Tl* the contact owns a 2005 nissan titan. The contact stated that while driving the vehicle at any speed, the vehicle leaked fuel and exhaust fumes emitted. The vehicle was driven to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate mileage was 63,000.
2005 Nissan Titan fuel system complaints
Page 3 of 5: complaints 41 to 70 of 104, newest first, as owners wrote them.
Lost power to vehicle while driving, power steering, brakes, etc. Narrowly avoided accident. Gas gauge indicated a quarter tank of gas when it was actually empty. Contacted nissan, they said there was recall for this for the year make and model, but my VIN was not included in the recall.
Tl* the contact owns a 2005 nissan titan. While driving approximately 7 MPH, the engine stalled because the fuel gauge reading was inaccurate. The fuel tank was empty. The vehicle was coasted to a safe location and refueled. In 2014, the vehicle was repaired under the federal safety agency campaign number: 10v074000 (fuel system, other); however, the failure recurred. The vehicle was not repaired a second time. In addition, when the vehicle was parked with a quarter tank of fuel, the reading would display less after returning to the vehicle. The failure occurred intermittently. The manufacturer was notified of the failure. The approximate failure mileage was 55,000.
Certain 2005 nissan titans were recalled in campaign #10v074000 due to the fuel gauge showing that there was fuel remaining when the tank was actually empty. This occurred to my vehicle in february 2013. The vehicle shut down and I lost power steering. I was luckily able to turn with enough force to leave the roadway. After contacting nissan, they declared my vehicle was not part of the recall and was not affected although I was having the exact same issue.
Tl* the contact owns a 2005 nissan titan. While driving 20 MPH, the vehicle lost power and restarted after numerous attempts. The contact stated that the fuel gauge was not registering. There were no warning indicators illuminated. The vehicle was not diagnosed or repaired. The VIN was not included in the federal safety agency campaign number: 10v074000 (fuel system). The manufacturer was not made aware of the failure. The failure mileage was unknown. Updated 02/05/16
After driving for 250-300 miles with stops for fuel and food the engine loses power and quits. After getting off the road and turning off the ignition for several minutes the engine will restart and run for 10 t0 20 minutes until it quits again. This happens on interstate highways at speed of 70+/- MPH. This has been happening for 6 or 8 months. The truck has been to several shops and several parts have been replaced according to the ECM service engine codes. Nothing has solved the problem. Took the truck to nissan dealer for help. They could not find the problem and said they had no record of any such problem and could not do anything unless they drove the truck and had the problem happen while they were driving. I do not know what is causing the engine to quit at highway speeds and at this point neither does nissan. I believe this lose of power is as dangerous as the gm ignition problem which caused a lost of power. Since I need the truck for transportation I continue to drive it but try to stay in the right lane so I can get off the road when it quits.
Driving to work in the morning rush hour traffic, at approx 65 MPH, I experienced my 2005 nissan titan shut completely down losing all power to the engine resulting in a loss of power to all supporting engine accessories including the power steering and ABS. I attempted to restart the vehicle while driving, by down shifting to neutral, which failed. Fortunately I was able to find a find a spot to pull over on the side of the busy highway and call for roadside assistance. It was later determined that I had run out of fuel, despite the fuel gauge showing well over 1/4 of a tank of usable fuel. At this point I discovered a recall campaign for the 2005 - 2009 nissan titan instrument panel fuel gauge (the federal safety agency campaign number: 10v074000) and proceeded to call the phone number listed in the remedy portion of the recall. When speaking with nissan it was determined that my VIN wasn't included in the recall campaign, and an appointment was made at the local nissan dealership by nissan consumer affairs to confirm my finding and see if they would be able to complete the repair for me under the recall. When I brought my vehicle to my local nissan dealership they informed me that the vehicle VIN wasn't apart of the recall, but did see a service bulletin associated with that make and model. It was ultimately determined they wouldn't be able to recover warranty money from nissan, and informed me that I would need to pay for the repair out of pocket. Bottom line, it came down to a monetary issue not a safety factor issue for nissan. It was obvious my vehicle experienced the same potential consequences as the other 2005 nissan titan VIN's in the recall campaign. However, based on my experience in trying to resolve this matter, it is obvious nissan feels the onus of liability ultimately falls on me as a consumer and not them, if I would like to operate my vehicle in a safe manner. Updated 10/9/15 *ln updated 12/21/2015
Hi, I have a 2005 nissan titan and the exhaust manifold has cracked in the same spot twice now and it is before the cat so that means its now a gross polluter. The problem is you get it fixed and they put the same part back on that cracks again because they haven't changed the design. There are 3 other titans in my town and all of us have the same story. Also the sway bar mount on all of ours are broke witch results in very poor handling. I hope it can be recalled before something serious happens. Thank you.
