When driving at an undetermined speed, the check engine light appeared on the dashboard, then the vehicle stalled. Consumer had the vehicle towed to the dealership and the mechanic determined that the fuel pressure failed. *ak the radiator cap was replaced. While in motion, about 2 miles at 30 MPH, the check engine light had come on. The vehicle was returned to the mechanic. The next day the vehicle would not start. The dealer found that fuel leaked and ruptured the manifold. Recall#04v090000. The consumer was told that the recall was not in reference to her vehicle. *sc *jb the consumer sent in a thank you note after recieving her recall notice.
1998 Pontiac Bonneville fuel system complaints
Page 2 of 2: complaints 11 to 36 of 36, newest first, as owners wrote them.
The consumer was not satisfied with the amount of the reimbursement he received from the manufacturer. *nm the consumer experienced problems with the vehicle starting prior to receiving the recall. The manufacturer stated they only reimbursed the consumer the amount that pertained to the recall. Out of 834.60 for repairs the consumer received 97.92. Recall#04v090000.
Consumer received the federal safety agency recall 04v090000 regarding fuel pressure regulator failure. After having the fuel pressure regulator replaced vehicle failed to start. Also, while driving vehicle stalled.
Consumer heard a loud bang while driving on the highway. He proceeded off the highway, opened the hood of the vehicle, and fire started in the engine compartment, which engulfed into flames. Within seconds consumer called the fire department, who indicated that the fire started near the engine block. The fire occurred due to the defect described in the fuel pressure regulator, recall 04v090000. But after the factory representative inspected the vehicle he claimed that the fire was not caused by the defect. A fire report was filed.
Had tune-up and regulators changed (based on recall) on 7/19/04. Then on 7/22/04 smoke emitting from exhaust and then car would not start. Car towed and repaired (manifold cracked). On 7/26/04 car taken from shop, 2 hrs later car would not start again. This time claimed starter was the problem. Consequences: over $1,500 in repairs.
Request for reimbursement for intake manifold that ruptured twice. *mr fuel leaked into the plastic intake manifold. *sc there was a recall regarding the issue. Recall#04v090000.
General motors recall program denial of payment for recall item repaired nd paid for at a general motors pontiac dealership. Second recall notice recieved on my 1998 pontiac bonneville, the federal safety agency id# 04v090000, compontent is the fuel system, gasoline delivery. My 1998 bonneville was at the dealership many times and over a period of 2 years until the problem was resolved. Rental vehicles, costly not-needed repairs were done in an effort to find the problem, down time, etc. Payment from general motors requested providing all items requested, original receipts, signed forms and the reason given for the denial was that the vechicle identification number was not part of the recall. General motors mailed me the recall forms. My car did have the problem related to the recall.
1998 pontiac bonneville purchased with 214 miles on 10-05-2000 from powel watson motors in laredo, texas. The vehicle had problems from nov. 2000 to the repair date in 2002. A seperate dealership (tindall chev/pontiac in dilley, texas) was finally able to repair the problems with the fuel regulator. This recall item has be denied from pontiac. The dealership billed me $1,024.00 for repairs not including rental fees for the loaner car. I feel that pontiac should honor the reall and return my money to me due to the faulty delphi fuel pressure regulator.
Vehicle was operating under normal conditions, vehicle was purchased used. Two blocks from my destination, the car was running rough, almost like it was sputtering. I parked the car in the hopes it would start,the backfire that I never heard, not only broke the nose off the starter, blew a hole in the intake manifold and filled the engine with antifreeze. Luckily for me I had shut the car off before any major damage had been done to the engine. I had the car towed back to the dealer I had purchased the vehicle from. Monday came and I then went to the dealer to have them fix this vehicle I had just purchased only 3 months prior, they looked at it and gave me a $700 estimate, knowing full well that this is a defect with the vehicle, but would not provide me with temporary transportation while waiting for the repars to be done. I asked that they put the old parts that had been replaced into the trunk for further investigation by me. Have done research on this on the internet only to find this a more common problem with this vehicle than had been imagined. Why must someone die before something is done about this defect with this vehicle???
Repeated stalling in traffic. Typically occurred approximately two minutes after start-up. During one cold start the engine miss-fired and back pressure popped off the brake vacuum line, causing loss of brakes. Was diagnosed first time as mass air flow sensor. Problem recurred, diagnosed as fuel pressure regulator. Shortly after, flooding and sparkplug fouling occurred due to damaged intake manifold leaking coolant into cylinders. While two of the components are the same as recall campaign 04v090000, and gm recall 03054b, gm says this VIN [xxx] is not included. *ak updated 07/30/2012 *js information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
The engine exploded upon starting. The vehicle was towed to the dealer. The dealer told the consumer there was a recall on the park avenue which had the same engine as the bonneville, but there was no recall for the bonneville. Please describe further.
