Plymouth Voyager power steering loss problems

Filed Sep 11, 2013 · Steering · 160,000 miles · OR

Tl* the contact owns a 1992 plymouth voyager. The contact stated while driving approximately 45 MPH there was a loss of power steering without any warning. The steering wheel became extremely difficult to maneuver. The failure occurred intermittently. The vehicle was not repaired nor was the failure diagnosed. The manufacturer was not notified of the defect. The approximate failure mileage was 160,000.

Filed Dec 29, 2012 · Steering · 133,000 miles · MN

Losing power steering from bumpy roads and during bad weather. This happened three times within a 30 day period... ...first, while changing lanes in city I noticed that the power steering was hard when I made a right turn, had to keep going with traffic, when I made the second right turn I realized that the steering was out...parked at destination...when I came out noticed something hanging under the van, upon further inspection I found out that it was a belt hanging but it was not broken...when the tow arrived he stated the power steering belt came off...at the auto shop he checked all pulleys and replaced the belt as he said it looked to be new still...I was on my way, no problem... ...second, while raining we went a good distance, 2 hour drive, returned and when parking noticed the hard steering, looked and yes belt off, since we knew what it was brother put back on... ...third, on the I-90/94 expressway in the snow, after stopping for gas about 15 mins on expressway steering got hard again, I rode trying to get to exit to stop, car began to reeve when I went over 40mph...finally car began to give out, all lights started blinking, motor just stopped...pulled over under a bridge called 911 they sent tow...at the shop he said belt came off probably when I went over snow at gas station (dec. 20, 2012 blizzard in wisconsin at this time)...all pulleys looked fine, he put belt back on...I rode straight 4 hours without stopping for fear this might happen again and it was getting cold and darker outdoors...finally at home to scared to drive any distance......will have it looked at beginning of new year 2013... ...would really like to know why this is not a recall when the steering can go out at anytime...this is very dangerous, especially for those of us that travel on expressways often...12.29.2012 [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).

Filed Feb 23, 2012 · Steering · 185,000 miles · MD

Drove through a puddle. Serpentine belt fell off, causing loss of power steering. Completed repair as per tsb 07-02-99. Did not correct issue. A known issue with 1996 - 2000 plymouth/dodge caravans 3.3l and 3.8l. Very dangerous, happens on wet/snow conditions. Bottom third of harmnic balancer is not guarded from road moisture. Chrysler redesigned in 2001. Gates after market kit solves problem gat 38379k, cost $120-$220 with out labor. Does this meet the criteria for a recall?

Filed Dec 22, 2011 · Engine · 119,000 miles · TX

The belt slips off in the rain causing power failure to everything running off the belt. No power steering, no cooling system, no electrical charging, no A/C, and I believe the brakes didn't work right.

Filed Nov 17, 2009 · Engine · 135,000 miles · GA

During a very heavy rain, I hit a big puddle which caused the serpentine belt to come off the pulleys. My mechanic said it is a common problem with this vehicle. The result is no power steering, no alternator to charge the battery and no water pump to cool the engine. I drove it until the temp gauge showed hot and then shut it down. No major damage resulted. Mechanic put belt back on for $15.00. 135k miles on vehicle and is very dependable.

Filed Nov 18, 2007 · Engine, Suspension · 116,250 miles · NY

I own a 1996 plymouth voyager and on this min van the wipers act very erratic. They work when they want. Sometimes they won't shut off and other times they will not come on at all or stop right in the middle of your view. I also have an issue with the serpentine belts popping off the drive line leaving you with no power steering or power brakes and completely disables the vehicle. I also experience issues with the rear shocks. The bolts come loose and detaches the rear shick from the van leaving it quite uncontrollable while driving. All 3 issues happens on many occasions. All 4 of these defects make this van very dangerous to drive or travel with. Currently my van is sitting in my drive with a bad transmission. I have owned the van for 5 years now and in 5 years I have blown 3 transmissions.

Filed Aug 22, 2007 · Engine · PA

1999 plymouth grand voyager throws serpentine belt when driving through a puddle, resulting in loss of steering.

Filed Jul 20, 2007 · Engine · 75,000 miles · GA

Serpentine belt repeatedly comes off. Replacing idler pulley, tensioner pulley, and belt remedies the situation for 6 months or so. The problem is so prominent in other vehicles with the same engine that gates and goodyear sell a kit that will permanently fix chrysler's goof up. Failure results in loss of power steering and loss of battery charging. Vehicle continues to run until the battery dies.

Filed Jul 13, 2006 · Engine · 63,000 miles · OH

Dt*: the contact stated while driving through a residential area in rainy weather, there was a loss of steering without warning. The vehicle was pulled over and inspected. There was extreme heat present under the hood area. It was towed to an independent repair shop for further inspection. The mechanic determined the serpentine belt disengaged and contributed to the steering problem. The mechanic reinstalled the serpentine belt. The manufacturer was alerted.

Filed Nov 22, 2004 · Transmission · WV

Heard a loud blast, van went up in the air off the road. Touched back down on the road I was all over the road. Had no brake, no power steering and no park. *bf the transmission failed.