue. This raises concerns that the defect may not be properly detectable through the current recall procedure. I am reporting this as a potential safety concern due to repeated engine failure and loss of confidence in vehicle reliability.

Filed Apr 13, 2026 · Engine · 122,053 miles · TX

I am reporting a safety defect involving my 2022 Nissan Rogue related to the federal safety agency Recall 25V437 (engine bearing failure). Prior to complete engine failure, I experienced multiple instances of sudden loss of power while driving at highway speeds, creating a serious safety hazard. In one instance, this nearly resulted in a multi-vehicle accident in heavy traffic. The vehicle also exhibited additional symptoms consistent with the recall, including engine shaking, knocking noises, rough riding and hard shifting, burning smell, and warning lights. Nissan performed the recall service, which consisted of reprogramming the Engine Control Module (ECM). However, this software update did not repair or replace the defective engine components. The vehicle’s condition worsened after the recall service. The engine ultimately failed completely at approximately 122,000 miles, shortly after the recall repair was completed. This indicates that the recall remedy is ineffective and does not adequately address the safety risk, as a software update cannot prevent or correct pre-existing mechanical failure of engine bearings. I am concerned that other vehicles with this defect remain at risk of sudden power loss and potential crashes despite having the recall performed.

Filed Mar 22, 2026 · Engine · NJ

**Timeline Summary – Vehicle Safety Recall Case** **Owner:**XX **Vehicle:** 2022 Nissan Rogue (VIN: [XXX] ) **Dealer:** Pine Belt Nissan of Keyport **Recall:** the federal safety agency 25V‑437 (engine bearing defect) **August 2025:** Owner received recall notice describing a potential engine bearing defect that could lead to engine damage, sudden power loss, or fire. Nissan indicated remedy was not yet available. **December 2025:** Nissan notified owner that remedy was available. Repair protocol included ECM reprogramming, diagnostic drive cycle, and DTC scan, with engine replacement if faults were detected. **December 3, 2025:** Vehicle serviced at Pine Belt Nissan. ECM reprogrammed (campaign XXX), diagnostic testing completed, and no DTCs found. Vehicle returned to owner. **Mid-January 2026:** Engine suddenly failed during normal driving, resulting in complete loss of power. Vehicle became inoperable and was returned to dealer. **January 16, 2026:** Dealer diagnosed catastrophic engine failure: “engine ran without oil… knocking… needs long block, turbo, and Bank 1 catalytic converter.” Estimated repair cost exceeded $10,000. Owner declined repairs. Oil, filter, and drain plug washer were replaced during this visit. **Current Status:** Vehicle remains inoperable. Failure occurred shortly after recall repair and appears consistent with the defect described in Recall 25V‑437. **Key Issue:** Catastrophic engine failure occurred soon after completion of the recall remedy, raising concern that the repair did not adequately identify or prevent the defect. Owner is requesting full repair coverage, including engine replacement and related damages. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 9, 2026 · Engine · 84,000 miles · NY

The contact owns a 2022 Nissan Rogue. The contact stated that while driving 55 MPH, the vehicle went into LIMP Mode and decelerated to approximately 10 MPH. The message "Engine Malfunction" was displayed. The contact was able to pull over to the side of the road. The vehicle was restarted, but failed to respond while depressing the accelerator pedal. The vehicle was towed to the dealer, where it was diagnosed and determined that the engine had failed due to the failure of the camshaft and three other unknown parts around the camshaft. The dealer determined that the failure was not related to the federal safety agency Campaign Number: 25V437000 (Engine and Engine Cooling) because the engine had not failed due to rod bearing failure. The vehicle was not yet repaired. The manufacturer was notified of the failure and offered a 70 percent reduction in the cost of the repair. The failure mileage was approximately 84,000.

