2017 Prevost H3-45 technical service bulletins
194 technical service bulletins and manufacturer communications cover the 2017 Prevost H3-45.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The gasket thickness was increased from 1.5 mm to 3 mm to prevent interference between the collar ends,...
- Sway bar collars improvement
- Sway bar collars improvement
- H3 lavatory fan retrofit kit
- Kit power steering tank convertion cummins to zf with D13 engine
- Improved bearings are now available to replace the original bearings used on some Prevost vehicles idler...
- Electric fan drive cooling system conversion with bosch alternator
- ELECTRIC FAN DRIVE COOLING SYSTEM CONVERSION WITH DELCO REMY ALTERNATOR. REVISION : i Note added regarding...
- Steering gateway.
- Air Tanks Draining Sequence
- Air Tanks Draining Sequence
- P20EE (diagnostic troubleshooting code) SOLUTION
- Air Tanks Draining Sequence
- Halogen to LED fog light replacement kit
- Tag axle hub flange - alternate cap screw
- STEERING GATEWAY, revision A : Cancel watch dog removal from EFD part of the instruction
- STORAGE AND STARTUP GUIDELINES : part number updates
- Steering gateway
- Central HVAC merv filters installation
- H3 series envirocare - ions air sanitizer
- Brake pedal seal plate installation kit
- P20EE (diagnostic troubleshooting code) SOLUTION
- STEERING GATEWAY schematic
- Bosch to delco remy alternator installation, H3-45 revision : e
- SCR converter replacement - aftertreatment system
- Bosch HD10 alternator diagnostic guide
- Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair – From US10 to newer...
- Lavatory compartment sliding door latch improvement
- Ront & tag axle – unitized hub bearing end play verification and replacement
- Eberspacher preheater installation
- P20EE (diagnostic troubleshooting code) SOLUTION
- H3 series envirocare - ions air sanitizer rev a
- Central HVAC merv filters installation reva
- Storage and startup guidelines
- Tie rod 610052 first installation instructions
- Introducing a new engine coolant into prevost service center network
- Volvo i-shift transmission replacement - difference between connections at the top of the oil filter housing
- Rev A: Mention added concerning DDC Series 60 engine SCA requirement
- SCR converter replacement - aftertreatment system
- Introducing a new engine coolant into service
- Revision : A Torque value reduced
- Engine oil & filter change intervals - volvo D13 engine, from US10
- Lavatory fan retrofit kit
- Prevost aware adaptive cruise braking (ACB) FLR20 radar sensor replacement kit
- Prevost driver assistâ¢
- H3 driver’s partition lite installation
- Uv lights installation in a/c compartment
- Uv lights installation in AC compartment
- Sigma passenger seats partition kit
- PM sensor has detected battery voltage is too high US 2017 emission level Prevost units with Delco alternators
- Storage and startup guidelines
- Engine Exhaust Gas Recirculation Differential Pressure
- Jerky, noisy or hard to turn steering gearbox
- General hoisting and towing procedures
- Electric fan drive cooling system conversion with delco remy alternator
- Electric fan drive cooling system conversion with bosch alternator
- Storage and startup guidelines
- Plexiglass Shield Behind Driver H3 Series
- Accessory air filter replacement Replaces 642192
- Prevost vehicle disinfection procedure
- Baggage door seal replacement
- Hand sanitizer dispenser installation
- Prevost vehicle disinfection procedure
- Storage and startup guidelines - all prevost vehicles & volvo 9700
- Repair instructions to address fault codes P029800
- Repair instructions to address fault codes P040200 Engine Exhaust Gas Recirculation 1 Valve PositionFlow...
- Repair instructions to address fault codes P052400 Engine Oil Pressure Too Low
- Repair instructions to address fault codes P054415 Exhaust Gas Temperature Sensor Bank 1 Sensor 1
- Repair instructions to address fault codes P105998 Gearbox Oil Temperature Sensor
- Repair instructions to address fault codes P107017 Gearbox Brake Valve (VAGB)
- Repair instructions to address fault codes P107575 Clutch System
- Repair instructions to address fault codes P10CE97 Reductant Return: No Flow Detected
- Repair instructions to address fault codes P203115 Exhaust Gas Temperature Sensor Bank 1 Sensor 2
- Repair instructions to address fault codes P203F00 Reductant Level Low
- Repair instructions to address fault codes P204713 Reductant Injection Valve Control Bank 1 Unit 1 –...
- Repair instructions to address fault codes P204A13 Reductant Pressure Sensor
- Repair instructions to address fault codes P208464 Exhaust Gas Temperature Sensor Circuit...
- Repair instructions to address fault codes P20E892 Reductant Pressure Too Low
- Repair instructions to address fault codes P242A15 Exhaust Gas Temperature Sensor Bank 1 Sensor 3
- Repair instructions to address fault codes P256000 Engine Coolant Level Low
- Repair instructions to address fault codes U029D00 Lost Communication With NOx Sensor "A"
- Repair instructions to address fault codes U029E00 Lost Communication With NOx Sensor "B"
- Repair instructions to address fault codes U02A200 Lost Communication with Reductant Quality Module
- Added: Power cables for L.H. side alternator & fan drive breaker box
- Repair instructions to address fault codes P008A-00; P0087-00
- Repair instructions to address fault codes P207F-00
- Repair instructions to address fault codes P207F-00; P20EE-00
- Repair instructions to address fault codes P021700 Engine Coolant Over Temperature Condition
- This instruction sheets explains how to replace the fuel tank on H-series vehicles
- Revision : Mention added in the instruction sheet stating to disable "Prime"
- Revision : Mention added stating to disable Prime.
