1997 Plymouth Voyager technical service bulletins
140 technical service bulletins and manufacturer communications cover the 1997 Plymouth Voyager.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Charging System, Battery Diagnostic Tools and Warranty
- Repair Parts Used For Structural Repairs
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- Valve Body
- Snow/water ingestion into rear brake drum
- Snow/water ingestion into rear brake drum
- Pop/tick sound in steering wheel area
- Cosmetic corrosion or perforation at upper strut tower/s usually between the strut and upper load path...
- Snow/water ingestion into rear brake drum
- Concerns with the air bag warning indicator lamp on intermittently or constantly
- Flash programming failure recovery
- Subject regarding outside rearview mirror glass replacement
- Experiencing a pop/tick sound heard coming from the steering wheel area while the vehicle is in motion
- Subject regarding transmission oil cooler line hose clamp service
- Subject regarding camshaft / bearing service
- Subject regarding outside rearview mirror glass replacement
- Experiencing a squawk / creak / groan sound from front suspension while driving over rough / bumpy roads
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty
- Subject regarding generic scan tool (GST), publication no
- A condition may exist where a low frequency howl / moan noise is heard from the rear brake area during low...
- On some vehicles, while driving through deep or blowing snow / water, the snow / water may enter the rear...
- This bulletin involves installation of a new component to assist cam seal retention
- Subject regarding wire splice repairs
- Subject regarding outside mirror glass replacement
- Information on service publication updates
- Subject regarding child seat tether anchors
- Experiencing a chatter sound coming from the sliding door power lock actuator(s) when the power lock...
- Subject regarding non-deployed airbag handling procedures
- A condition exist where the roof panel surface exhibits waviness or depression(s) near the front of the...
- This bulletin contains procecures to remove waviness or depressions from the roof panel surface
- This bulletin provides a revised wire splice procedure and related parts
- A condition where a click / rattle sound may be heard coming from the area of the steering wheel while the...
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes P1494, P0442...
- Concerns with the pcv valve freezing under extremely cold conditions
- Information regarding snow / water entering the rear brake drums
- Vehicle operator may complain of poor AM radio reception
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles
- Information on rear wheel park brake actuator / lever service
- Subject on the child seat tether anchors
- Technical service bulletin regarding multi-layer steel (MLS) head gasket installation procedures
- Information regarding the ignition switch housing service
- This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket
- Information on child seat tether anchors
- Concerns with speed control which does not maintain set speed while climbing a grade
- This bulletin explains the operation and application of the leak detection pump (LDP) monitor test
- Experiencing tick type noise at top of left b-pillar
- Concerns with serpentine belt slipping off idler pulley
- Subject pertaining to smooth road high-speed vibration or shake condition
- Customer may complain of low speed tire wobble
- Conditions with intermittent loss of speed control
- Subject regarding reusable automatic transmission oil pan gasket
- Concerns with sags / hesitation / stumble / start & stall, a/c bump improvements, addition of leak...
- Service and parts information on 1999 running changes to transmission range sensor (TRS) tt
- Concerns with front and / or sliding door power lock motors making a whirling noise
- Subject pertaining to a ticking type noise at top of left b-pillar
- Subject regarding airbag on - off switches
- Subject regarding oil seepage at cam position sensor / misinterpreted head gasket leak
- Windnoise around fron door glass, especially at top of the b pillar
- Some vehicles may exhibit a condition where the powertrain control module (PCM) resets while the customers...
- Vehicle experiencing a ticking noise while at idle from engine
- A new multi-layer steel ( mls ) head gasket has been developed and is being implemented into production...
- Subject regarding i/m ( inspection maintenance ) testing - OBD II "carb" readiness monitor information
- Right side half shaft cv boot is made of a special high temperature resistant material that CAN show heavy...
- Subject on flash programming failure recovery
- Subject regarding the airbag on-off switches
- A "honk" or squeal noise during parking lot maneuvers
- Rattle noise from rear of the vehicle when driving over road bumps
- Exhibiting a moaning and groaning sound accociated with a/c compressor operation
- Front windshield wipers self-activate while driving or will not turn off
- Subject regarding a/c suction and / or discharge line requires replacement due to cracking at or near...
