2004 Nissan Titan steering problems

Filed Sep 3, 2018 · Electrical, Engine · 335,000 miles · LA · fire

My husband could have been killed. We had no knowledge of any recalls. Two days ago my husband was getting in the truck and all of a sudden smoke started coming from the dash board and a fire was starting. He immediately ran in the truck stop store and was able to get a fire extinguisher. Another customer unhooked the battery as my husband distinguished the fire. The truck will not start and when trying to test it out by re-attaching the battery the smoke began again. We are now without a vehicle and had to get the truck towed home.

Filed Jul 30, 2013 · Steering, Suspension · 126,000 miles · MD

This is the second time in over several months that my driver side drive axle for my 4x4 has pulled its self out. It was fixed once on my dime and is now going to be fixed on my dime again it is a dangerous failure that could cause my suspension to lock up an rip my wheel off then leading to a serious accident. It needs to be addressed and the federal safety agency has done nothing to pursue this. Another problem that nissan will not cover is the rear axle seals that blow out due to a faulty design which may also lead to a serious accident, they will not address any of these issues under a recall an there are thousands of people that are suffering from these issues from 04-010 for the axle seals and model years 04-08 for the axle shaft pulling out from the 4x4 causing serious damage to internal and external parts. This needs to be addressed an the federal safety agency is doing nothing about it.

Filed Feb 4, 2013 · Steering, Transmission · 140,000 miles · MD

I was using my four wheel drive when I noticed a loud clunk and found that my axle had popped out of the front differential. I am among over 1000s of titan owners with this same issue that nissan knows about and has caused multiple failures in our trucks. It also caused a failure in mine. The have known about this issue for years now and changed there part in 07 from the original number 38500-8s102 to the new product number 38500-8s11b truck is a nissan titan 2004 se king cab 4wd.

Filed Oct 5, 2012 · Engine, Steering · 136,000 miles · CA

Tl* the contact owns a 2004 nissan titan. The contact stated that while the vehicle was at the local mechanic for routine inspection the contact was informed that the engine exhaust manifold was leaking due to a defective design. In addition, the steering failed while driving. The steering column was replaced; however the exhaust manifold was not repaired. The failure and current mileage was 136,000.

Filed Dec 19, 2011 · Steering, Suspension · 60,600 miles · NH

Failure of front control arms, according to nissan website (many other vehicles were recalled for same, not mine) this could result in collision. Mechanic stated the wheel would come off with failure. Nissan dealership discovered the weld was failing and told me they had to be replaced, but that while 1800+ vehicles were shown to be affected by this issue, my VIN number was not on list. Nissan needs to expand their recall.

Filed Dec 2, 2009 · Steering · UT

I have a 2004 nissan titan and have had it for about 4 years. There is 51000 miles on it and around 22,000 miles I put a lift on it. Everything was fine with the truck until I got around the 35,000 mile range. When I would drive the truck I would notice loud noises coming from the front end. I took it to my nissan dealership 2 or 3 times and they said that everything was fine and that it was just my suspension that was making the noise. Now it has been about 15,000 miles later and I noticed a leak coming from around the front axle so I took it back and they told me that my front differential needed to be replaced. They told me that it would cost $2300 to fix it. They also told me that they see this problem alot with nissan titans. When I got home I did a little research and found close to 100 people that had the same problem. I feel that nissan should be the one to take care of the problem.

Filed Oct 3, 2009 · Steering · 47,021 miles · WY

Turning steering wheel. Steering rack pulled apart. Total loss of power assisted steering and complete steering fluid loss. When fluid loss occurred it sprayed all the fluid to the left saturating inside brake pad and rotor. No action taken yet just occured. Part still on truck.

Filed Mar 27, 2008 · Steering, Suspension · 16,021 miles · NH

Tl*the contact owns a 2004 nissan titan. The contact stated that the steering wheel began to shake and rattle. The vehicle was taken to the dealer several times, but they insisted that there was no failure. The vehicle was taken back to the dealer and the steering failure was able to be duplicated. The steering rack force was adjusted; however, the failure persists. The manufacturer stated that the vehicle is five months out of warranty and will not offer any assistance. The current mileage was 24,800 and failure mileage was 16,021. Updated 07/07/08. *lj updated

Filed Aug 13, 2007 · Brakes, Steering · 12,000 miles · PA

Tl*the contact owns a 2004 nissan titan. The contact stated that the rotors on his vehicle have been replaced three times. The first time was in october of 2005 due to a safety recall. The second and third times were due to so much corrosion that the brake pads detached from the brakes. The power steering line has been replaced three times in two months. He also stated that the power steering failed intermittently while driving. The VIN, purchase date, speed, and recall number were unknown. The current mileage was 23,000 and failure mileage was 12,000.

Filed Mar 18, 2005 · Steering · 5,000 miles · VA

Power steering fluid leak under right (passenger-side) axle-to-wheel area. Also, a front-end alignment problem. I have had to take my 2004 nissan titan le 4x4 crew cab into the dealer service shop on at least 3 occasions to try and get the power steering fluid leak repaired/stopped. The last time it was in the their shop they had my truck for over a month waiting on a new power steering hose part that apparently was in short supply. The leak has now started again and I'm going to have to take the truck in again... Additionally, ever since the truck was brand new, I have asked the shop to fix the alignment 4 times and it's still not right. The steering seems straight until higher speeds (60+ MPH) then I have to keep the steering wheel turned a little to the right to keep the truck straight. My truck only has 7600 miles on it so far. I have also had the brakes repaired once already. Based on all of the brake complaints I have read, I'm sure I will have to get them repaired again soon. When should I try to use virginia's lemon law?