We took the titan to a nissan dealership for recall service and general service only to find out that the fuel level sensor that was on recall notice is not covered on our particular VIN. Interesting that the $110 diagnostic test I was charged for showed that sensor has failed, but nissan refuses to cover my vehicle under the recall. By looking at the complaints on this site, I can see I am not the only consumer affected by this issue. Makes me wonder if nissan is actually honoring any of the recalls for this particular repair. Interesting that after my service date, I was contacted by a sales representative with the same dealership asking if I would consider bringing in my 2005 titan for a trade-in opportunity. I don't want a new car, I want this one repaired with the recall that was issued to address this problem. I contacted the national office and was assigned a case number and the individual handling the case also declined my request for repair. On that same call, I was asked how many nissan vehicles I own and if I would consider buying a nissan in the future. Based on my experience with this recall, I will never own another nissan. Nor will I recommend nissan to anyone who asked what our experience has been with this vehicle and the nissan motor corporation.
Tl* the contact owns a 2005 nissan titan. The contact stated that the vehicle failed to start. The vehicle was inspected by an independent mechanic. The technician diagnosed that the fuel tank was empty and needed fuel in order to start the vehicle. Also, the technician noticed that the fuel gauge read a quarter tank full. As a result, the technician diagnosed that the fuel sender unit inside the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the VIN was not included in the federal safety agency campaign number: 10v074000 (fuel system, other). The approximate failure mileage was 170,000.
While driving on a highway at approximately 55 MPH, my engine stalled. I lost all engine power to my truck, with no error codes, no check engine light. I had to place my truck in neutral while at speed in traffic in the left lane and coast to a safe location on the right shoulder. During this time, I had no power steering or power brakes. After I safely stopped on the shoulder, I tried to restart my engine. My engine would not start. Approximately one month prior to this incident, my truck had intermittently stalled while stopped, with an error code that pointed to an ineffective catalytic converter. I had my mass air flow sensor replaced, my ECM relay replaced, and my catalytic converter replaced, at a cost of ~ $5000 total. I am now told the intelligent power distribution module is likely the culprit for all of these problems, which will cost me another $700 to replace. In researching previous recalls, there is an existing recall for the ECM relay, but not the ipdm module. It appears in other titan forums that several other people have suffered from the same issue.
The other day I was sitting in traffic for almost 30 min stopped with the engine running (lots of christmas traffic on the 5 south freeway), I put the truck in park because I notice an accident. I had my windows up and my cabin air on. Then a few min later I started feeling dizzy almost fainting. The car next to me saw that I was struggling, came to my window and asked me if I was ok. I rolled down my window and he noticed the smell of exhaust inside my truck. After my headache went away. I went to the dealership and they told me both of my exhaust manifolds were cracked and that's how the exhaust was entering near the front cabin.
While driving down the highway the truck stalled and lost all power. After getting to the shoulder of the highway, the truck still had battery power and wanted to crank to start but acted like it wasn't getting gas. After calling around we determined thru a nissan service advisor that we should try filling the tank with gas, even though I was telling him it read between a quarter and half a tank. After putting in 5 gallons and turning the key and cranking it a few seconds, it started right up. It has done this at various times since this first occurrence and continues to vary. I now have to keep no less than half a tank of gas at all times or I will suddenly lose power and have to pull off. Nissan has a voluntary safety recall campaign 2005-2009 armada and titan fuel gauge inaccuracy, campaign id#r1010 & the federal safety agency#10v‑074, but say that it does not include my VIN. I have tried repeatedly to ask nissan how this safety campaign does not affect my vehicle if it too has the same problem, as I've been told its the fuel sending unit which is what this recall campaign covers.
My truck stopped one sunday I was sitting at the red light. I tried to start it but it wouldn't start so I called a tow truck and had it towed to the nissan dealership. On monday morning I get a call from the service department and they told me my truck was out of gas. I told them that I had a little bit over a quarter tank of gas in it. He told me that they would call me back after a complete check. They called back and told me that my truck needed a fuel sender unit and a fuel ring, I told them to go ahead and repair it. On tuesday I went and picked up my truck and they explained to me that my fuel leveling sensor shorted out. I paid a total of 515.88 plus 65.00 for towing on something that had a recall on it. I don't know if they knew it was under recall or not but I would like to find out if I paid for something that should have been covered under the recall. I have my receipts and it shows the dates of the incident came after the recall dates.
