Engine failed unexpectedly and without warning. After doing research there is a widespread problem with the 2016 diesel engine.
Nissan Titan XD engine failure problems
34 of the 200 owner complaints about the Nissan Titan XD describe engine failure.
- owner complaints
- 34
- typical mileage
- 83,000
Is there a fix? No recall or service bulletin covers this area of the car yet.
By model year
- 201634
Often reported together
Trouble codes mentioned
P0087 1
What owners say
I purchased this Nissan Titan XD used in 2018 with 20,000 miles on the vehicle. Since that time, it's been driven an average of 4,000 miles per year. Current odometer reading is 53,813 miles. The truck has had all required and recommended service done on the manufacturer's recommended schedule. We were headed west on [XXX] and were approximately 18 miles west of El Centro when the engine experienced catastrophic failure from the main bearing failure which damaged the crank and pistons. There were no warning lights, or messages showing prior to the engine failure. All gauges were reading normal. We went from normal operating to the engine sounding like it was grinding a bag of hammers instantly and without warning, Our safety and the safety of other was put at risk because the engine failed so unexpectedly, we barely had time to get to the side of the roaad. I was barely able to get to the shoulder . We were then stuck there within inches of traffic moving at high speeds until a toow truck could be sent. That took hours while we stayed seatbelted into our truck in 96 degree weather waitng for a wrecker. Even the slightest bit of distarction by one of the driver coming by us cold have been catastrophis. We count oursekves lucky we weren't hit. The vehicle was eventually towed to Nissan Imperial in El Centro. The diagnosis was confirmed as a failed main bearings. I know this was investigated earlier by the federal safety agency, but these trucks are still on the road and still failing at very low mileages and usages. This is obviously a defect by Nissan and Cummins as all the failures of this type I see are in 2016 year model trucks with the 5.0 Cummns diesel. Nissan has acknowledged that the failure was failed crank bearings but refuses to take any responsibility for a $69,000 vehicle that only went 53,813 miles before turning itself into a large paperweight. I need help dealing with Nissan on theis please. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Odometer Fraud. The contact purchased a 2016 Nissan Titan. The vehicle was a dealer sale. The contact later discovered a mileage discrepancy. At the time of purchase, the vehicle mileage was 31,190. When the vehicle was later taken to a dealer for an engine failure, the dealer informed the contact that the mileage was 226,000.
The contact owns a 2016 Nissan Titan. The contact stated that the low fuel pressure message was displayed, and the vehicle failed to start after several attempts. The contact stated that the failure was related to Emissions Recall: PD128. The contact stated that the vehicle was towed to the local dealer, where the engine was replaced, but the failure recurred. The dealer informed the contact about additional diagnostic testing. The manufacturer was contacted, who opened a case, but no additional assistance was provided. The approximate failure mileage was 83,000.
There is a known issue by Nissan regarding many issues with the XD Diesel platform trucks. Mine is a castrophic engine failure at 76,237 miles. There was a recall previously on turbos for many 2016s & 2017s. One is not showing up for mine and as I bought the truck used can not confirm or deny my truck was one effected by this recall. I was driving and heard a light thump and had just had my tires rotated. It sounds like a tool or piece of rubber was inside the tire. I got out and made sure tires were on tight. Got back in the truck and got an engine loss of power warning and then the "oil pressure low stop vehicle" warning. I immediately pulled over and called insurance company for a tow. My truck now sits at the dealership needing a new motor and 2 turbos to the estimated cost of $39,850.
Dear Sir/Madam Masked Oil Pressure Warning in 2016 Nissan Titan XD (5.0L) I am writing to report a concerning and potentially dangerous defect observed in a 2016 Nissan Titan XD equipped with the 5.0L Cummins V8 diesel engine. As a Nissan Master Technician with extensive experience in vehicle diagnostics and repair, I believe this specific defect could be a contributing factor to the well-documented crankshaft breaking condition prevalent in these vehicles, which the federal safety agency is currently investigating. The specific issue I have identified and thoroughly documented on my own 2016 Nissan Titan XD is as follows: Observed Defect: The engine oil pressure gauge consistently reads "normal" (approximately 1/2 scale) at all times, including with the Key On, Engine Off (KOEO). Crucially, the corresponding oil pressure warning light does NOT illuminate during the normal Key On, Engine Off bulb check or at any other time, despite the engine not running. Diagnostic Findings (Summary): Preliminary diagnostics, including unplugging the oil pressure sensor, indicate a likely fault with the oil pressure sending unit itself, causing it to send a false "normal pressure" signal. This specific sensor defect fundamentally compromises the vehicle's critical oil pressure monitoring system. ( the engine is running ok, no other symptoms) Potential Safety Implications and Link to Crankshaft Failure: This defect creates an immediate and severe safety risk because it completely masks any actual low oil pressure condition that the engine may develop. Documentation: I have well-documented photographic evidence of the current occurrence described condition (gauge reading, non-illuminated warning light KOEO) which I can provide upon request to support this report. I urge the NTSB to include this specific oil pressure sensor/warning system defect in its ongoing investigation into the 2016 Nissan Titan XD 5.0L Cummins engine failures Sincerely, [XXX] Nissan Master Technician ASE-1104-7529 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
During cruising at 70mph on the interstate, vehicle started making some noise from the engine and 5 miles later locked up completely leaving me stranded. This is a known issue with the 5.0 Cummins. My safety and the safety of others was put at risk through the vehicle being disabled on the side of the highway all of the sudden during rush hour traffic. Problem was confirmed at a dealer. No warning lamps or messages prior to complete engine failure, just some slight noise from the engine a few minutes before.
The contact owns a 2016 Nissan Titan XD. The contact stated that while driving at 80 MPH, the engine was seized. There were no warning lights illuminated. There was an abnormal grumbling sound from the engine. The vehicle coasted and came to an abrupt stop. The contact stated that he experienced a catastrophic engine failure. The contact sustained a seatbelt rash and whiplash, but medical attention was not provided. The crankshaft had snapped. The driver was stranded for two hours in the desert. The vehicle was towed to his residence. The local dealer was contacted, who recommended an engine replacement. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 180,000.
What component or system failed or malfunctioned, and is it available for inspection upon request? Fuel system/oil system catastrophic engine failure. Yes it is How was your safety or the safety of others put at risk? Truck shut down on highway at 70 mph with a child and wife in the truck Has the problem been reproduced or confirmed by a dealer or independent service center? Truck needs a complete motor. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Inspection was through a well know ase diesel technician Were there any warning lamps, messages or other symptoms of the problem prior to the failure, no there was not and when did they first appear? N/A
Engines blown. Needs new engine.
Related recalls
No recalls on record for this model year.
Questions about the Nissan Titan XD engine failure
Which Nissan Titan XD years have engine failure problems?
The model years with the most reports are 2016 (34 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Nissan Titan XD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history