- This instruction Sheet explains how to install a seatbelt cutter in the driver's area
- This instruction sheet describes how to cut the air dryer bracket, to avoid dirt accumulation, and applies...
- This Instruction sheet explains how to perform an Electric Fan Drive Cooling System Conversion with Delco...
- This instruction sheet explains how to install the electric fan drive cooling system conversion kit with...
- This instruction sheet explains how to replace halogen fog light to led's
- The intent of this procedure is to guide you through the steps required to program a MCM especially for...
- This instruction sheet explains how to relocate the wheel chair lift parcel rack fan
- On vehicles with active code P20EE, perform the following checklist and operations.
- This Instruction Sheet explains how to perform the first installation of Tie Rod 610052 on Prevost...
- Electric fan drive cooling system conversion with bosch alternator - H3 series US10 cooling system
- Electric fan drive cooling system conversion with delco remy alternator
- MP-1000 multimedia player installation
- Intelligent sleep mode installation
- Prevost aware adaptive cruise braking (ACB) - FLR20 & FLR21 radar sensor alignment
- Vehicles identified below are compatible with a new tie rod design
- This instruction sheet explains how to install the Tie Rod 610052.
- Wheel fender stainless steel protector
- This instruction sheet shows how to install a flap over the diesel filling cap.
- Isri seat belt with sensor installation (accessory kit 23687694)
- This instruction sheet explains how to perform alternator conversion, from Bosch to Delco Remy, on H3 vehicles
- On the independent front suspension (IFS) of the vehicles affected by
- This instruction sheet explains how to convert H3 SERIES US10 vehicles equipped with Bosch Alternators to...
- This instruction sheet explains how to install a GM Glove box Lock on H-Series vehicles
- This instruction sheet explains how to install an ELD interface on OBD vehicles
- This instruction sheet explains how to install a flap over the diesel filling cap
- This procedure explains how to program a MCM especially for the control of the electric fan drive, as...
- This Special Bulletin explains how to perform the replacement of the SCR tank, when authorized.
- This Maintenance Information expains how to adjust p/n 660865, 660699 draglinks
- This Maintenance Information is published to answer some questions regarding the inverted or ?trailing?...
- This Instruction sheet explains how to install Ism (Intelligent Sleep Mode)
- This instruction sheet explains how to convert H3 SERIES US10 vehicles equipped with Bosch Alternators to...
- This instruction sheet explains how to convert H3 SERIES US10 vehicles (equipped with Delco Remy...
- This instruction sheet explains how to replace fenders made of fiber glass with Aluminium
- This Service Center Instructions explains how to install the Prevost Ultimate Entertainment System
- On the vehicles affected by
- This Warranty Bulletin explains how to update the VECU (Vehicle Electronic Control Unit) parameters to...
- This instruction sheet explains how to install hatches with fan on H3 vehicles.
- On the vehicles affected by
- On the vehicles affected by
- This Maintenance Information presents information about the Bitzer A/C compressor oil change interval and...
- This Maintenance Information explains how to remove and install the Bosch HD10 (120A or 150A) alternators
- This maintenance information explains how to tow and hoist Prevost vehicles.
- This Maintenance Information presents information about the removal or installation of the Lang KK73.1...
- This Maintenance Information presents guidelines to help with the diagnosis of the Bosch HD10 alternators
- This Mainteannce Informaiton presents the latest engine oil & filter change intervals for the Volvo Engine
- On the vehicles affected by
- This instruction sheet explains how to install an ELD interface kit on Pre-OBD Prevost Vehicles equipped...
- This instruction sheet explains how to install and adjust drag link # 660699
- This instruction sheet explains how to installa parcel rack door kits
- This instruciton sheet explains how to relocate the RV-3 Valve
- This instruction sheet explains how to optimise the operation of the lavatory fan
- This Maintenance Information explains how to inspect the Fuel Tank Cradle Mounting Screws on a yearly basis
- This instruction sheet explains how to install the Volvo Electronic Logging Device (ELD)
- On the vehicles affected by
- This conversion kit explains how to to disable the ACB radar.
- On the vehicles affected by
- This bulletin explains how install an extension to the linear thermal detector (LTD) over the alternators
- This Instruction Sheet explains how to install a wheel fender stainless steel protector
- This Maintenance Information explains how to remove and install the Bosch HD10 (120A or 150A) alternator.
- This maintenance information applies only to vehicles equipped with 19000 lb Independent Front Suspension...
- On the vehicles affected by
- On the vehicles affected by
- Explains that improved bearings are now available to replace the original bearings used on some Prevost...
- The Beru sensors used on Prevost vehicles to monitor tire pressure (TPMS system) are being replaced by new...
- Use this procedure when a suspension height check or adjustment must be performed.
- This Maintenance information explains that on vehicles equipped with Ramco rear-view mirrors in winter...
- On vehicles operating in muddy road conditions, a road material ring may accumulate and harden inside the...
- Communication letter from Accociate Administration for Enforcement, the federal safety agency From Prevost...
- This procedure explains how to perform a STARTER REMOVAL AND INSTALLATION, and does apply to Melco 105P70...
- This Maintenance Information shares information about the Bendix M-32QR valve replaced by M-40QR model...
- This Instruction Sheet explains how to assemble the BENDIX FLR10 AND FLR20 RADAR SENSOR ALIGNMENT TOOL
- This Instruction Sheet explains how to install the AWARE ADAPTIVE CRUISE BRAKING (ACB) FLR20 RADAR SENSOR...
VIN decoder
See the problems and recalls for an exact car
Buying a used 2017 Prevost H3-45?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history