I was riding down i25 when my truck engine unexpectedly quit. At 75 MPH it was all I could do to change lanes and pull over to the median without causing an accident. The fuel gauge showed that I still had 1/4 tank of gas. I tried repeatedly to start the truck without success. After scratching my head for a while I called my son to bring me some gas. After adding gas the truck started up after a few turns of the ignition. Not knowing what the heck had happened I continued driving the truck. Unfortunately I ran out of gas again some week later, this time in a neighborhood where the speed issue was not quite as severe. Since that time I've ignored my fuel gauge and determined when to refuel by mileage. This is really aggravating because there is a recall on titan fuel senders for model year 2005. However nissan is telling me that my VIN is not covered by the recall.
Nissan replaced the ecu relay and front fan they installed a jumper fuse into the ipdm and now vehicle shuts down while driving now the vehicle wont even turn over. The battery was drained now charged when I turn the ignition I get zero response from the starter as if the ipdm was blown. The truck shut down while driving like 10 - 20 within a 5 mi trip to get back home.
While driving on freeway truck shut off. Gas tank read quarter of a tank but engine shut off-car was out of gas.
Tl* the contact owns a 2005 nissan titan. The contact stated that the fuel gauge malfunctioned and inaccurately displayed that fuel was in the vehicle when it was empty. The failure caused the vehicle to shut off because there was no fuel in the fuel tank. The vehicle was taken to the dealer for a diagnostic testing. The contact referenced the federal safety agency campaign id number 10v074000 (fuel system, other ); however, the VIN was not included in the recall. The manufacturer was notified of the failure. The approximate failure mileage was 68,000. ..updated 10/07/14
Was accelerating after coming to a stop at a stop sign. Got up to about 15 MPH when all of a sudden the engine died in the middle of traffic. Tried to restart but could not. Coasted into a side street. Fuel gauge indicated that the vehicle still had 1/8 of a tank of fuel. After putting in about a half of a gallon of gasoline was able to get to a gas station. Once truck was full it ran with no problem. A week later I ran the fuel down to the same amount (1/8) where the truck had died before. This time I had a spare gas can with me. The vehicle died again.
Tl* the contact owns a 2005 nissan titan. The contact stated that when driving at various speeds, the exhaust pipe could be heard shaking. The vehicle was taken to a dealer where a technician diagnosed that the exhaust manifold was cracked. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 30,000 and the current mileage was 115,000.
While driving with my family, my titan ran out of gas while the gauge showed 1/4 tank, stranding myself, my pregnant wife and 2yr old daughter in a dangerous area, and in the middle of a busy street. I had to get out and push the truck to a parking lot. I then walked two miles to get 2 gallons of gas, forced to leave my family with the stranded truck(my wife can't walk that far right now). I returned, put the 2 gallons in the tank and it started right up. I called the dealer, which gave me a lousy excuse as to why thousands of these trucks were recalled because of this same issue, except mine. They offered to give me a great deal. 600 dollars for the repair when the part costs $77. Then just last week the truck ran out of gas, this time on the freeway, nearly causing an accident with a semi truck, while showing almost 1/2 tank. Upon researching this issue, I have discovered that thousands of titan owners are having the same problem and not being covered under the recall. I contacted the bar and after their investigation, the dealer disclosed that all titans were made with the defective fuel level sensor, and that the dealer was replacing these parts every day, not covered by the recall. To sum it up, I spent good money for a truck that I thought would be a safe vehicle for myself and my family, which it is not. I'm very serious I was almost killed when it happened on the freeway. I have owned a lot of vehicles, and have never ever heard of such a safety issue that isn't addressed by recalls. Basically this truck is a death trap, it's only a matter of time until something tragic happens, all because nissan will not own up to their faulty parts. In fact they are very disrespectful, and unprofessional when talking to them about it. I will never purchase another nissan again, knowing how unsafe they are and the way they treat their loyal customers after a purchase. .... Updated 08/05/14 *bf *tr updated 08/18/2014
I ran out of gas even though the fuel gauge stated I had more than a 1/4 of a tank of fuel left. After researching and discovering the federal safety agency campaign id # 10v074000 many 2005 nissan titans have had the same problem as I encountered. I contacted a local dealership and discussed this with them. After giving them my VIN, they stated there was no recall on my 2005 nissan titan for false fuel gauge readings or other issues regarding the fuel system in my vehicle. "recalls are VIN specific and yours is not listed." well, there is an issue with my vehicle's fuel gauge as well. I would like information how to get my vehicle's VIN added to the list of malfunctioning fuel gauge issues and have it replaced by the dealer as a warranty item, as others have done. This is a huge safety issue as I was traveling on the highway at 75 MPH when without notice, I ran out of gas. When my vehicle ran out of gas I was unable to use my brakes, steering was difficult and if there was traffic ahead I would of surly crashed. Thank you
Tl* the contact owns a 2005 nissan titan. The contact stated the fuel gauge failed and displayed a quarter tank when the fuel tank was empty. The manufacturer stated the VIN was not included in the federal safety agency recall campaign number 10v074000 (fuel system, other). The vehicle was not repaired. The approximate failure mileage was 104,000. The current mileage was 105,320.
