2000 Pontiac Montana electrical problems

Filed Jul 21, 2014 · Driver assistance, Electrical · 182,000 miles · ID

The car would start missing, like there was a short in the electrical and then the car would shut off the and I would have to sit there for 1 to 2 hrs and then it would start and run for a while and shut off again, the last 2 times this happen I had to have a tow truck pick it up and take it to my home where it has sat ever seance 2008.

Filed Apr 13, 2011 · Electrical · 172,000 miles · MN

We have a 2000 pontiac montana, my little girl and I were driving home from the store that's 15 min from home I noticed a burning smell, then smoke came pouring out of the dash buy the time we got out the security lite was on check motor light was on and it would only go ten miles an hour, so the next day I took apart the dash and found the wiring burnt up, and now I cant even start it so im stuck with a broken down van, that I just had a $600 dollar fix so now im out $600 and a van. I cant fix it because I don't have the money too so all old parts are available for some $$.

Filed Sep 9, 2010 · Electrical · 158,000 miles · MI · fire

Tl* the contact owns a 2000 pontiac montana. The contact stated that after driving and parking the vehicle for 10 minutes she noticed smoke coming from the dashboard. She tried to put the fire out with water but when she did flames started to come out of the vents. Wires were melted and the heating system and the cd player were also destroyed. The fire department responded and put the fire out. The police were not called. The manufacturer had not been contacted at the time of the complaint. The failure and current mileages were approximately 158,171. The VIN was unknown.

Filed Aug 12, 2009 · Electrical, Locks · 113,546 miles · CA

Tl*the contact owns a 2000 pontiac montana. The contact stated that the power sliding door does not lock. The dealer stated that no recalls were available. The failure has been ongoing for five days. The vehicle was taken to a body shop, but the mechanic could not determine the cause of the failure. The mechanic removed the door from the vehicle. When it was placed back on, the failure stopped for only a few days. The failure mileage was 113,546 and current mileage was 113,600. Updated 09/01/09. *lj the power doors would not lock. Updated 09/04/09.

Filed Nov 27, 2006 · Electrical · 87,000 miles · CO

Dt*: the contact stated while driving various speeds, all of the instrument cluster panel warning lights illuminated. The vehicle was inspected by a dealer, who determined the ignition switch needed to be replaced. After the replacement, the problem persisted. The vehicle was again inspected by the dealer who performed a diagnostic test, which did not produce any failure codes. The manufacturer was alerted.

Filed Feb 14, 2006 · Body, Electrical · 60,000 miles · GA

After two recalls from gm over several months. Dealer avoids repairs. Right elec. Sliding door recalled for hazardous inside handle. Could brake fingers. No correction was been attempted. Dealer avoids ordering parts so replacement can't take place.

Filed Aug 8, 2005 · Acceleration, Airbags · 37,182 miles · OH

New march 2000. Van always receives regular maintenance. The following is a history of repairs: 4/00 windshield wipers would not return to closed position - dealer fixed. 12/03 (37,179 mi) tps sensor breaking down causing idle to surge - dealer replaced throttle position sensor, completed reprogram ($255.14) 12/03 (37,182 mi) air bag light coming on - dealer replaced right front seat belt buckle under warranty (labor $134.51). 12/27/03 (37,555 mi) was in collision (other vehicle pulled out in front of me as I was coming down small overpass, he was cited). My van sustained $4,500 in front end damages, his car was totaled. My air bags did not deploy. No one injured. 5/04 (40,983 mi) rear hatch would not stay up - dealer replaced both hatch props ($258.73) 7/04 (43,437 mi) van was "shifting" hard, would not pick up speed correctly. Dealer replaced pressure control solenoid, flushed transmission and replaced front brake pads and machined rotors ($986.48). 12/04 (48,284 mi) van would not start on several occasions. Known independent repair shop replaced battery, checked oil leak. ($114.90). 4/05 (51,646 mi) low coolant light /check engine light coming on. Same independent repair shop replaced intake gaskets, thermostat, spark plugs and filter, and oil pump shaft 0-ring. Corrected air bag light ($791.03) 6/05 purchased new tires and were told needed all new tie rods. We went on vacation july 9, 2005 (ohio to virginia and back). Concerned that the van shook terribly when applying the brakes on long downgrades through wv and va. We were towing nothing. The very next day, after returning home, the van would not start consistently. 7/05 (56,533 mi) told that the computer crashed. Same independent repair shop replaced ECM, crank sensor, ign module and machined front rotors which if you remember were just done in july of 2004 ($982.02). After researching the track record of pontiac montana, have found that many consumers having the same problems.

Filed Jan 31, 2005 · Airbags, Body · 88,852 miles · CA

The door comes unlatched from the pontiac montana mini vans w/o power slider also. Subsequently my van door passanger side came open slamming off half on the road and then remained attached to the top but the track wheel snapped off, making it inpossible to put on with out tools and the muscles to even lift it.

Filed Aug 31, 2004 · Electrical · CA

I would like to report a possible manufacture defect of my 2000 pontiac montana. There was electrical damage within the engine compartment due to the factory (where the vehicle was assembled) miss routing of the harness from the positive cable of the battery. The harness was found, by the mechanic, to be routed over the air conditioner, which in-time burned through to the bare wires, which in-turn shorted out causing damage to the PCM and battery plus burned out most of the wiring connected to the positive cable of the battery. According to the mechanic who preformed the repairs, this problem appears to be a manufacture defect and considering the year and mileage of the vehicle this should not have happen. The PCM, battery and wiring had to be replaced, with new harness; in addition the mechanic had to re-route the harness under the engine in order to prevent it from burning up again in the future. The vehicle would not start and had to be towed to a local pontiac dealer. Total repair bill $823.00 not including towing.

Filed Feb 17, 2004 · Electrical, Engine · OH

Gas gauge fluctuated and antifreeze leaking. Diagnosed as leaking intake manifold gasket and wiring harness for fuel assembly was corroded due to exposure to moisture - repair bill $1400.