1996 Plymouth Grand Voyager body problems

Filed Sep 22, 2009 · Body, Suspension · 100,000 miles · NY

Rusted strut towers on 1996 plymouth grand voyager front strut popped through almost crashed other complaint number found on internet probably a lot more 10090457.

Filed Oct 15, 2004 · Body · OH

Severly rusted strut tower on my 1996 plymoth grand voyager. After investigating the problem, I have found that numerous complaints have been filed. There was a recall on the 1998 and 2000 grand voyagers with the same exact problem. Estimated repair $4500.00.

Filed Jan 15, 2004 · Body, Engine · 114,991 miles · MI

Above are our major problems we recently had with our van. The most serious one that has to do with safety is the body work done to the left side strut tower due to rust - which also included the repair of the suspension. I reported this to daimlerchrysler under concern#11568602 asking them for financial assistance but they refused. We also had a transmission failure and air condion failure; howerver, these were fixed with no charge due warranty (below 100,000 miles), but the air conditioning failed again as noted above. Regarding other costs: these were for the front sway bar bushings and outer tie rod ends. I purhased this 1996 van in 11/12/1998 with an odometer reading of 53,841 miles.

Filed Jan 15, 2004 · Body, Engine · 600 miles · NY

Transmission pump, is out now, speckled paint on hood and top, sides, back, vibration in front end steering, loud noises, creaks and makes lots of noises, back door on right side will not lock or unlock. I need help with all of these problems. The items repaired was by a friend mechanic.

Filed Jun 23, 2003 · Body, Transmission · 89,000 miles · KY

While driving down the interstate doing about 70 MPH I heard a loud noise. Looked at speedometer and it registered 0. I had no power. Barely managed to get van off the road. Got out and looked under it, there was transmission fluid everywhere. Had it checked out by personal mechanic. He then told me that there have been numerous complaints about this year of plymouth grand voyagers. I only have 86,000 miles on it. Also the sliding door locks have failed, windshield washers have failed, A/C has failed, not to mention the airbag light, fuel line and all of the numerous other recalls it has had on it.

Filed Dec 24, 2002 · Body, Electrical · 60,000 miles · AZ

Sub frame of van has cracked causing severe vibration. All motor mounts failed. My 1990 had similar problem. Van is barley drivable and unsaleable. Throw in two complete AC systems, two multi-function switches(looks like #3 is linings up), a clockspring(recall) and top it off with horrible service. Loyalty should be a twp way street!! Ts

Filed Dec 2, 2002 · Body · 150,000 miles · MD

Consumer stated the same defect regarding liftgate recall 99 v 213 happened with his vehicle, however vehicle was not included because of the year. Ts consumer heard a loud noise as if something had hit the right rear tire, consumer discovered the liftgate support was dangling, the bolt attaching the support to the vehicle had broken off. *jg

Filed Jul 1, 2002 · Body, Electrical · VA

Lights flash,bells chime,door locks activate repeatedly, dash gauges go dead very distracting and scary for my wife.

Filed Apr 8, 2002 · Body, Electrical · OR

Door lock failures: repeated failures required new mechanisms, also affected the fuel tank door. Transmission failure: occurred in parking lot fortunately. Required $2200 in repair. Dealer (hershberger motors in woodburn, or) failed to correctly seal the transmission. When returned to dealer for this, they broke the right bearing hub, another $400 to repair. Body control module failure: wipers stopped working - an absolute necessity in oregon! Bcm repaired by sending out existing unit by dealer (town & country chrysler, milwaukie, or). Did not correct problem ($450 repair costs). Presently in for correcitve action. Signed - unhappy customer.

Filed Mar 12, 2002 · Body · PA

Sliding door on passenger's side feels tight on track. But when closing and driving it rattles/ shakes and sounds like it's going to come off. Vehicle has been in 3-4 times to be checked, and nothing could be found wrong. The dealer was notified.