2022 Nova Bus LFS technical service bulletins
59 technical service bulletins and manufacturer communications cover the 2022 Nova Bus LFS.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The rear door operator is missing one bolt and washer.
- The HVAC generator engine pulley has bolts that are too long.
- One fire suppression system pipe may be installed backwards and interfere with an alternator cable,...
- Rear Door Electrical Operator
- Water Sensor in E-Steering Compartment.
- Restricted access to the Modular Propulsion Control System (MPCS) makes decommissioning difficult and...
- Battery Unbalanced Light Logic with AGM Battery.
- The Driver’s Barrier stationary glass is breaking in service due to possible metal to glass contact on the...
- Headlight bezel adjustment screw may interfere with HIVIS frame.
- The Cabin Coolant Level Sensors for the LOW and HIGH levels are swapped.
- Battery door slam latch, due to a shortage, N620000263 was installed as an alternative to temporarily...
- LED strip (N105390) was installed without seals in the plug.
- P-clamps holding the transmission coolant pipes can break.
- Oil level creating different issues, Cummins recommendation following few parts issues.
- Buses logging cabin and engine coolant pressure codes as reported by Clever Device.
- The ground of the IVN unit (Intelligent Vehicle Network) could be connected to the wrong place.
- Oil level creating different issues in service
- Fuse holder for the electric cooling fans require an improve protection against road debris.
- The Driver’s Barrier stationary glass is breaking in service due to possible metal to glass contact on the...
- Driver barrier door stanchion hardware loose, missing, or broken.
- The EGR cooling hose N95062-48 is not rated for the engine compartment temperature
- Flag Terminal Hole is too Large for Terminal Stud.
- Consat programation was not completed.
- Communication System Cavity plugs missing in 2 Ethernet switches.
- The WHA11 harness has a potential chafing issue.
- Upper door shaft nut may get loose.
- Lower door shaft nut may get loose.
- Reverse signal triggering stop request announcement
- Battery tray arm may have loose hardware.
- Rework allied motion e-Steering motor
- Introduction of headlight N109645 to replace N71373
- Driver's barrier door has an improper fit
- Erroneous Fault Codes reporting on the AVM System of Clever Devices.
- A bad connection at the ZF transmission connector may
- Wheel Chair Ramp Missing two P-clamps and a grommet.
- Mirror flasher signal is connected to the wrong output
- Brake and Accelerator Pedals
- Brass fitting (N79131) leaks found at BL2 and BL4 two-way valve, repairs were performed not per AVT0029.
- Battery tray may crack, new battery hold down required.
- There is a potential restriction of fluid due to an improperly placed clamp which could
- Power steering lines chaffing the rear shell.
- The supplier Lift-U recommends the addition of a detection delay to prevent wrong fault code in the AVM.
- Fire light coming on in the dash, Fire detection system.
- Fire light coming on in the dash, Fire detection system
- The Back-Up Run 24C was energizing the Run 24C Relay when MC43 was off and this was causing BAE Fault Codes
- Loose fuel tank due to improperly torqued hardware and missing hardware.
- American seating lower bracket hardware missing
- Wheelchair ramp deploy switch hardware loose.
- The NCP-2 corrosion preventative product has better performance than Maxi-coat
- Hardware fixing the steering gear box mounting plate may have been installed with an insufficient torque
- Hardware fixing the steering gear box mounting plate may have been installed with an insufficient torque.
- Installed headlights do not have heated lens.
- Leveling valve N92260 found out of adjustment
- Fire light coming on in the dash
- To eliminate the possibility of an operator becoming injured by the sharp edges on the shield center display
- On the Thermo King HVAC roof unit, after replacing the actuator N8897109, some customers could see the...
- HVAC deflectors are breaking at the folded attachment points
- Parker Screen Software Update
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Nova Bus LFS?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history