1st incident occurred during rush hour traffic. I was driving around 25mph when my titan started to stall and then came to a complete stop, was just about rear-end by delivery truck. I was stuck on the street in the middle of traffic for 2 hours before a tow truck was able to come tow truck. I had mechanic look it over and it came out that I had run out of gas, mechanic looked at fuel gauge and it was reading of tank but would not start. Once couple gallons were added truck started right up. Mechanic stated that fuel gauge is reading wrong, mechanic looked up to see if there was any recalls. There was a recall for the 2005 nissan titan for the fuel system not reading correctly. But dealer stated that my VIN number didn't fall into that recall. Mechanic stated it would be over $900 to fix. So I had to tell the mechanic not to fix it. Over the years, I have run out of gas about 3 more times due to the fuel gauge not reading correctly. Last time I ran out of gas my infant son was in truck and was just about side swiped from another vehicle at an intersection. I need to do what needs to be done to get my nissan titan added to this recall, I cannot afford to pay this to be fixed. Recall id #68299 ? Fuel system, other: storage:fuel gauge system.
Was given a case number [xxx], ext [xxx], was told by[xxx]to go back to the nissan dealership and have them perform a diagnostic on the fuel system. And then call her back with the results. I did this at a cost of $110.00 to me. When I call back at the number she had given me all my calls go to voice mail. No one has ever called me back from nissan. 1‑800‑647‑7261 information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Fuel gauge bouncing around going from a half a tank of gas to a quarter tank of gas. Call nissan dealership also company. They said there is no recall for the fuel sending unit. But I see on their website that there is.
Tl* the contact owns a 2005 nissan titan. The contact stated that he noticed that the fuel gauge was not providing an accurate reading. The vehicle was taken to the dealer for diagnosis. The technician was unable to diagnose the failure. There was a recall under the federal safety agency campaign number: 10v074000 (fuel system, other) that could have been related to the failure. The manufacturer was made aware of the failure and stated the vehicle was not included in the recall. The vehicle was not repaired. The approximate failure mileage was 150,000.
The spider gears in my rear differential sheared off, causing catastrophic failure of my rear end. This has been a huge problem with the nissan titans, and should be addressed.
Tl* the contact owns a 2005 nissan titan. The contact stated that when driving various speeds, the fuel gauge reading would fluctuate even though the fuel tank was empty. The failure recurred despite the actual fuel level. The vehicle was taken to an authorized dealer for diagnosis. There was a voluntary recall issued by the manufacturer that was related to the same defect. The contact's VIN was not included and the vehicle was not repaired. In addition, the air conditioning unit and heater would not circulate air properly through the vents when activated. There was also an abnormal clicking noise heard from the vehicle. There were also occasions when the air conditioner would independently shut off. The air conditioner blower motor was replaced by the dealer however, the failure recurred. The manufacturer was notified of the problem. The approximate failure mileage was unavailable.
Tl* the contact owns a 2005 nissan titan. The contact stated that the fuel gauge failed to register when the fuel tank was full or empty. The vehicle was taken to the dealer, where repairs were made under the federal safety agency campaign number 10v074000 (fuel system, other) however, the failure was not corrected. The manufacturer was made aware or the failure. The approximate failure mileage was 75,000 and the current mileage was 91,000. ...updated 07/22/13
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Nissan Titan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history