Filed Mar 9, 2026 · Engine · NC

My 2022 Nissan Rogue VC-Turbo has progressively worsening engine knocking and vibration since ~30,000 miles. Dealer documented: “Found variable compression ratio actuator to be making noise” (see repair order). Symptoms persist at idle, acceleration, and when warm. Recall 25V‑437 is marked complete, but the actuator continues to make noise, indicating the defect is not fully remedied. Nissan Consumer Affairs offered 50% financial assistance toward the actuator repair (email attached), and the dealer requested a diagnostic fee, which I have not paid and formally dispute, as the inspection relates to a potential safety defect. The actuator controls the internal multi-link compression system connected to the crankshaft, Progressive knocking and vibration may indicate stress on internal bearings and failure could lead to loss of engine power or engine seizure while driving, creating a serious safety risk. Vehicle is originally owned, maintained at Nissan dealerships, and has a branded title solely for cosmetic hail damage, with documentation confirming no structural or mechanical impact. I request the federal safety agency record this complaint, evaluate potential safety defect, and consider further investigation. I can provide repair orders, service records, and videos of the noise if needed.

Filed Nov 8, 2025 · Driver assistance, Engine · TN

While driving, multiple warning lights appeared on the dashboard, including the check engine light, malfunction indicator, and crash sensor warnings. A message then displayed: “ENGINE MALFUNCTION POWER REDUCED SERVICE NOW.” The engine began making loud knocking noises, lost power, and the vehicle entered reduced-power mode. The issue appears to be related to the ongoing engine bearing failure recall (R25A8 / 25V‑437) affecting Nissan vehicles with VC-Turbo engines. Because of these symptoms and the risk of complete engine failure or loss of motive power, the vehicle became unsafe to drive and was parked. The problem poses a serious safety risk, as the loss of power occurred suddenly while the vehicle was in motion, which could cause an accident if it happens in traffic. The problem has not yet been repaired because the manufacturer has not released the full recall remedy. I called the Nissan Dealership in Greeneville TN, at 8:53 AM EST on 11/08/2025 the vehicle is currently parked at my residence. I was advised by the dealership to call back on Monday morning to schedule an inspection at a Nissan dealership. Warning lights and the “Engine Malfunction Power Reduced” message first appeared shortly before the loud knocking began and power loss occurred on the vehicle.

Filed May 29, 2025 · Engine · NY

Driving vehicle around 60 mph. Heard load knocking noise coming from engine then vehicle instantly lost power. Engine reduced power came across display and it had virtually no power to get to side of road. I called dealer and I they said I would have to pay to tow it there and pay to diagnose engine problem because I was out of warranty. Got vehicle towed back to my house by myself. Load knocking noise heard from engine.

Filed Feb 13, 2025 · Engine · NY

I was driving and began hearing knocking sounds from under the hood. The car began dragging, so I was afraid to go at any speed over 25 or 30. I was almost home and it was night, so I resolved to go to the mechanic by my house the next morning. When I set out to go to the repair shop, the car was knocking louder, and I did not go more than a mile before the car stalled at a stoplight. It shuddered and then cut off. I tried to restart it, but it kept coming on and going off right after. I was in the turning lane, and had on my hazard lights, but several motorists still came up close behind me and honked their horns for me to move. This happened about a dozen times before the tow truck arrived. One man came up beside me, yelling and making gestures (I kept my window up and ignored him). I called AAA and was towed about a mile to the shop. The shop owner checked the oil to see if I had run out of oil - I had not. He then said to have it towed to Nissan because it was under warranty and the “engine is done.” He said that due to the sounds he heard coming from the engine. Days later (it was Saturday, and Nissan was not open Saturday or Sunday) I had it towed to Nissan and they have yet to diagnose the problem, after several days.

Filed Aug 30, 2024 · Acceleration, Engine · CA

I recently experienced “safe mode” in my 2022 Nissan Rogue while driving on the highway at 80mph. My car suddenly lost power and would not accelerate or brake. I had to have my vehicle towed off the side of the highway as it was not drivable. My car is currently under diagnostic at Nissan where they are unable to reproduce the error codes. They notified me of $4,000 in repairs that would be covered by Nissan but they are unsure that will fix the problem. My car is knocking while driving, vibrating upon attempt of acceleration and shuttering at idle.

Filed Jul 29, 2024 · Engine · TX

Engine started misfiring and when stopped at red light the engine began making a knocking noise.