2016 Nova Bus LFS technical service bulletins
160 technical service bulletins and manufacturer communications cover the 2016 Nova Bus LFS.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Improved durability of engine-side heat exchanger hoses.
- Validation of the previous passenger seat back panel campaign.
- Potential presence of a gap may
- Failure of DEF sensor GEN 6 within the expected 5-years lifespan.
- DEF GEN4 tank, tank head and sensor will no longer be available in service
- The Delco-Remy alternator is obsolete
- ECP radiator failures deemed to be due to overpressure events.
- DEF tank Head Unit GEN4
- DEF tank Head Unit GEN4 N8900882 is no longer available in service, it is replace by the new DEF tank Head...
- New lower shock mount available with an adapter plate better suited for the front and rear axle.
- Headlight Failure
- Radiator leaking coolant
- Cummins has issued a Temporary Repair Practice: TRP2484 â ECM Calibration for DEF Header Sensor Failures...
- Radiator leaking coolant
- Engine could crank when fuel door is open
- Emergency Engine Stop Override switch on the Operator's Control Panel is missing.
- DEF level sensor failure
- ITS Box Shelves Loose
- Engine compartment junction block scheduled maintenance
- The original production CAC silicone elbow used on the CAC pipe may leak due to insufficient length
- Hydraulic Level Sensor Defective, failures or intermittent Low hydraulic light coming on in service
- Information about the engine coolant
- Recommendations on the disinfection of vehicles as well as products and precautions to be taken.
- The elbow used on the CAC pipes too short and found a leakage, decided to use the double clamp, it was...
- Hydraulic level sensor defective
- Passengers seat back cracked inspection
- Passengers Seat Back Cracked
- High ambient temperature on exhaust side (after-treatment area) may
- New style CNG Spheros is not fit, form and function as compared to the old heater.
- Auxiliary heater Thermo 300 is discontinued
- Vertical beam might crack above front door, second post capping
- Drag links found loose after 35 to 45000 ml. Replace drag links.
- Failures or intermittent Low hydraulic light coming on in service
- Under certain condition (high temperature in southern state) combine with the engine compartment high...
- Floor damage around the drive shaft access panel
- Introduction of a new steering gearbox without the lubrication zerk.
- TRW has eliminated from service procedure TAS-103 the greasing of the steering gearbox output shaft.
- Wheel chair access ramp does not operate under the actual VBEA program.
- Radiator Canopy Panel Hardware Loose
- Bike Rack Icon not working correctly
- Delco 450 Amp Alternator internal failure
- Body corner panel shows cracks
- Whenever experiencing multiple random transmission fault codes, it is advisable to inspect the N40216...
- Tow eye plugs stuck
- Bad torque sequence and engine rail flatness out of tolerance at fuel tank mounts created preload in the...
- Engine door Hinge becoming loose
- ITS Box Shelves Won't Lock
- When Fast idle is active the engine parameter prevents the engine from doing an active regeneration.
- A new part kit and work procedure is required to replace the auxiliary heater filter N12950 since the...
- Niehoff alternator regulator connections failing off CTA
- CNG Turbo Failure
- Seats rail failure San Antonio Texas
- Seat back panel
- CAN Layer Resets
- Cummins code 3568
- HVAC discharge pipe insulation melting
- Belt Guard Beam Failure
- Niehoff alternator regulator connections failing off
- Engine Fan Connector hot
- Seats rail floor failure San Antonio Texas
- Splash Cover NYCT L841 to 845
- Availability of a dust protection kit to remove the maintenance need to clean the flame sensor sight glass...
- Sight glass for the flame detector could become dirty leading the heater to lock out
- ITS box rail locks are breaking
- Watch Your Step Decal Peeling
- Rear axle failure NYCT Inspection Request
- Seats rail failure San Antonio Texas
- Middle coolant sensor replace by a resistor
- Cummins code 1242 for throttle pedal sensor circuit
- Addition of strain relief bracket to secure regulator connections against vibration
- The repair kit parts will require a specific installation procedure
- Splash cover for Sika bead
- Lateral console nameplate cracking Houston Top Nameplate
- Ramp pump assembly with aluminum reservoir cracking
- Heat exchanger hose leaking
- Destination Sign Curtains Falling
- Compartment Door Corrosion
- Paint peeling on all panels made of N64030-28
- Improper collar installation may
- AC drain tube kazoo/check valve missing
- Driver Defrost Not Working with High Fan Speed
- Paint peeling occur on skirt panels and other exterior trim components
- Driver Partition Legend decal is cracking
- VBEA Reprogramming for Battery replacement due to low voltage
- Exhaust Pipe Clamp Loose
- Infotainment ethernet cables wrong connector
- Plastic fitting for PEX affected by oil leaking from transmission cooler
- Sika Seams are Cracking, Strip Solution will be introduced in service.