- Windshield wipers self-actuate while driving or will not turn off
- Symptoms with roof rack rattles at highway speeds
- Subject on labor operation time change for domestic 2.OL dohc and 2.4L head gasket replacement
- Information on body control module (BCM) replacement
- During low speed vehicle experiences side to side oscillation/wobble while driving between 10-45MPH
- Subject on delayed transaxle engagement
- Some vehicles may experience a bump feeling during a/c compressor engagement
- Information on installation of radio transmitting equipment
- Subject on tip-in sags/hesitations or rough idle after a hot soak restart
- Information on gasket surface preparation on aluminum engine components
- This bulletin involves intermittent popping on front end
- Creak sound heard upon acceleration and/or deceleration- sound seems to come from floorpan/dash area
- Concerns with "honk" noise during parking lot maneuvers
- Test
- Vehicle may experience remote keyless entry transmitter batteries discharge prematurely
- This bulletin involves transaxle kickdown, linkage wears the wiring harness
- Information on poor drivability with high di (drivability index) fuel
- Concerns of thumping noise from the rear jounce bumpers when driving over small bumps after the vehicle...
- Concerns with thumping noise at rear of vehicle during cold operation
- Exhibiting a periodic bump in power train when the a/c is operating
- Some vehicles experience a momentary loss of power assist for the steering when turning corners with the...
- The cd player may become inoperative, and will not accept the cd when attempting to insert the disk into...
- Vehicle may expereience inoperative cd player sales code raz radio
- Authorized airbag deactivation for medical necessity
- INFORMATION REGARDING the federal safety agency AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. NLM
- Water leaks onto the passenger side floor from the HVAC housing
- Concern with water leak onto the passenger side floor from the HVAC housing
- Information on no start diagnostic cam/crank sensor $01 and $28. nlm
- Concerns with cd player not accepting cd when attempting to insert the disk into the radio
- Concerns with a/c evaporator odor
- Child safety seat video and harness clips for minivans equipped with integrated child seats
- A/c suction and/or discharge line service
- Windshield wipers do not park properly and/or wipe in the intermittent mode properly
- This bulletin involves transmission fluid auxiliary cooler
- Information on tire and wheel runout
- Front HVAC blower motor resistor connector service
- Exhibiting a periodic ''bump'' in power train when the a/c is operating
- Information on 41TE/42LE service information
- Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of...
- Concerns with engine coolant usage
- Concerns with high effort required to u nlatch rear bench seats from the floor
- Information on leak detection pump (LDP) dealer test mode
- 2.4L crankshaft/camshaft timing
- Condition with underhood noise due to serpentine belt outboard ribs fraying or splitting from the main...
- Concerns with serpentine belt coming off or outboard ribs of belt are frayed
- Some vehicles may experience a rattle in the area of the rear wheels caused by the parking brake actuator...
- Concerns with brake actuator lever rattle (all wheel drive)
- Coolant seepage at underbody auxillary rear heater line hose connection
- 35 mph cyclic vibration
- This bulletin involves sliding door poor fit - low at rear
- Condition with tranaxle shudder during a 3RD gear to 3RD gear partial emcc ( electronically modulated...
- Concerns with 41TE/42LE transaxle shudder during an emcc (electronically modulated converter clutch) shift
- Information on all wheel drive (AWD) system seal replacement
- This bulletin involves vibration/drone at all vehicle speeds and/or slight jerk during initial...
- Air bag warning labels
- Difficult to clean light colored "chalky" residue from plastic body components that are molded in black
- Rear brake cyclic rubbing noise
- Rear brake moan/howl noise
- Vehicles with 3.0L engines - intake valve deposits - driveway die out, rough idle, lack of power, sags or...
- Vehicles built on or after nov 6, 1996 (mdh 1106XX) have two 1/4IN foam pads attached to the top of the...
- Erroneous MIL illumination with hex code $29, $2A, $2B, erroneous PCM resets, displayed fuel economy...
- During high humidity climate conditions, some vehicles may experience a momentary loss of power assist for...
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Plymouth Voyager?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history