2015 Nova Bus LFS technical service bulletins
123 technical service bulletins and manufacturer communications cover the 2015 Nova Bus LFS.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Validation of the previous passenger seat back panel campaign.
- Potential presence of a gap may
- DEF GEN4 tank, tank head and sensor will no longer be available in service
- The Delco-Remy alternator is obsolete
- ECP radiator failures deemed to be due to overpressure events.
- DEF tank Head Unit GEN4 N8900882 is no longer available in service, it is replace by the new DEF tank Head...
- New lower shock mount available with an adapter plate better suited for the front and rear axle.
- Headlight Failure
- Radiator leaking coolant
- Radiator leaking coolant
- DEF level sensor failure
- ITS Box Shelves Loose
- Engine compartment junction block scheduled maintenance
- Information about the engine coolant
- Recommendations on the disinfection of vehicles as well as products and precautions to be taken.
- The elbow used on the CAC pipes too short and found a leakage, decided to use the double clamp, it was...
- Passengers seat back cracked inspection
- Passengers Seat Back Cracked
- New style CNG Spheros is not fit, form and function as compared to the old heater.
- Vertical beam might crack above front door, second post capping
- Drag links found loose after 35 to 45000 ml. Replace drag links.
- Introduction of a new steering gearbox without the lubrication zerk.
- TRW has eliminated from service procedure TAS-103 the greasing of the steering gearbox output shaft.
- Radiator Canopy Panel Hardware Loose
- Bad torque sequence and engine rail flatness out of tolerance at fuel tank mounts created preload in the...
- Engine door Hinge becoming loose
- When Fast idle is active the engine parameter prevents the engine from doing an active regeneration.
- Seat back panel
- CAN Layer Resets
- Cummins code 3568
- Belt Guard Beam Failure
- Engine Fan Connector hot
- Splash Cover NYCT L841 to 845
- Rear axle failure NYCT Inspection Request
- Addition of strain relief bracket to secure regulator connections against vibration
- The repair kit parts will require a specific installation procedure
- Critical low coolant level sensor N84555 may under certain conditions
- Splash cover for Sika bead
- ITS box rail locks are breaking
- NOx sensor failing Codes 3446 and 3649
- VBEA Reprogramming for Battery replacement due to low voltage
- Plastic fitting for PEX affected by oil leaking from transmission cooler
- Sika Seams are Cracking, Strip Solution will be introduced in service.
- Replace the affected Signal and Ground wires by New kit of Kidde.
- To avoid the risk of air being trapped which could damage the EGR cooler.
- Brake wear signal reads 0% or fluctuates
- A new air dryer inspection procedure will be added to the maintenance and preventive maintenance manual...
- Canopy door latch might need to be retightened.
- A new option is available to ease the removal of the Thermo King AC unit evaporator on CNG vehicles.
- Cummins code 1242 for accelerator sensors circuit
- Plastic stopper strips can detached from the canopy doors.
- Latch adjustment for the the proper operation of the destination sign doors.
- Original valve is discontinued
- Latch adjustment for the proper operation of the destination sign doors
- The structural integrity of the plastic PEX fittings may be affected if coated with liquid and/or...
- Oil filler tube part number superceeded by improved tube
- This is a product improvement campaign that is being issued to recaliberate the ECM and upfit with...
- Subject to application and duty cycle, DEF dosing valve can clog up and
- Possibility of engine derating, stalling and losing of power
- Dust intrusion in baselights area through the structure vertical tubes.
- Low coolant level sensor warning
- Interlock brake is activated when the B-bus network is disconnected or lost.
- Articulation hydraulic cylinder pin is required to be maintained at W2 (60,000mi,100,000Km) maintenance of...
- Dust cap from PRD vent pipe of rear regulator on CNG units may pull off
- Impact on the driver's road side mirror may damage the gelcoat panel.
- Heat from a drain on the exhaust may damage the rear left corner panel.
- Improved solution to secure Radiator Canopy Panel hardware
- Heat from a drain on the exhaust may damage the rear left corner panel
- Interlock brake is activated when the B-bus network is disconnected or lost
- Flexible bellows N79197 may have an exhaust leak near the rigid exhaust pipe
- Engine derating, stalling, and loss of power may occur as a result of code 3568
- Vertical beam might crack above front door, second post capping.
- When the accelerator is suddenly depressed, the alternator voltage momentarily surge well above 32V...
- Presence of air bubbles in graphics stickers
- This communication is a letter of information concerning a fault that may appear on the actia gauge if an...
- There is a possibility of battery cable (+ve) chaffing against sharp bracket supporting the ground cable.
- There is a possibility of battery cable (+ve) chaffing against sharp bracket supporting the ground cable.
- Heating valve N47416 is obsolete.replacement of valve N47416 by the new N8903252, which is shorter,...
- Cummins coolant sensors equipped with the epc connectors fail in service due to water infiltration."
- Introducing new hardware and installation procedure for pitman arm
- Incompatibility of actia gauge programs a fault may appear on the actia gauge if an incorrect program...
- Introduction of nord-lock washers to front engine mount bolts with new torque specification for improved...
- Introduction of nord-lock washers to front engine mount bolts with new torque specification for improved...
- Cummins coolant sensors equipped with the EPC connectors fail in service due to water infiltration.
- Introducing new hardware and installation procedure for Pitman arm
- Incompatibility of Actia gauge programs A fault may appear on the Actia gauge if an incorrect program...
- No access to suspend #6 lifter
- The wiper motor cannot be stopped by the driver.
- Introduction of nord-lock washers to front engine mount bolts with new torque specification for improvised...
- Cummins code 1242 for accelerator sensors circuit, replace the throttle pedal sensors cable.
- This communication is a service bulletin concerning the front camera under the destination sign that may...
- Flexible bellows N79197 may have an exhaust leak near the rigid exhaust pipe
- Cng fuel line that runs to the spheros aux heater unit may come into contact with the engine cradle and...
- Cummins code 1242 for accelerator sensors circuit
- This letter is to inform that CR3670E replaces CR3492ER3 for L573, L640, L671, L727, L787 and L902.
- This communication is a letter of information to highlight the erroneous "dvr not operational" and "roll...
- Introducing new hardware and installation procedure for pitman arm.
- Auxiliary heater intake pipe mounting bracket might not be able to withstand the vibration induced by the...
- Auxiliary heater intake pipe mounting bracket might not be able to withstand the vibration induced by the...
- Wheelhouse kick-plates may come loose.
- Unable to perform stationary regeneration.
- This campaign is being issued to highlight the modifi ed routing of power and ground wires inside the mcc...
- This campaign is being issued to highlight the modifi ed routing of power and ground
- Unable to perform stationary regeneration.
- Destination sign oscp software may freeze
- Starter motor defect impacts only canadian vehicles, reconducted in this list because it was in the first...
- Interference between external oil filter and fuse bracket holder
- Introducing new hardware and installation procedure for Pitman arm
- This Campaign is being issued to address actuator failures for ISB6.7 and ISL CM2350 Cummins Engines in...
- The engine air intake hose could rub against the air conditioning compressor components
- Moisture may accumulate in the space under the driver's seat and
- Niehoff alternator bolts and rubber air intake elbow
- Installation of a TPMS smartire connector in the RF2 panel make it possible to download data from the...
- A new radius rod bolt torque is now in effect.
- Coolant filter additive free N71764 installed in production since august 2013
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Nova Bus LFS?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history