- Replace the affected Signal and Ground wires by New kit of Kidde.
- To avoid the risk of air being trapped which could damage the EGR cooler.
- Firmware update to increase the coils lifespan by improving its control.
- Brake wear signal reads 0% or fluctuates
- A new air dryer inspection procedure will be added to the maintenance and preventive maintenance manual...
- Canopy door latch might need to be retightened.
- A new option is available to ease the removal of the Thermo King AC unit evaporator on CNG vehicles.
- Cummins code 1242 for accelerator sensors circuit
- Plastic stopper strips can detached from the canopy doors.
- Latch adjustment for the the proper operation of the destination sign doors.
- Original valve is discontinued
- Latch adjustment for the proper operation of the destination sign doors
- The structural integrity of the plastic PEX fittings may be affected if coated with liquid and/or...
- Inner slotted nuts may mislocate the wheel bearing assembly.
- Oil filler tube part number superceeded by improved tube
- Subject to application and duty cycle, DEF dosing valve can clog up and
- Dust hides safety decals on hybrid electric units
- Possibility of engine derating, stalling and losing of power
- Dust intrusion in baselights area through the structure vertical tubes.
- Accumulator solenoid failure resulting in air leakage.
- Low coolant level sensor warning
- Interlock brake is activated when the B-bus network is disconnected or lost.
- Articulation hydraulic cylinder pin is required to be maintained at W2 (60,000mi,100,000Km) maintenance of...
- Dust cap from PRD vent pipe of rear regulator on CNG units may pull off
- Heat from a drain on the exhaust may damage the rear left corner panel.
- Improved solution to secure Radiator Canopy Panel hardware
- Heat from a drain on the exhaust may damage the rear left corner panel
- Interlock brake is activated when the B-bus network is disconnected or lost
- Flexible bellows N79197 may have an exhaust leak near the rigid exhaust pipe
- Valves balancing braking power needs to be updated to meet customer specifications.
- Engine derating, stalling, and loss of power may occur as a result of code 3568
- Dust intrusion in baselights area through the structure vertical tubes (40' bus)
- When the accelerator is suddenly depressed, the alternator voltage momentarily surge well above 32V...
- Articulation ACU and solenoid Justify Articulation solenoid circuit may
- Cummins coolant sensors equipped with the epc connectors fail in service due to water infiltration."
- Introduction of nord-lock washers to front engine mount bolts with new torque specification for improved...
- Introduction of nord-lock washers to front engine mount bolts with new torque specification for improved...
- Cummins coolant sensors equipped with the EPC connectors fail in service due to water infiltration.
- No access to suspend #6 lifter
- The wiper motor cannot be stopped by the driver.
- Introduction of nord-lock washers to front engine mount bolts with new torque specification for improvised...
- Cummins code 1242 for accelerator sensors circuit, replace the throttle pedal sensors cable.
- This communication is a service bulletin concerning the front camera under the destination sign that may...
- Cng fuel line that runs to the spheros aux heater unit may come into contact with the engine cradle and...
- Cummins code 1242 for accelerator sensors circuit
- This communication is a letter of information to highlight the erroneous "dvr not operational" and "roll...
- Auxiliary heater intake pipe mounting bracket might not be able to withstand the vibration induced by the...
- Auxiliary heater intake pipe mounting bracket might not be able to withstand the vibration induced by the...
- Unable to perform stationary regeneration.
- Unable to perform stationary regeneration.
- Regeneration system on hybrid articulated vehicles
- A new radius rod bolt torque is now in effect.
- Coolant filter additive free N71764 installed in production since august 2013
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Nova Bus LFS?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history