1991 Plymouth Grand Voyager fuel system problems

Filed Oct 26, 2011 · Fuel system · 155,000 miles · IL

Tl* the contact owns a 1991 plymouth grand voyager le. The contact stated that there was a leak in the fuel rail. The vehicle was taken to a local mechanic for routine maintenance where they discovered the fuel leak. The manufacturer was notified of the failure who advised that the vehicle was too old for them to provide any assistance. The failure mileage was 155,000.

Filed May 22, 2006 · Fuel system · 79,000 miles · PA

Dt*: the contact stated there was a strong odor of gasoline present in the vehicle. The vehicle was inspected by an independent repair shop. The mechanic determined the fuel rails were leaking. Although the problem persisted, the fuel rails were not replaced. There is a the federal safety agency recall # 98v130000 regarding the fuel system. The VIN was not included in the recall.

Filed Oct 25, 2005 · Engine, Fuel system · OH

My 1991 plymouth grand voyager has had so many problems. I have had to replace the whole exhaust system, the transmission, put in a new fuel pump, a new radiator, now it failed an emissions test and I was smelling fuel when I was driving only to find out my fuel rail is leaking or should I say squirting as onto the engine, which almost resulted in a fire had I had been smart enough to check it out. Now the shop where I had to have it towed since it was unsafe to drive says you can only get the part from a dealer which costs 319.00 and that does not include labor.

Filed Dec 22, 2003 · Fuel system · SC · fire

The fuel rail located on the fuel injection system was leaking gas onto the engine manifold, resulting in a fire. The fire was extinguished by consumer.

Filed Dec 19, 2003 · Fuel system · 140,000 miles · WA

While traveling on the highway and without prior warning fuel smell was coming though the vents. Independent mechanic found that fuel rail was leaking gasoline.

Filed Dec 19, 2003 · Fuel system · 140,000 miles · WA

While traveling on the highway and without prior warning fuel smell was coming though the vents. Independent mechanic found that fuel rail was leaking gasoline.

Filed Feb 7, 2002 · Fuel system · NE

Fuel smell in side vehicle. Soon after consumer serviced vehicle, and noticed fuel injection rail two seals were leaking fuel. Dealer has been notified. Please provide further information.

Filed May 3, 2000 · Fuel system · IA

While driving the gas gauge went down to empty. Then consumer was driving again on a very busy intersection and vehicle just stopped dead in tracks. Consumer tried to start vehicle, but it kept cutting off.took to dealer, and they said it was the fuel pump that needed to be replaced.

Filed Dec 1, 1999 · Fuel system · WA

Started smelling gas fumes inside van. Took it next day to shop where they showed me dripping gas from the "fuel rail" of the injector system. It was drippiing onto the engine and could've started a fire at any time. On the u shaped part its at the 90 d.

Filed Oct 14, 1999 · Body, Fuel system · TX

While driving to school could smell gasoline. Checked under the hood and noticed gas had been shooting from the fuel rail. Vehicle was leaking continuously. Also, power locks went on and off/speedometer went to zero/gas gauge read tank empty while it was full, and windshield wipers came on and off.