Consumer bought the bonneville in august, since then it has been in repair shop 7 times. The first four times were for transmission failure. They replaced the pressure control valve and throttle body. The remaining visits were for 4 fuel injection system failures, injector coil failures melted 4 spark plug wires. Also, water pump started leaking.
Consumer states that while driving the vehicle and no warning the intake manifold blew causing the vehicle to be non drivable. Dealer notified. Ph
Intake manifold failures are a known problem at gm, and nothing is being done about it. My wife was driving home in rush hour traffic, at a speed of apx. 65 MPH, on a four lane highway, in the center lane when the failure occurred. The intake manifold failure causes the engine to stop, and loss of steering and braking then occurres. As she proceeded to try to get the car off of the highway, several cars skidded to stop as the car slowly made it's way off of the highway. It had to be towed to the dealer for repair. I have been informed that general motors is aware of these intake manifolds failing, and that it is a known design defect. They see a lot of 3.8 engines with this problem, and are doing nothing about fixing it for the consumer. My repair cost me a little over a thousand dollars. A lot of times, the entire engine has to be replaced because it is damaged by the catastrophic events that take place when the intake manifolds fail. We are very lucky that she was able to get the car off of the highway, despite the fact that several cars locked up their brakes to avoid collision with this disabled vehicle. We purchased the car new, and maintain it more than is required by the manufacturer. This intake manifold defect should have been investigated a long time ago, as I have traced owners of these vehicles having this problem since 1996, and possibly before. If nothing is done, then surely deaths will occur due to the series of catastrophic events that will occur due to this defective intake manifold, including loss of engine power, steering and braking. Dt
Fuel line broke, and started leaking ,could have started fire.
Upper intake manifold is leaking coolant onto engine while driving. Manufacturer was notified. *ak dealer replaced the upper intake manifold due to it being warped where it joined the throttle body.
Engine would not run due to coolant in cylinder/s, cost to replace plastic intake manifold apx. $900.00 the term degrade as used by gm should be defective as by all experience, an intake manifold has no moving parts to wear and the car was equipped with coolant which does not need replacingg until 150,000 miles or five years. There is no maintenace that any owner can do to prevent this from happening. If it happens when in traffic and the engine stopped, there will be serious safety problem. Gm does not want to take responsibility for a defect or design problem.
Antifreeze leaked from vehicle, dealer determined that plastic intake manifold melted, causing antifreeze to leak into engine. Engine needed to be replaced.
The plastic intake manifold has gotten a hole in it 2 times now. The first time was at 83000 miles and resulted in needing a new engine. The new engine had 16000 miles on it and after driving 19000 miles the same thing happened again causeing us to replace the manifold, head gaskets, bolts and starter. It has cost over 2000.00 for the same defective plastic peice. The garage said to get rid of the car because it is just going to keep happening and there is no way of telling ahead of time that it is going to happen. We just paid the car off and cant take on new payments so that is not possible. So someone needs to get gm to fix their defect so we don't have to keep going through this. We contacted the gm customer assistance center and they would not acknowledge a defect or problem. We called the dealership and they said they had received a bullitin on it and said what to check but would not help with the cost either. Neither were any help at all. But they were sorry we were having difficulty what a big help.
Consumer stated the upper manifold and gasket had to be replaced.
Intake manifold blew up and fire started in engine. Claim number 40-2468-798.
It would seem that an intake manifold leak so sudden & severe that it kills the engine at speed could potentially cause a person to loose control of the car. No advance warning, other than starting to run rough, then filling the engine so full of coolant that it killed the motor & locked it up, preventing the starter from cranking the engine over.
While traveling at highway speeds engine check light came on, and temperature gauge went to high. Consumer drove car to a near by mechanic, and they poured antifreeze into engine compartment to cool vehicle down. *ak consumer stated, while he started the engine, white smoke poured from the exhaust, towed the vehicle to the dealer, dealer replaced engine but while testing the engine, the same problem appeared, dealer aware of the service bulletin, the upper intake manifold was replaced, which caused the problem.
Upper intake plentum failed, causing coolant to leak internally into the engine, this caused some cylinders to shut down and the car to run rough. When I contacted the dealer, I was informed that this was happening to this vehicle at various mileages. I was also told that part of this assembly was made of plastic rather than cast metal and this could be cause for failure due to exposure to high tempuratures. I was lucky that I was not far away from home when this engine failure occurred.
Car would stall hard to start ground problem blamed for poor gas pressure to carb, also could of been problem that failed the starter, engine lite would go on then off, door locks would not work. Problem was intermitten until the last time when the ground problem was found. Major expense to me not happy it took this long to find problem. As of today car seems to be ok
Fuel guage indicator level misreads the amount of fuel in the vehicle. Dealer has inspected vehicle and corrected it, but, the problem still exists.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1998 Pontiac Bonneville?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history